Olympus M100 Manual.pdf

42

Transcript of Olympus M100 Manual.pdf

��

��

�������������� ������������

�������������������

��������������������������������������� � �������• ��� !�"�� �� � � � #�

• ��"$��"������"�%�"��� ��� � � &�

• ���� �����'��������� � � (�

��������)����� ��� ������%����

• ���"� �"�����%���� � � � *�

• �"$���"�����%���� � � � +�

��������,)����� ��� ��� "�!� ���

• ���"� �"���������� � � � -�

• .��� ��������/��$���"���� � 0�

• �$���"������ ��������� � � ��

• .��� �������� � � � �

• � ���� ��/�1�"����2 ���� � ,�

• ����3����������� � � � #�

• � ���� ���!4��������� � � &�

• �$��! 5��� "�!� ��� � � (�

• � �6���$ ����� � � � *3-�

• � ���� ���� 5����$� � � � 0�

• .� ����7��� ���� � � � ,��

��������#)����������"�8���"$��"���

• ��������"�� � � � ,&�

• 7 �5�����/��� ��������� � � ��o ����� � � � #,�o ��� 3�����3� ��� ���� � � ##�o � ���� �����9� � � � #&�o .��������9� � � � #+�o �����/�1�"����������� � &��o ����:������:�� �� ������ &�

• .� ����� � � � &,�

��

������� ��

����������������� ������������������� ����������� �������������������������������������������������������������������������� ������������������ �������������� �!�����������������������"���������#��������$������������$��������������������������������������������������������������������% ���������������������������������������&����������������������� ������������������������������������!���������������!�����������!�������'��������������������� ������������� $����������������!���������� ���������������������������������$������������������������'�������������������������#���������������������������� ������� ��!���!���!� ����!��$����������" ���������6�% �� �� �������$����"$���;���(!� ��������������������������� ��������������)�������������� ��������$�������������������������������������������������(� �'������������������������������������������������������������������ �������������� ������������ ���������������� �������������������!���������������� ���������� �������������� ���#������������������������ *��� ����������+,-,�.����/0��%����.���1������� $�2��-+�,3�-���,4-�,453�-���,4-�3-/4��(6��7���������������������������� )��������������!����������������������������������������������������������������� ��������������������������������������������������

��

����� �������� � ��� ���

���2��$��� % ���"���<� �"� �2���$�)��#-=� ������$)�,-=� �.�!�$)��038,=� �.���$�)�-(��6�;�� ���� �����9�����"���)� � ,����� ��>�" ?� �����9�����"���)�� � ,����� ���� ���� ������)� � � �� 4���7*#(@+�,�������

�������A�,;��������1�"���� � �)�� � � �5 �����B����6�(;+=�!������ �A������������!��"$� ���

�5 �������A� ����!������ ������ 5� �7 �5)��� � � -;,��5�!�� ����8�;,��%����� �!�� � � � C�!!�(������ ����"$�����5��$���� �����3 ���������D�� � � � �

������!� !��'�����������2��$��� % ���"���<� �"� ���� ����.��!)� � �.,0E��3������������������3���!�7����@���.��!�� �� � � � �

1�"����2 ��)� � ,(F�E�38,=�5��$�38,=�"�%%�/�,=�"�%%�� � � �� � � � � �2��� ���� ��2 ��)� ,(F�<�8&=�5��$�8&=������8�%������'��"9�" ���"����� 5� �� !)� � ,(F�<�,������5��$������/�%�������������!��

��

�!!��� ����8����� �����'����������� �������������5��$�"$���"���! �5)�� � � � �,���� ��������B��)� � � � � � � �7������� �����3 ���������)� � � � � � �*�����3 ���2 ��)� � � � � � � �2*(�2�! 3����� ������������� )� � � � � � ���>����"�����������% �2�! 3����� )� � � � ����2�! 3� "����4�"�� ���� ��� �A�� 5�� ���� �)� � � ��,�2�! 3� "��>�? ���� ���� ��� �A�� 5�� ���� �)�� � ��,>�#;(=�2�! ��G�$ ���� ��� �)� � � � � �.(���&;(=�2�! ��G�$ ���� ��� �)� � � � � �.(��#;(=�2�! ��7���<��G�$ ���� ��� �)� � � � �.(�7�&;(=�2�! ��7���<��G�$ ���� ��� �)� � � � �.(7�38,=�1�"����2 ��)��C� �!��� �% ��A�� �"�%%�D� � � �2#*� �,=�"�%%�% �38,=�1�"�2 ��)�� � � � � �2&*�38,=�"�%%�% �38,=�1�"�2 ��)� � � � � �2&,�,=�2 ���� ���"� ��1�)� � � � � � �2+*� �38,=�2 ���� ���"� ��1�)� � � � � �2+&�2��� ���� ��2 ��)� C7 ���� ����"��!��H��"9�� ���"��D� �2+07�8&=�����H��"9�� ���"�)� � � � � � ����0�8&=��������H��"9�� ���"�)� � � � � ����-�� 5� �� !�,(F�<�,������58�����/�%������������ � �.#,�� 5� �� !�(�F�<�,������58�����/�%������������ � �.##�����������������������������

�� ��

�� ���

����

�����

��

�������

����G����I�����$�����"$�������������"� �"����������"�;��� �������6����9���� � �!�"���$�� ��9� %����"� �"����$ "9;��

• >��7���7�G�7�>����7���������>G�����������>�����>�������2����;�

• ���������������������������� �������������)� $���������������������� ������������� � ������������ ��#������������������������������� ��������� ��������������������

• 2��������������!������������������ ������������������� �����������������#���������

• 8������ ������������� ������ �� ��9������ ������������� ������ ����� ����G��� %���� ��!����������� �������C���D�!�?�"��5���� �!�"���$�� ��9� %����"� �"����$ "9;�

• 9�������������������������$�������������!�����������!������������

• 9������������������������!���������������

• 7���#�����������������$���������������!�������������������� ��������������������������������������

• 9������������!�������� �������������������:������������!����������������������

• 9�������������#�������� �����������

• 7�����������������������$�����������������;������!������!�������������������������� ����������

• ������!����������������� ��� ������������������������������,�������

• ������!������������ ����������,�������������

���� ��

��

���.�>����I�����$�����"$���������6��� ��"��!�% ��" �!��� ���5$�"$�����!�������$������:����9:�$ ������!� �$� �" �� �����;�

• � ��J���� %�5��� �����$�����"$����5����"������� � ���!���������������$�������������$�������������� �� ���������� ����� ����<���� ������������ .����$� ���������$� ������� ����� �'������� �� � ��� ������������!��� ��������<�����=3,>������>�?���7�� ���������������������� �������<��$������������������������������������ ��������������������!���������� ����

• 7�������'�������������� �����������������������������!���������������$�������� ������������������<���� ��������������������<�����������������������������!���������$��������������� ����$�����������$������������$������������������������������������������������������� �!�������������<�������������������������������������������!���������

o �������������<������������� ��������� ������������������������ ���������������������������������

• ����������������� ������ ��� ������� ����� �� ������ ��� ����������� ������� ��� ������!����� ����������������� � �����������

• .������ ����� ��� !����� ����� �������� ����������� �������� �� � ������� ���� ���$� �����$� ���� ������������������9������ ��������������������� ��� �� �������� ��� ������ ���� ���� ���������� ��� �������'����������������������������� ��� ���� ������������!�����������������

• 9�����������!������������������������������������� �����3�>���

• ;��������������������$���������� ����$���������!����������!������������������ @������

• �8��������� ����������!����������������9����������8������������������������������������$� ����$���������!�������������A#�������8����������������� ���������������������������������������

• ;�����������������������������!��������������� ���������������% ����(���8���������������2������ ������������������������������ ��������� ������������������������� �����������������

• B����C����7������������������������������ ������������������������9�����������������������!����������C���� 7���� ������ ��� ������G���!�% ��� � � �����������% ���6���!3���!� ����"����������!�� �?����% ��8� ���� ��% ������ ����?�"����;�

KKKG���" �� ��������� �� ��"��� � ���%���!� �$� ��5$�����������$����'�������;KKK�

• B����������������������!� ������������������!�����������

• B������ �� ������$�����$�������������������!� ���������������������������������(!� ��!��������������������������������� ��'�������!�������������������

• 2����#���������!�����������������������%������������������������ �������� ��

• 9���������������������������!���������!�������������� �����!������9����������������������� ������� ������������������������!����������1����������� �������������������������

• %������� � �������$�����$���� ���#�����������������������������������8����������������!�����!�����!������������������������������������������������������

�!

"����� ��#��������

B� 5��!��� %��$��� �� � �� ��� �� %��$�������� �'�� �!�� ����� ����� ���%������!��%%�"������� % ���"�� %��$���<� �"� ;��

����G����7����>������;����"� �"���� !)�����,/@���!������������������!��������� ���������������������������!���'������������������� ���������������,���������������8��������!���������������������������������������������������������

���� ��

��

Power Cord – AX32 25’ – 12 gauge M-F Plugs

Power Cord

�$

,�;�.��� ��������/��$���"����<���A�����������)�• 8���������,��������������!��������������������������������������������������������$��5��� �

����� ��� ��"��� ���<"��!�#�°°°°�;�• �����������������������������������������������������'������������������!�������������������������

���������������������!����� ������������������� �����������������$��������������!����������������$����������������� �����������&��������������������������������������������#������������

• 8�!�������������������� ��������������!����� ��������������������!���������������������������

������������,�;�.��� ��������/��$���"���7����� ��A����� ������� 3�����������)�• ������������������������������������ �����������������$��������������������������� � ���������� �

��������������������������=.���D��!���������������������������E����8�����������������������?��

��$���"������!������)�

• ;���������������������������������������������������

• 8���������������������������������������������'�������������

• 7��������������������$������������������������ ��������������!����������$�����������������!�� ��-*��=�����'������������������4��F+�<����������������������������!�����?�

• ���������������������!����������������������'���������!���������������������,/4*������������������������������������!�������!��������������������$��F,�����������������!�� ���������

• �%���% ��$�5��� � �����5��$�� �"$���"������!��� �!:�����������?���$��"$���"���%��!�$ �������!���$��� ���� �����9;�

��

� �

Proportioning Valve

Chemical Feed Hose

Add appropriate amount of chemical to water in solution tank

Pour appropriate amount of hot water into solution tank

����

2 5�� ��$������$����� �������)�

• ;������������������������������������� �� �����������������������������������������

• 2�����!�������������������������

• .���!����������������������� ��������������������������������� ����������� �� ������������������� ��������B���C2�! 3� "���������7���D�����������+�������������������������������$���!������������������������*�������+,5*�����;������������������ ��!������������������������������������������������� ������������������������

