HCD-GRX3/RX55/R300 - Forum Futura Sciences

HCD-GRX3/RX55/R300US Model

Canadian ModelHCD-RX55

E ModelHCD-GRX3/R300

Australian ModelHCD-GRX3

SERVICE MANUAL

MINI Hi-Fi COMPONENT SYSTEM

MICROFILM

HCD-GRX3/RX55/R300 is the tuner, deck,CD and amplifier section in MHC-GRX3/RX55/R300.

SPECIFICATIONS

Model Name Using Similar Mechanism HCD-G101

CD Mechanism Type CX3

Base Unit Type KSM-213BCM

Optical Pick-up Type KSS-213B/S-N

Model Name Using Similar Mechanism NEW

CWB44RR10

CD

SECTION

TAPE DECKSECTION Tape Transpor Mechanism Type

AUDIO POWER SPECIFICATIONS:(U.S.A. model only)POWER OUTPUT AND TOTAL HARMONIC DISTORTION:with 6 Ω loads both channels driven, from 70 – 20,000 Hz; rated 35 W perchannel minimum RMS power, with no more than 0.9% total harmonicdistortion from 250 mW to rated output.

Amplifier sectionNorth American modelContinuous RMS power output

50 W + 50 W (6 Ω at 1 kHz, 10% THD)

Other modelsThe following measured at AC 110, 220 V 60 Hz;DIN power output (Rated) 35 W + 35 W (6 Ω at 1 kHz, DIN)Continuous RMS power output (Reference)

45 W + 45W (6 Ω at 1 kHz, 10% THD)

The following measured at AC 120, 240 V 60 Hz;DIN power output (Rated) 40 W + 40 W (6 Ω at 1 kHz, DIN)Continuous RMS power output (Reference)

50 W + 50W (6 Ω at 1 kHz, 10% THD)Peak music power output (Reference)

600 W

InputsMD IN (phone jacks) : voltage 450 mV, impedance 47 kΩ

OutputsMD OUT (phone jacks) : voltage 250 mV, impedance 1 kΩPHONES (stereo phone jack) :

accepts headphones of 8 Ω or moreSPEAKER : accepts impedance of 6 to 16 Ω

CD player section

System Compact disc and digital audio systemLaser Semiconductor laser (λ = 780 nm)

Emission duration: continuousLaser output Max. 44.6 µW*

*This output is the value measured at adistance of 200 mm from the objectivelens surface on the Optical Pick-up Blockwith 7 mm aperture.

Frequency response 20 Hz – 20 kHz (± 0.5 dB)Wavelength 780 – 790 nmDIGITAL OUT (OPTICAL)(Square optical connector jack, rear panel)

Wavelength 600 nmOutput Level –18 dBm

Tape deck sectionRecording system 4 -track 2 -channel stereoFrequency response 40 – 13,000 Hz (± 3dB), using Sony

TYPE Ι cassette

Tuner sectionFM stereo, FM/AM superheterodyne tuner

FM tuner sectionTuning range 87.5 – 108.0 MHzAntenna FM lead antenna

photo : HCD-GRX3

— Continued on next page —

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardousradiation exposure.

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

Flexible Circuit Board Repairing• Keep the temperature of soldering iron around 270˚C

during repairing.• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering

or unsoldering.

Laser component in this product is capable of emitting radiationexceeding the limit for Class 1.

This appliance is classified asa CLASS 1 LASER product.The CLASS 1 LASERPRODUCT MARKING islocated on the rear exterior.

This cautionlabel is locatedinside the unit.

SERVICING NOTE

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCKOR BASE UNIT

The laser diode in the optical pick-up block may suffer electrostaticbreak-down because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECK

The laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission,observe from more than 30 cm away from the objective lens.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITHMARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTSLIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESECOMPONENTS WITH SONY PARTS WHOSE PART NUMBERSAPPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTSPUBLISHED BY SONY.