• �����#����*���� ����'�������F,������������������������������!����$��������������������������������!�����������������������-/*���

• ��������������������� �����������������!����!����������������� ����������=�����������?����������!�����������������������������

• ������!��������������$����'������������������� ����������#��������������������������������������������@������������$����������������������������������������������

• �������� ��������� �������� ������������� �������'��������� ��� ����������������� �������������"��� ���$� �)����������������������

Metering Tip Kit – PDE001

Turquoise Tip Dilution 256 - 1

Red Tip Dilution 85 - 1

�78���1�;�

��A�7�(1�9712�7�G�;(�A.����H�F�:(1���������=;(�7�?�

�(G� ��3������������������=+,5*�?�

�;(G:A� ��+������������������=3,�*�?�

�G>HG����� �;(������������������C,(*)D�

87GB� ��5/�����������������=�5�*�?�

17:���I12A� ���������������������=�,-*�?�

I;�%G� ���,�����������������=��+*�?�

;A9� ��/�������������������=-/*�?�

%�7�A� ��5/������������������=53*�?�

:;AAG� ,���������������������=4+*�?�

I12A� ,�/�������������������=/�*�?�

"A11�%� 3�5/������������������=3+*�?�

I1(�B� /���������������������=,4*�?�

82;81A� -�/�������������������=�/*�?�

:;("� ���/�����������������=��*�?�

G���78� �4�,/�����������������=-*�?�

Proportioning Valve

����

.��� �������)�

• ����������������������������������������*�o ������������(������%�����.�� �������������!����������=��������'�������������������������

���������������?���o ���������������������������������������!����������$���������������������!������

• ����!��������� �����������������������������������������#������+�°���• �������������������=� ���������������J(6,��K�(6,,?���������� ���������!�������������������������

� ����������������������������������������������������� ��!4�����$��5��� ���?�������$��� ���� �����9)�

• ������������!�������� ��

• (�)���������������������������������������������� �����������������������

• .�������� �������������������������������������������o ��������� �������!������������������!����������o ��������� �����������������������!����������

• .�������������� ������������������������

• ��������!�������� � ����������7������������������������!���$������������������������������������������!���$����������������� ���������������$������������� ��������� ���������������������

���

� �

Connect the Auto-Fill Water Supply Hose to Solution Inlet (Male quick connect on the front of the machine.) 3/8” id X 25’ with F Quick Connect & F Garden Hose Fitting

Chain

Float Valve

Float Bottle

Connect the Auto-Fill Water Supply Hose to a faucet and turn on the water

Chemical Feed Hose

����

#;�� ���"�� �� %�� ���� ��2 ��)���������������������������������������������������������=������'���������������������������������������?�����������������������������������������������'���������������������������������%���� ���������� �����������������$���������������������!�������������G����������������)�������������$������������������������������������������� ���������������������������������������'�������7������������������������� ������$���������!�����!���������� $������������������������������������������������=���!��������������������?������������$������$�����������������������������������������F����������������������������������������������������)����������������������!�����������������������!���������������������������������������7�� ���������������� ��!�����������$����������������� ��������������������������� ��������� ������������������������������

�����������&;�� ���"�� �� %�1�"����2 ���)�(����F,E�#�,/@�C�������������������!�������������������,E������������,/@�������������������������������C����I�� ��������������������������������������������!�����������F,E��������������������������������������%�������� ���� ������������$����� ����������!���������������G�����������%����������������� �����������!������ �������������������������������� ����$������������������� ��!������ ����������!��������G��

�������������

Vacuum Hose 1-1/2” x 25’ with 2” & 1-1/2” cuffs

Connect the male end of the HP Solution Hose Assembly to the female solution outlet fitting on the machine. Connect the female end to the cleaning tool.

HP Solution Hose Assembly – AH79D 1/4” id X 25’ with M-F Quick Connects

����

�(;����� ������� �����3 ����������3�� ���"�� �� %�����3 ���2 ��)����������������������/�@������������3F+E��������������

• ;�������������������������������������������������� ���������������������

• ����������������������������������������������

• 8���������������������������������������������������������������������������� ���!���� �������

• .������������������������������������������������G���!�% ��� �� �� �?����% ���6���!3������ �" ?� �����9�!� ����"����������!�� �9����% ��8� ���� ��% ������ ����?�"����;��%�������� ���� ������������$���������!����������!�������������G������������

• 7 �� ���� �� ��5�����������5��"$������������3 ���$ ������" ���"��!���!�$���6���� ���!�� ���� �� �! ���;�

��������������

(�;�.��������9��$�� %%)�7�������'������!�������(���8������. ���������������������!�����������$���������������������������������� ��������������%��������������� �����������������������$���������� ������� ������������������������!�����������!����������� ������������������������!����������������������� �������������������������!�����!����������������������������������%��������������*�

• 7�������� �������������������!��������

• 9���������������� ���������o �����������������!�����!�����������������������o ���������!����� ������������������������������

• ��������������������������������������!������� �������!�������� ��������������������7�����������������������������������!������������� $����������������� ��������������������������� ��������� ������������������������������

����

�Pump-out Hose – AH65 3/4” id X 50’ with M-F Garden Hose Fittings

Connect the Female Garden Hose Fitting end of the Pump-out Hose to the outlet fitting on the back of the recovery tank. Place the other end of the pump-out hose in a sanitary drain.