Antenna terminals 75 Ω unbalancedIntermediate frequency 10.7MHz

AM tuner sectionTuning range 531 – 1,602 kHz (with AM tuning interval set

at 9 kHz)530 – 1,710 kHz (with AM tuning interval setat 10 kHz)

Antenna AM loop antennaAntenna terminals External antenna terminalIntermediate frequency 450 kHz

GeneralPower requirements

North American model:120 V AC, 60 HzMexican model: 120 V AC, 50/60 HzAustralian and South African models:

220 – 240 V AC, 50/60 HzOther models: 110 – 120 V or 220 – 240 V AC,

50/60 Hz (adjustable with voltage selector)Power consumption 100 WDimensions (w/h/d) incl. projecting parts and controls

Approx. 280 × 320 × 400 mm(11 1/8 × 12 5/8 × 15 3/4 in)

Mass Approx. 9.5 kg (20 lb 15 oz.)Supplied accessories: AM loop antenna (1)

Remote (1) RM-SG7 (for HCD-GRX3/RX55) RM-SG7B (for HCD-R300)FM lead antenna (1)

Design and specifications are subject to change without notice.

ATTENTION AU COMPOSANT AYANT RAPPORTÀ LA SÉCURITÉ!

LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE ! SUR LESDIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONTCRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NEREMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONYDONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OUDANS LES SUPPÉMENTS PUBLIÉS PAR SONY.

— 2 —

SAFETY CHECK-OUT

After correcting the original service problem, perform the followingsafety checks before releasing the set to the customer:Check the antenna terminals, metal trim, “metallized” knobs, screws,and all other exposed metal parts for AC leakage. Check leakage asdescribed below.

LEAKAGEThe AC leakage from any exposed metal part to earth Ground andfrom all exposed metal parts to any exposed metal part having areturn to chassis, must not exceed 0.5 mA (500 microampers).Leakage current can be measured by any one of three methods.1. A commercial leakage tester, such as the Simpson 229 or RCA

WT-540A. Follow the manufacturers’ instructions to use theseinstruments.

2. A battery-operated AC milliammeter. The Data Precision 245digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of aVOM or battery-operated AC voltmeter. The “limit” indicationis 0.75 V, so analog meters must have an accurate low-voltagescale. The Simpson 250 and Sanwa SH-63Trd are examples ofa passive VOM that is suitable. Nearly all battery operateddigital multimeters that have a 2V AC range are suitable. (SeeFig. A)

To Exposed Metal Parts on Set

0.15 µF 1.5 kΩACVoltmeter(0.75 V)

Earth Ground

Fig. A. Using an AC voltmeter to check AC leakage.

TABLE OF CONTENTS

1. GENERAL .......................................................................... 4

2. DISASSEMBLY2-1. Upper Cover and CD Door ................................................. 52-2. Front Panel ......................................................................... 52-3. Main Board ......................................................................... 62-4. Amp Board ......................................................................... 62-5. CD Tray .............................................................................. 72-6. CD Decoder Board ............................................................. 72-7. Base Unit ............................................................................ 82-8. Cassette Door ..................................................................... 8

3. MECHANICAL ADJUSTMENTS ............................... 9

4. ELECTRICAL ADJUSTMENTS ................................. 9

5. DIAGRAMS5-1. Circuit Boards Location ................................................... 145-2. Block Diagrams

• Deck Section ................................................................... 15• CD Section ...................................................................... 17

5-3. IC Block Diagrams ........................................................... 195-4. Printed Wiring Board —CD Section — ........................... 245-5. Schematic Diagram — CD Section — ............................. 295-6. Schematic Diagram —Panel Section — .......................... 335-7. Printed Wiring Board —Panel Section —........................ 375-8. Printed Wiring Board — Deck Section — ....................... 425-9. Schematic Diagram —Deck Section — ........................... 475-10. Schematic Diagram —Main Section — ........................... 515-11. Printed Wiring Board —Main Section — ........................ 555-12. Printed Wiring Board — Amp Section — ........................ 605-13. IC Pin Function ................................................................ 65

6. EXPLODED VIEWS6-1. Cabinet Section ................................................................. 676-2. Front Panel Section .......................................................... 686-3. Cassette Mechanism Deck Section ................................... 696-4. CD Mechanism Deck Section 1 ....................................... 706-5. CD Mechanism Deck Section 2 ....................................... 716-6. Base Unit Section (KSM-213BCM) ................................. 72