�Float Shutoff Assembly – NM5037 �

9������������;������ ������

����

*;�� ���� ���!4�������)��$��� ���� �� %��$��������� ���!4����6��;������������������������������������ ��������������������!���������������������������!������������������� ��������� ������������������� �������������������������#�������������������������$� ���������������������������������������������������������!�������!�����������������!����)�����������!��������������������!����!��������������������������������� ������ ��!������!������������������������)��������������� �!� ���������������!�������!������������������������������������ �����������������������������)�����7�� �����������������������������)���*�

• .�����)���������!�����!�!����!��������������������������������=2������������?�

• 1������)�����������������!�!���!������������������������������������������� ���������������������������)��$��������-��4$�0/�/��������+$��������������<�������������������)�����������������������!��������������������������� ����=-�$�0/�K����?������������������� ����������������!��������������������������� ����=�4$��/�K��+?�������������������������<�����������������<���� ��������������������!�������������)������+��������������������������������������������������������������+�!����!���+��������+������(�����������������������4�!����!���4��������+������=.��������� ��!�?��9���������)����!����������������� ������=-���$�-��3�K�-��+?������������������������������<����9���������)����!�����������������������<��=-���/$�0/��/�K������/?������������������������ ���������2�������)��������������������� ��������������������������� ��� ���������������������!���������������!��������������� ��������� ����7������������$������������)���!������������)�������������� ��������� ������������������������������������������)���������!�������������!��������� ������������������������������������ ������������������ ������������ ���������������=������#������!��������������������)����������,�������?��7���������������������� ������������ ��$����������������� ��������������������������� ��������� ������������������������������

� �����������������������������!��������������!����������)���$�����������!���������)���������������������������������!��������������������������

Tee Jets and Vee Jets Equiv. Dia. Flow Capacity (Gallons Per Minute) Orifice Size in inches 40psi 60psi 100psi 200psi 300psi 500psi 1000psi 01 0.026 0.10 0.12 0.16 0.22 0.27 0.35 0.50 015 0.031 0.15 0.18 0.24 0.34 0.41 0.53 0.75 02 0.036 0.20 0.25 0.32 0.45 0.55 0.71 1.00 03 0.043 0.30 0.37 0.47 0.67 0.82 1.10 1.50 04 0.052 0.40 0.49 0.63 0.89 1.10 1.40 2.00 05 0.057 0.50 0.61 0.79 1.10 1.40 1.80 2.50 06 0.062 0.60 0.73 0.95 1.30 1.60 2.10 3.00 08 0.72 0.80 0.98 1.30 1.80 2.20 2.80 4.00 10 5/64 1.00 1.20 1.60 2.20 2.70 3.50 5.00 15 3/32 1.50 1.80 2.40 3.40 4.10 5.30 7.50

����

�$��! 5��� "�!� ��)��

• 7������������������� ����$���������!�������� ����� ���������������������)� ��������!����!�����������!���������������������� ������������$�����!����������������������#�����!�������� ��������������������

• %��������������������$������������!���������

• 7�������������� �����!������������������������!�����������������������$����������������!����������������!����������������������� ����������������������������������������������9��������������!������������������������'������������������������������������������

• 9��������������������������������������������������������������8���������������������������������������������� ��������������������������������������������������

• 7���������������������� �������������������������������������������������������������;���������������� ������������� ��=(���(�?�

• 9�����������������������������������������������������������

• 7��!�������������������������������$����������������������������#�����!���������������������

• 7�������������� �����!������<��$����������������������������� ��������������������������

• 7������!������������� �����!������*�o ��������!����������!�����D�GE������������� �����������!��������������������� �������o �����!��������$�������������������������������������������������������������������o ;�����������!������������������������������!������������������o ��������������������������������������������� �!����������������������������������������������

• 9����������������!���������������������������������������������

• ;��������������������������� ����������������� ���������������������������������;������������������ ��������������

• 9������� �����������!��������������������� ����������������������������� ��������9������������������� ���������������������������� ���������������������

• ;����������������������������������������#�������$�������$�������������������

����

Troubleshooting – Olympus M100 Problem Cause Solution Machine not Building circuit breaker tripped. Reset breaker or move cord to other outlet turning on - Faulty power cord Replace cord (AX32) No power Faulty switches or internal wiring Check wiring & test switches - Repair as needed * Solution Pump

Line pressure activating pressure switch. Spray tool to release pressure

not running Pressure Switch faulty. Replace pressure switch. (PF02090-120) Building circuit breaker tripped. Reset breaker or move cord to other outlet. Faulty power cord Replace cord (AX32) Faulty switches or internal wiring Check wiring & test switches - Repair as needed * Pump fuse blown Replace 5amp fuse Pump motor faulty Replace pump (AP25) Pump seized - trips breaker Repair or replace pump (AP25)

Low Solution Jets too large for pressure desired Check jets size & flow rates use smaller jets or lower pressure

Pressure and/or Jets worn allowing too much flow Replace jets Pulsation Solution inlet filter plugged Clean or replace filter Hose from solution tank restricted Repair or replace hose

Pump intake hose or fittings leaking Repair or replace hose. Tighten clamps or replace fittings

Filter screen or jets plugged on tool Clean out filter or jets

Solution tank empty Add water to tank - Check & repair auto fill assembly Pump faulty Repair or replace pump (AP25) Tool valve faulty Repair or replace valve Quick connects or hoses restricted Clean out or replace quick connects and/or hoses Can't connect Pressure in lines Release pressure solution hose Quick connects faulty Replace quick connects (AH101B, AH102B) to machine Wrong style/size quick connects Replace quick connects to match connects on machine

* To reduce the risk of fire electrical shock or injury repairs to wiring should only be performed by experienced service technicians. If you are not experienced in checking electrical wiring contact your nearest authorized service center to perform tests and repairs to wiring and switches.

���� ��

�����%����� �&�

�� �

Problem Cause Solution Pump-out Building circuit breaker tripped. Reset breaker or move cord to other outlet. not working Faulty power cord Replace cord (AX32)

Faulty switches or internal wiring Check wiring & test switches - Repair as needed * (NM5008)

Optional Pump-out pump faulty Replace pump-out pump (NM5053) Auto Pump-Out Pump-out pump clogged

Clean pump-out - Keep recovery tank clean - Use Hydro-Filter

Outlet check valve stuck Clean or replace check valve Discharge hose restricted Un-kink, clean out or replace hose Float switch stuck Clean switch make sure float slides up & down easily Float switch faulty Replace float switch (NM5054) Vacuum Building circuit breaker tripped. Reset breaker or move cord to other outlet Motor Faulty power cord Replace cord (AX32) not running Faulty switches or internal wiring Check wiring & test switches - Repair as needed * Vacuum motor faulty Replace vacuum motor (AV010) Loss of Vacuum motor faulty Replace vacuum motor (AV010) Vacuum Vacuum motor gasket damaged Replace gasket (PA010) Recovery tank lid gasket damaged Replace gasket (NM5059) Drain valve open Close valve Drain valve leaking Repair or replace drain valve (PEA11)

Vacuum motor hoses loose / leaking Reconnect or replace vacuum motor hoses

Vacuum hose or tool clogged Clean out vacuum hoses and tool Vacuum hoses or cuffs leaking Replace vacuum hoses, cuffs & connectors as needed Recovery tank full Drain tank Float shutoff filter clogged Clean float shutoff filter Ball stuck in float shutoff Repair or replace float shutoff (NM5037) Pump-out Check Valve stuck open Clean out or replace check valve(NM5052) Recovery tank damaged Replace recovery tank Chemical not Solution tank not filling Check & repair auto fill assembly feeding Chemical hose restricted Un-kink, shorten, clean out or replace hose Filter screen plugged Clean or replace filter (PDE100-11P) Optional Auto-Fill Low Incoming Water Pressure

Set chemical bottle on top of machine – Shorten Chemical hose – Find other water source.

Wrong size metering tip Change metering tip Chemical proportioner faulty Replace chemical proportioner (PDE61-22-3) Check valve in filter faulty Replace filter (PDE100-11P) Tool won't Jets clogged Clean out or replace jets spray - low or Inline filter clogged Clean out or replace filter uneven spray Jets worn Replace jets Jets not aligned properly Re-align jets Tool valve faulty Repair or replace valve Quick connects or hoses restricted Clean out or replace quick connects and/or hoses

* To reduce the risk of fire electrical shock or injury repairs to wiring should only be performed by experienced service technicians. If you are not experienced in checking electrical wiring contact your nearest authorized service center to perform tests and repairs to wiring and switches.

��!�

Problem Cause Solution Solution Tank Water source turned off Turn on faucet or find other water source not filling Float not on valve arm Reconnect float to valve arm - Adjust to proper height/level Float valve faulty Repair or replace float valve (NM5055) Optional Water hose restricted Un-kink, clean out or replace hose Auto Fill Quick connects faulty Clean out or replace quick connects (AH101B, AH102B) Solution tank Float too heavy/ Filled with water Replace float (PHY005-003) overflowing Float & chain tangled Make sure float chain free & hanging properly Optional Float too high Adjust chain to set float at proper level Auto Fill Float valve faulty Repair or replace float valve (NM5055) Chemical Jug Foot valve in Filter stuck Clean out foot valve and filter Filling with Foot valve in Filter faulty Replace foot valve and filter (PDE100-11P) water - Overflowing Optional Auto Fill

* To reduce the risk of fire electrical shock or injury repairs to wiring should only be performed by

experienced service technicians. If you are not experienced in checking electrical wiring contact your nearest authorized service center to perform tests and repairs to wiring and switches.

����

• Contact your distributor for additional troubleshooting assistance, to order parts, or for advice and assistance in performing necessary repairs.

��$�

��������������������������������������������

����������������

�������

���� �����'�

�����L������������

��������M��

9�������% �������!�����������������

9�����������������!��

9����������������!�������!��

(����

���� ��)�* �#����

�����C����7����L������������

��!�8�������!��!������������(������. ��������,�

8���(8,/�

����

��������������

(����

� � �&�� �&��+ �,��������

.�12�7�G�82�8�

���������G�:;�2G9���;�(11����8�GAG�.�

��.�>���>7�

;A9�

"A11�%�

I12A�

I1(�B��,�:(�

I1(�B�

%�7�A�

:;AAG�

%�7�A�

I1(�B�

I1(�B�

I1(�B�

C(�22���J��,�.�����

C(�22��J,�,�.�����

I1(�B�

.������8���

C����J,� C����J��

�2.A�

����

�����������������

(����

� � �&�� �&��+ �

� �������#�+ �,"��������+ �

C����J��C����J,�.������8���%�����8���

��.�>���>7�

%(.�A�82�8�

�1�(��

.%7����

.�12�7�G�82�8�

���������G�:;�2G9���;�(11����8�GAG�.�

;A9�

"A11�%�

I12A�

I1(�B�

I1(�B��,�:(�

I1(�B�

%�7�A�

I12A�

I;�%G�

:;AAG�

%�7�A�

I1(�B�

I1(�B�

I1(�B�

C(�22���J��,�.�����

C(�22��J,�,�.�����

I1(�B�

I1(�B�

�2.A�

����

��L�G���������7�>7��.���2������)�

1�"�����,��%���������!����������������������G������������!��������������������������������=,�.�����C���?�

� ���� ��������5��"$��%���������!����������������������G������������!����������������������������������������������!��������������������� �����������������������������������������!����������������!��������������������%������������������� ��������������������$��������������!������������������ �����G���%��������������������=A#����������� ?������������������!������G���

1�"�������%���������!����������������������G������������!��������������������������������=,�.�����C���?�

����

��L�G�����.��2��G����G�3�G����.���2������)�

.�����������5��"$�%�����!����������������������G���������$�% �����8������������������������� ����������.!������������;������ �������8���!�����������������!�������������������������������!���������������!�����!����������%�����8����G��9����������%�����8���.!������G���������������������������������8�����������������

1�"�������%���������!����������������������G������������!��������������������������������=,�.�����C���?�

� ���� ��������5��"$��%���������!����������������������G������������!����������������������������������������������!��������������������� �����������������������������������������!����������������!��������������������%������������������� ��������������������$��������������!������������������ �����G���%��������������������=A#����������� ?������������������!������G��

1�"�����,��%���������!����������������������G������������!��������������������������������=,�.�����C���?�

����

��

(� ���������

� �� ����������"����� �'�� �!�� �9�����$����� �� ������� �� ��:�� �?����! 5��������!�� ��<���!��$����%�� %�� � ��'�������;�

.�>����)�7��" ���"�����"� �"���� 5� �6�% ���� % ����������� ?�"�� ����������"������!����"$����6���� �6�% ���������� � ���� �����5��"$��� �� 5� �" !�;������ ��� �! �� ����� �����������?� ���� � ������4� �� �!���$;��� �

���>������ ����>1������������������������

�1A(G���A�7�(1��AA9��71�A;�K������C(1CA��

=���������!������������(2����711�.".�A���� ?�

9�� �N�(�����A����M� � ,/�

�1A(G�C(�22��.�2�����(..A�I1"�.�;AAG� 9�� �N�(�����A����M� � ,/�

�1A(G��"9;���71�A;�=7������'�����?� 9�� �N�(�����A����M� � ,4�

;7G.A��2��;A��CA;"��(GB� 9�� � ,4�

�1A(G�%(.�A�82�8��

=���������!������������(2���82�8��2��.".�A���� ?�

9�� � ,5�

�12.��.�12�7�G��(GB�(G9�82�8� 9�� � ,5�

�1A(G�82�8�7G1A���71�A;� 9�� � ,-�

�12.����A�7�(1�.".�A���

=���������!������������(2����711�.".�A���� ?�

����� � ,0�

�1A(G�9;(7G�C(1CA� (��������� 3��

.��;(:A�8;A8�N��;AAHA�8;��A��7�G� (��������� 3��

���� ��

��

����

������ �2������ ���7� �����>� /� ����� 1��1�)�.��$� ��� ������� 3�����������������

����������K������C������������������������������������������������������������������������)�������������������������(�������������������� �������

;���� ��#�������������������������������������

�����������������C���*�

• ;����������������K������C�������������������������������������������������������������!�������

• I�!�������������������������������������������� �� ��o 7�����������C�����������������$������������������� ��������������������$� ��!��������!������

���� �� ���������������������o 7����������������������$���������������������������

���� ��������� ��������� ����������!������������������������F��������������� ��������������������������

�������1��GG��2G�����������L���>���)��7����������������� �����$�������������������������$��������C����.������(���� ��7������������������������ ��������!���������� ����������������������������������������������������!����������C����.������(���� ����!���������� ����������������� �!������� �����������������������������������������!�����������!������ ��7���� ���� �������������������$����!�����������������������!������� ��������������������������������������������!������������ ��7���� ���������������������� ����������������������������������������� $������ �������������������!�!����������������!����!����$���������!�����!�� ��������������������������� �!����������#������G���!�% ��� �� �� �?����% ��� �� ���� ��% ������ ����?�"����;��������*�

• �!���������������������������� �������������������������

• 8��� ��������������������������!���������!�������

• 8������������ � ���������������������������������������������� ����������

��

��!�9���������

��!�9���������

C����.������(���� �G�/�35�

������K������C����89A������8�

������������������

����

�������2��2L7>�3�����>)�C���� �����""��� �D��I���������� ����������������� ����������� ����������!�����������������������!������� ��������������������������������!������������ ��(������������ ���!����!��� ��������������������������������������� �������������� ����������������%�����8�����������C����.������(���� ���$��2�! 3����� ������6���<�����!���!�"�����!� ����� ���� �9�����$�����%��"�� ������ �� ��)�

• 8������������������������������� ���������������

• ;���������������� ����A#���������� ����������������������������������

• ;��������� �� ��������� ����������!���������!�������

• A#��������������������������������������������

• ;��������������!����������� �����

• ������������������������

�����������>������G��>���1�>L����B)��I����������������������� �������������������%�����8�������9�����C��������������������������������� ���������#������������������������������������!�������������������������������������� �������

• ;����������������� �����������������������������������

• 8������ ���������������������������

• 2���������������������������������� ��������������������� ��������

• ���������������������������� ����������!�������������<���������������������

• 8����������%�����8��������������������������������� �����������

• 9������������������ �!����������� �����������

179�N�(���9��

1(�����

��;7G:�

�71�A;�I�9"�

�71�A;�I(:�N�(���(�

� �

;��������������������� ����������� ���������*�������I��*����(���(�8�����B��*�����(���I�N�=7������1����$��������K�����!��?�1��*� ��������(���9��

�� �

������.������G�3�G���G�)��C.��$� ��� ������� �����3���������������D��I����������������������������%�����8���������������������������������������������$����������������������������������� �������������������������!�����������%�����8������� ����������

• (��������������������������� �����$��������������������������������8������������������%�����8����������������������� ������������������&���������������������������

• %�����������������$���������%�����������!�������������G������������

• 2��������������������������� �������������������!���������������!��������������%�����8����G���

• 1������������������������������������!���������������!��������������!������������������%�����8�����

• 2�������������������������%�����8����!�����������

• �����������������������������������������������!�������

• �������������������$������������������� ��������$������������������������ �!����������� ������

��G�2����G��������B���7��G�)��

• 8����!�������������������������!����������������������������

• %�����������������$�����������������������������������������������������'��������������

• 9������������������������������������������������ ����������� �� ���

• ����������� ������������������G�������������������������G���

• 1������������������������������!��������� ���������������������������������7 �� �������$������� ���! �;��� ���$�����������6�% ���$��5��� ������� ��$��6 �� �� %��$�����9;���

• ��������������������������������������������������

• 8������ ������������������������&����������������������������������!���������������������� ��������

• ���������������������������������������!�������7����������������� ��������� �������������������$������$��������$���������������� ���������������������!�����������������������������=;A�A;����8����.��G���11�%7G:�8(:A�?��

• (����������������� ����������$���������������������!���������������������������������

• ;��������������������������������������8������������������������

• ��������������������G������������������������ �������� �������1������������������������������!��������� ���������������������������������7 �� �������$������� ���! �;��� ���$�����������6�% ���$��5��� ������� ��$��6 �� �� %��$�����9;���

• 9�������������������������������������

• 2���������������������������������������������������������������������������

• 8����!�������������������������!����������������������������

• ����������������������������������������������������'��������������

• 9������������������������������������������������ ����������� �� ���

• ����������� ������������������G�������������������������G��1������������������������������!��������� ����������������������������������

• ��������������������������������������������������

• 8������ ��������������������������������������������������������������!���������������������� ����������������������������������������������!������

Pour 2 or 3 gallons of clean water into Solution Tank

��!�

��G�2����G��������B���7��G�)��C" ������!�% ��� �?� �������D����������

�����������G�������������>��(������������8���7�������������������������������������������������������'��������������������������

• ;����������������������������������������������������������

�����������

� �

Solution Tank

Direct the end of the prime hose into the recovery tank vacuum barb

Vacuum acid solution out of Solution Tank

8���7����������8�A,0���-�

��$�

��G�2��2�������L���)�C.��$� ��� ������� 3����������������D�

�������� ��������������������� ���������������������� �������������!��������������

• ;������������������ �����!����������!������=�������� ��������� ����$���������������� ���������������������?��

• ;������������������������������������������������������������������������������������ ��������������!��������������������������

• ������������(������%�����.�� �������������!�����������=����'�����������?�������������������������������

• ���������������������������������������!��������������������������!������1�������!�������!������������������� ������������������������������� �������!��������������������������������#���!�����������������!��������������������������� ���������������������������������������������������������

• �������������������������� �������!�������������������������$�������������!������������������������������(������%�����.�� ��������

• 8���������$����������������������������������� �� $�������������J�$������������������������������������!����������������������������

• %������������������������ �����������$��������������������������������!����������

• 8������ ��������������������������������������������������������������!��������������������� ��������

• ���������������������������������������!�������

��

��

� �

Place Chemical Feed Hose into Rinse Solution

Connect Auto-Fill Water Supply Hose to machine and faucet

Vacuum water out of Solution Tank

Drain water from Recovery Tank

����

������>���1�>L����B�7>�����9� ���������������������������������������������������������������������������������������������� �������!�������������� �!���������������������������2����������� ������������������������������������������ ������!������������������$� ����������� ����������������!����'���������������������������7 �����$�� �" ?� �����9�6�% �������������� ��� ?�"���$��! ����?��?�;�

• 2�����!���������������������������� ������������������������� ������������������������������������� �������2�������������������������$��������������������� �����������������������$������!������������������������������

• .����������������� �� $���������������������������������������������������������������������

• A#��������������� �� �����!���������������������������������������������9��������������!����!�!����������!���������������������������������;����������������������

• A#����������������������������������$��������������������

• ;�����$������������������������������!���������������1��������������������������������������������������������.���������� ����!��������������� ������������������ �� �����������������������������������!�������������������� ���

• ������� ������������������������������������� �������

• �;���������� �� ������������ ������� �� $�������������������������$��������������� � ������������������������

• �;���������� �������������������� ��������������� �����������9������������������� �����

��

Remove four bolts holding valve assembly to flange fitting

Unless damaged or leaking between tank and flange, the flange fitting does not have to be removed

FLANGE FITTING

GASKET – NM3019

VALVE BODY OUTLET ADAPTER

DRAIN VALVE – PEA11

Clean debris from slot in bottom of valve body. Valve slide must be able to slide to bottom.