7. ELECTRICAL PARTS LIST ........................................ 73

— 3 —

— 4 —

SECTION 1GENERAL

LOCATION OF PARTS AND CONTROLS

1 DISC 1 button2 DISC 2 button3 DISC 3 button4 DISC SKIP button5 § OPEN/CLOSE button6 · (TAPE B)7 · ∏ (CD) button8 TUNER/BAND button9 r REC button!º ∏ PAUSE button!¡ CD SYNC button!™ STEREO/MONO button!£ VOLUME!¢ REPEAT/MEMORY button!∞ ‚ + button!§ DECK B

!¶ JOG DIAL!• π (STOP) button!ª DECK A@º º – button@¡ DBFB button@™ SURROUND button@£ FILE SELECT button@¢ DISPLAY/DEMO button@∞ EDIT/DIRECTION button@§ PLAY MODE button@¶ FUNCTION@• ª (TAPE A) button@ª I/u (POWER) button#º · (TAPE A) button#¡ ª (TAPE B) button

9

8

7

6

0

!¡

!™

!£

!¢

!∞

!§

2 3 4 5

@¶

1

@ª

@•

#º

#¡

@§

@∞

@¢

@£

@™

!ª

@¡

@º

!¶ !•

— 5 —

SECTION 2DISASSEMBLY

2-1. UPPER COVER AND CD DOOR

Note : Follow the disassembly procedure in the numerical order given.

2-2. FRONT PANEL

1 Three srews

2 Three screws

3 Seven screws

4 Upper cover

5 Pull out the CD tray and remove the CD door with releasing craws into the directioin of arrow.

6 CD door

claws

4 Flat type wire (CN09)

2 Connector (CN302)

1 Three screws

5 Front panel


— 6 —

2-3. MAIN BOARD

2-4. AMP BOARD

1 Five screws

2 Harness (CN701)

3 Harness (CN302)

4 Harness (CN08)

5 MAIN board

1 Two screws

2 Three screws

3 Three screws

4 Three screws

5 AMP board

— 7 —

1 Screw

2 Bracket

4 Bracket


3 Screw

6 CD tray

2-5. CD TRAY

2-6. CD DECODER BOARD

1 Two screws

claws

2 Two screws

6 CD decoder board

3 Flat cable

4 Flat cable

5 Connector

— 8 —

2 Screw

3 UD-gear

4 Screw

5 UD-Cam

8 Spring

7 Spring

6 Spring

1 Two screws9 Base unit

2-7. BASE UNIT

2-8. CASSETTE DOOR

Cassette door(Note: Four claws are used.)

— 9 —

Precaution1. Clean the following parts with a denatured alcohol-moistened

swab:record/playback head pinch rollerserase head rubber beltscapstan idlers

2. Demagnetize the record/playback head with a headdemagnetizer.

3. Do not use a magnetized screwdriver for the adjustments.4. After the adjustments, apply suitable locking compound to the

parts adjusted.5. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.

Torque Measurement

SECTION 3MECHANICAL ADJUSTMENTS

Meter reading40 to 70 g • cm

(0.56 - 0.97 oz • inch)

1 to 5 g • cm(0.01 - 0.07 oz • inch)

55 to 140 g • cm(0.76 - 1.94 oz • inch)

Torque

FWD

FWDback tension

FF/REW

Torque meter

CQ-102C

CQ-102C

CQ-201B

SECTION 4ELECTRICAL ADJUSTMENTS

1. Demagnetize the record/playback head with a headdamagnetizer.

2. Do not use a magnetized screwdriver for the adjustments.3. After the adjustments, apply suitable locking compound to the

parts adjusted.4. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.5. The adjustments should be performed in the order given in this

service manual. (As a general rule, playback circuit adjustmentshould be completed before performing recording circuitadjustment.)

6. The adjustments should be performed for both L-CH and R-CH.

Record/Playback Head Azimuth Adjustment(Deck A, Deck B)

Note: Perform this adjustments for both decks.

Procedure:1. Mode : Playback

DECK SECTION 0 dB=0.775V

TapeP-4-A100WS-48B

Signal10 kHz, –10 dB

3 kHz, 0 dB

Used forAzimuth Adjustment

Tape Speed Adjustment

test tapeP-4-A100(10kHz, –10dB)

SPEAKERterminal (JK301)

level meter

+

–

set

— 10 —

2. Turn the adjustment screw and check output peaks. If the peaksdo not match for L-CH and R-CH, turn the adjustment screwso that outputs match within 2 dB of peak.

3. Mode: Playback

4. After the adjustments, apply suitable locking compound to theparts adjusted.

Adjustment Location:

Adjustment screwsREC/PB head (deck A)or PB head (deck B)

test tapeWS-48B(3kHz, 0dB)

Tape Speed Adjustment (Deck A)

Procedure:1. Mode: Playback

2. Adjust the SFR501 so that the frequency counter reads 3,000Hz ± 90Hz.

Adjustment Location: DECK board

Sample Value of Wow and flutterW. RMS (JIS) within 0.3%(test tape: WS-48B)

[DECK BOARD] — Component side —

L-CHpeak

R-CHpeak

screwposition

outputlevel within

2dB within 2dB

L-CHpeak

screwpositionR-CH

peak

test tapeP-4-A100(10kHz, –10dB)

SPEAKERterminal (JK301)(L-CH)

set

L

R

oscilloscope

SPEAKERterminal (JK301)(R-CH)

Waveform of oscilloscope

in phase 45˚ 90˚ 135˚ 180˚

good wrong

SPEAKERterminal (JK301)

set

frequency counter

+–

Tape Speed

SFR501CN501

— 11 —

TUNER SECTION 0 dB=1µV

AM Tuning Voltage Adjustment

Procedure:1. Set the reception frequency of the unit to 530 kHz.2. Adjust L105 for 1.2 ± 0.05 V reading on the DC voltmeter.3. Set the reception frequency of the unit to 1,710 kHz.4. Confirm that the voltage reading on the DC voltmeter is within

8.0 ± 0.5 V.

Adjustment Location: MAIN board (See page 12)

AM Tracking Adjustment

Procedure:1. Tune the set to 600 kHz.2. Set the output of AM RF SSG so that the input level of the set

will become 60 dB (µV/m).3. Adjust L104 so that when the waveform on the oscilloscope is

maximum, no noise appears.4. Tune the set to 1,400 kHz.

5. Adjust CT102 so that when the waveform on the oscilloscopeis maximum, no noise appears.

• Repeat the procedures in each adjustment several times, and thetracking adjustment should be finally done by the trimmercapacitors.


FM Tuning Voltage Adjustment

DC voltmeter

Procedure :1. Set the reception frequency of the unit to 87.5 MHz.2. Adjust L103 for 1.2 ± 0.05V reading on the DC voltmeter.3. Set the reception frequency of the unit to 108 MHz.4. Confirm that the voltage reading on the DC voltmeter is within

7.8 ± 0.5V.


TP1

+

IFGVT

Main board

DC voltmeterMain board

–

FGVT

TP1

+

–

AM RF SSG

loop antenna

set

loop antenna(Supplied accessories)

60 cm AM ANTENNAterminal (JK101)30% amplitude

modulation by400 Hz signal Field strength dB (µV/m) =SSG output level dB (µV/m) –26 dB.

— 12 —

FM Tuned Level Adjustment

set

Procedure:1. Supply a 28 dB 98 MHz signal from the ANTENNA terminal.2. Tune the set to 98 MHz.3. Adjust SFR101 to the point (moment) when the TUNED

indicator will change from going off to going on.

Adjustment Location: MAIN board

FM Tracking Adjustment

Procedure:

1. Tune the set to 90 MHz.2. Adjust L102 so that when the waveform on the oscilloscope is

maximum, no noise appears.3. Tune the set to 106 MHz.4. Adjust CT101 so that when the waveform on the oscilloscope

is maximum, no noise appears.