����

�� ����� �����!�� ��J��� ��"�� ��� "�!� ��)���"���� ������������� ���������������������<���������<�������������������������������������$�������$�����������������$������� ����������������������������!������7�������������������������������������������<���������������$��������!������������������� �������������(1.�$�������������������������������#���������������������$��������!������������������ ������������������������������������������� ����������� 7�������������������������#��F,���������!�����!�����F,�������������������������������������<���

=A�� ����� ���� ��?����#�!��������������������������������,� ����������������������������������������������=������'�����������?���������������������

����������������$�����������������!� ��������������������������%���������������������$���������������������������������������������������

#; 7���'������!����(������=7�����������������J/?&��������������8��������������������������������=������'������������?����������������������������������8��������������������(�����������=����'������������?��1��������������������������������������������������������������������������������� �����������������������<���������������������������������������������������� �����������I�����������������������������������������!��������������������������������������

+� ��������������������!�������������G�����������(�!��������������<�����������������/��������������#�����������������������<��������������������������������������������������������� ��� �����������������������<���������������!��������������������������<��!�� �����!������������������������������������������������������������

/� ���������� �������������������!�� ���������!����������������������������������!�������������G�����������9�������������� � ����������������������������������� ������������������������������������������������������ �������������

4� ��������������������!��������������������������5� 2������������������������������������������������<����������������������������������� ������-� 7���'������!����(���8������=7�����������������J��?&�������������������������!������������

�������������������� ������������������������������������������������������� ��������������������������������������������!���

0� ;����������������������������� ���������������%�����8����!�������������G����������������������������!���������������������������1�!����������������������������%�����8���.!���������������� ���������������<����!�����������������������������������

��� 9����������������������������<������������������������� ����������������������������� ���������������

>��G>������2����������>1��������>����>�����>��>��M���>��������)������������������������������$��������������<������ �������������������������������������������<�������������������� �������������������������� ���������������!�������������������������<�����

����

#�����

���������������� ���������������������������������

���� ��

��

(����#-(#�.��#���#��������/(012�

�� .�;A%.�82�8���2.7G:� ,��3������

,� 9A�(G9�.%7�������8.7� 8��,�0���,��

3� ��A�B�C(1CA�(..A�I1"�%7�����;7G:� 8�,�0�+���,(�

+� 97(8�;(:��F��(��IA(;7G:�(..A�I1"� 8�,���4��33(�

/� ����;�=% 7���2��I(.A81(�A?� �,�,0���+(�

4� ����;�;A(;�AG9�IA11��(..A�I1"� ,�55,��/5(�

5� I(.A�81(�A�K�:;���A�.��� ���,-�����

-� 288A;���2.7G:��% 7���.%7���� 8�9�3,C5���

� � �

����

����������������������������������������������

��L�G���G��3�����������1��1��������L�

C���� ���D�

8����G� ��� 9������������4�3� 3@�9���������� ����,/�5-� 8����G�����3+��5� �4E�������!��������������3+�,,� I�����!�8���������3/��,� ����������������N��(&(,�(� .��������N��(&(��3/��-� �����(���� �N��2L��(3��#�3/�3�� ��������������3/�3,� �������������3/�33� .������3/�3/� ������������% ����N��7�#(3&,�3/�34� C����I�� �3/�35� ������+����-� .������+��5�,/� A��������� ��+���/�/� 9���������4���,�� A �!�0�>�.�������F+E�4���,,� (�������4����5�,� ��������%������4��,,�3� 8������������N��7�*3,,3#�43�3/� �������43�35� .������43�3-� 8�����43�+4� .���!�-��-�#��F,E�=+���'�?�43�-5� C����;������B�������7�*#3-+�

=7�����*�+����-$�+���/�/$�43�35�K�43�3-?�����3� ; ���%�������������8� �����C����N�������N��7���3�������,� -@�#��F+E�8������� ����N�E��������/� �����������������'�����

����

����

����

�� �

��!�

��$�

����

����

����

"���� ����������������������������� �� ������������ �����������7������� ������������������������ ����������������������������������������������������������������������� ����������� �����7�� �������� �������������������������������������������� ����������� ��������� �������� ���������������������������� ����������!��������������������������������� ������������ ������������ ����������������������������������!�������������������� ��������������������������������(�������������������������� �������������!������������ ���������������������������������!������������������� ��������������������������������9���������!������ �������$�� ����������!�$�������������������������������������������!�������������� ������������������!������ �����������������������������������������������������������������������������(� ��������������������������������������������� ���������������������������!������ ��;��������������������!����������� ����������������������������������!������ ���������������!������ ������������ �������������������������������������������$�������������������$��������<���������������$������������������ ��� $������$�� �������#�������������<���������������������������7�����������������������!������������������������$����������$���������$������$�)���$������$� ��������$����������������!�������'����������������������������������� ������������ �����!������ ������������������ ��������$��������� ��������� �������� �����������7�������#������������ �������������� ����������������������<�����������������$����������������������� ������������������������������������������!������ ����������G����������������!�� ����������� �� ����������!������������������<�������(�������������������������������<�������� ��$������� �� ���������$����� ����������������#������������������������� �������������������������!������ ���������#������������������!��������������������������������������������������������������������������@�����������#����������������7���������������� ���������� ���� �������� �������$���������$�������$�������������������'���������������������!������ ������� �����������������������"���� �����������������������!�������� ������)��������������)������������������

���� ��

��1 + �������������