• Repeat the procedures in each adjustment several times, and thetracking adjustment should be finally done by the trimmercapacitors.

Adjustment Location: MAIN board

Adjustment Location

[MAIN BOARD] — Component side —

Carrier frequency : 90 MHz, 106 MHzModulation : AUDIO 1kHz, 75kHz deviation (100%)Output level : 20 dB (at 75 Ω open)

FM RF SSG

Carrier frequency : 98 MHzModulation : AUDIO 1 kHz, 75 kHz

deviation (100%)Output level : 28 dB (at 75 Ω open)

FM ANTENNA terminal(JK101)

75 Ω coaxial

SFR101

FM Tyned LevelAM TuningVoltage

IC103TP1

IC102

L105IC101

CT102

L103

AMTracking

L104

L102

CT101FMTracking

JK101

FM TuningVoltage

JK301

FM ANTENNA terminal (JK101)SPEAKER terminal (JK301)

FM RF SSG

set

oscilloscope

— 13 —

IC03VR02

VR01

R07

IC01

CN12

Focus Gain

Focus Bias

RF Level

CD SECTION

Note:1. CD Block is basically constructed to operate without

adjustment. Therefore, check each item in order given.2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.3. Use an oscilloscope with more than 10MΩ impedance.4. Clean the object lens by an applicator with neutral detergent

when the signal level is low than specified value with thefollowing checks.

5. Adjust the focus bias adjustment when optical block is replaced.

Focus Bias Adjustment

RF Level Check

Procedure :1. Connect oscilloscope to test point TP (RF) on CD DECODER

board.2. Turned Power switch on.3. Put disc (YEDS-18) in and playback.4. Confirm that oscilloscope waveform is clear and check RF

signal level is correct or not.Note: Clear RF signal waveform means that the shape “◊” can be

clearly distinguished at the center of the waveform.

oscilloscope

level: 1.0 Vp-p

VOLT/DIV: 200 mVTIME/DIV: 500 nS

+0.3–0.2

Adjustment Location: CD DECODER board

Procedure:1. Connect DC voltmeter to test point CN12 (FEO), (VC) on CD

DECODER board.2. Turned Power switch on.3. Put disc (YEDS-18) in and stop.4. Adjust VR01 so that the DC voitmeter reading is 0 ± 20 mV.

Adjustment Location: CD DECODER board

Focus Gain Adjustment (VR02)

This gain has a margin, so even if it is slightly off.There is no problem.Therfore, do not perform this adjusment.Please note that it should be fixed to mechanical center positionwhen you moved and do not know original position.

Adjustment Location

[CD DECODER BOARD] — Component side —

CD DECODERboard

CN12

FEOVC

DC voltmeter

+

–

CD DECODERboard

TP (RF)CN12 (VC)

— 14 —

SECTION 5DIAGRAMS

5-1. CIRCUIT BOARDS LOCATION

SW (C) board

SW (D) board

SW (B) board

CD BUTTON board

PANEL board

VOLUME board

FUSE board

AMP board

MAIN boardMOTOR board

MOTOR (6P) (S) board

SW (A) board

CD DECODER board

DECK board

HCD-GRX3/RX55/R300

5-2. BLOCK DIAGRAMS

— DECK SECTION —

— 15 — — 16 —

HP901PB

HEAD

TAPE B

HRP901REC/PBHEAD

TAPE A

R CHR CH

R CH

PLAY/RECCONTROL

Q203,205

PLAY/RECCONTROL

DRIVE

Q207

AMSMUTE

Q551,552

PLAY/RECCONTROL

D201

L251BIAS OSC

BIASOSC

Q251

HE901ERASEHEAD

R CH

1

2

9

3

REC OUT

PB OUT

A/B

5

19

11

10

REC/PBEQ AMP

IC201

Q251

D202

: FM

: CD

• Signal Path

• RCH is omitted

BCD

SECTION

TU L

11

9

10

ST IND

TU MUTE

DO

CD L

12

CONTROL

3 2

1

CLK

14

DI

15

CE

13

SELECTORIC301

CLK

DI

CE

LINE AMPIC303

13

Q709

MUTE

1 10

4

POWER AMPIC401

SPEAKERRELAYDRIVE

Q706

Q708

1

2

6

IC402

RL701

R CH

SPEAKER

PHONES

JK302

JK303

SCOR

SENS

SQSO

XLAT

SQCK

DATA

DI

CLK

CE

STB

26

ST

B

21

CE

22

CLK

23

DO

52

FO

K

53

CO

UN

T

18

DA

TA

19

SQ

SO

51

SE

NS

38

SC

OR

24

DI1

MUTEDRIVE

Q410Q604

MUTEMUTESWITCH

Q603

4

TU

MU

TE

47

FM

ST

IND

3

SY

ST

EM

MU

TE

2

PO

WE

R

LED DRIVEIC603

36

ALA

TC

H

13

LEDDRIVE

DI

CLK

Q608-613

RESETSWITCH

POWERDOWN DET

Q601

10

RE

SE

T

15

PO

WE

R D

OW

N

Q602

LED606-611

LED601-604

Q602

D602

X2

11

X1

12

VR

UP

44

X6014.19MHz

VR

DO

WN

45

VR601VOLUME

PIC

UP

55

PIC

DO

WN

56

TR

AY

OP

EN

59

TR

AY

CLO

SE

60

TU

RN

TA

BLE

58

DIS

C C

OU

NT

57

A B

S02TRAY

OPEN/CLOSEDET

S03DISC

COUNTERDET

S04TURNTABLEOPERATION

DET

S01CD DECKUP/DOWN

DET

3

2

Q601

RM601

REMOTECONTROLRECEIVER

39

RE

MO

TE

64 78

KEYMATRIX

S601-628

P1 P21

100 86

G1 G15. 81 8533 29

KI0 KI4

FLD601FLD DISPLAY

SYSTEM CONTROLLER/FLD DRIVER

IC601

+5.6VREG

Q409

SITCHING

Q415,416

+11.5V(SWITCHED)

+11.5V FILTER

Q403

+7.5VREG

Q702

+7.5V+12VREG

Q701

RECT

D705-708

P MUTECONT

Q713

AC OFFDET

Q714

D718

D720

RECT

D701

-12V

-30V

+30V

-27VREG

Q703

-27VVOLTAGEDOUBLER

D731,732

ACIN

PT001

AC3.4V

AC3.4V

12

16

ATUNER

SECTION

: PB (DECK A)

: PB (DECK B)

: REC (DECK A)

Q201

BIASSWITCH

CONTROLSWITCH

Q208,209

Q252,253

+12V

RECMUTE

Q213

6

TAPE A/B

MIX OUT

MD L

JK301

LINEOUT L

9 8

6

IC302 (2/2)

11 10

12

IC302 (1/2)

Q417

Q301

62

SE

RI M

UT

E

6

TAP

E R

EC

61

AM

S

BUS REGISTERIC501

14REC

12BIAS

11A/B

13REC MUTE

2S/I

3

CLK

10Q'S

1STB DECK STB43

MOTORB+ SW

Q501,502

SOL BDRIVE

Q503,504

DO

CLK

SHIFT REGISTERIC502

2

MTR +12V

9QH

1S/L

DECK DATA42

DECK S/L41

SOL ADRIVE

Q505,506

PLAY4

SOL A5

SOL B6

+12V

F REC3

R REC4

PHOTO A5

PHOTO B6

A MODE11

B MODE12

A HALF13

B HALF14HALF B

HALF A

MODE B

MODE A

PHOTO B

PHOTO A

REC REV

REC FWD

SOL B

SOL A

SOL B

MOTOR H

MOTOR LTAPE

SPEED

SFR 501

MECHA BLOCK

12

17

CE

CLK DO

LEDDRIVE

Q606,607

10

5

LED DRIVEIC602

2

3

4

11

12

LED605

1

3

2

Q605,615

SW

MO

DE

13

+5.6VSW101

10k

9k

JOG

A

49

JOG

B

50

VR612MULTI JOG

A B

4

LT C

OM

SURROUNDCONTROL

Q307

Q310

5

SU

RR

OU

ND

4

32

Q331HIGH

Q308NORMAL

7

DB

FB

NO

RM

AL

8

DB

FB

HIG

H

HP AMPIC401

Q408

MUTE

SP DET

Q404

+12V

-12VREG

Q401

: MD

17

SQ

CK

20

XLA

T

COUNT

FOK

HCD-GRX3/RX55/R300

— TUNER/CD SECTION —

— 17 — — 18 —

CE

19

12

5

3

4

2

24

1

PLLIC103

FM

XO

XI

CLK

DI

DO

CE

CLK

DO

DI

OPTICAL PICK-UPBLOCK

APC

Q01

38

+5V

VC

LD

GND

A

C

B

E

F

FOCUSCOIL

F+

F

T+

T

TRACKINGCOIL

33

34

39

36

35

48

APC

FOCUS PHASECOMPENSATION

DECODER

SERIAL/PARALLEL

CONVERTER

FEAMP

RFAMP

IIL

TTL

TTL

IIL

COMAND

VC

TRACKING PHASECOMPENSATION

LD

PD

E

F

PD1

PD2

6

24

23

20

19

22

21

31

25

SENS

RFO

FOK

C OUT

DATA

XLT

CLK

XRST

13FEO TAO

IC03

T.T/TRAY MOTORDRIVER

CD RF/SERVOPROSSESOR

IC01 (1/2)

4

5T IN

3

2

1

VR

PDPD

18

17

20

19

6F IN

22SL IN

13T.T F IN

F+

F

T+

T

SL+

SL

SP+

SP

M

M

MOTOR

M102SLED

MOTOR

M101SPINDOL

EFMDEMO.

XRST

CLVSERVO

DIGITALCLV

D/AI/F

SUB CODEPROSSESOR

CPU I/F

9 11 5 4 7 61

MDP

SE

NS

SC

OR

SQ

SO

SQ

CK

CLO

CK

DA

TA

CLK

XLT

DAT

SE

CN

FOK

RF

SERIALI/F

PWM

PWM

61

70

69

73

74

D OUT

NL

L

XTA1

XTA0X701

MU

TE

VDD

R-CH

D IN

GND

2

3

1

+5V

OPTICALDIGITAL

OUT

PH01

CD DIGITALSIGNAL PROCESSOR

IC703

16

:FM

:CD

:DIGITAL OUT

• SIGNAL PATH

14

7

8

4

2

1

6

10

DETECTOR

16

OSC

FM75Ω

AM

ANTENNA

JK101

D105

L101FM ANT

L102FM RF

3

1 RF MIX 6

8

FM FRONT ENDIC101

RF IFAMP

Q101CF10110.7MHz

T101 CF10210.7MHz

FM OSCAMP

Q102

D106

L103

L105MW OSC

IF

G

VT

AM/FMTUNING

VOLTAGE

TP1

L104AM ANT

AM RFAMP

Q108

MPX16

FM IF1

OSC23

AFC22AM RF21

FMIF

AF DET18

FMDET

AM/FMIF BUFF

AMOSC

AMMIX

AMDET

SM

ET

20

CF103450kHz

MUTE

AGC

AMIF

DECODER14

L

15R

4

2

T102AM IFT

8FM DET

17MPX VCO

CF10410.7MHz

CF10519kHz

R CH

FM/AM MPXIC102

L.P.F

Q112,113

FMTUNEDLEVEL

PD121

X1017.2MHz

FM B+17

TUB+

B+

Q114

PL

DE

T

13

18AM

OSC/FMSD24B+

7SD

PH

DE

T

11

PH

DE

T

12

14ST/MONO

TU

LE

D

6

13AM/FM

SD

15L CTR

16R CTR

7ST IND

10AM/FM

MUTE

Q117

TU L

ST IND

TU MUTE

DI

AMAIN

SECTION

D5

LD ONSWITCH

Q02LD

PD

F/T COILSL/SP MOTOR

CN12

CN2

ATSC45

FEO1

TEO42

FOCUSTRACKING

37 40FE BIAS EI

RV01

FOCUSGAIN

RV02

14

15

30

31

T.T+

T.T

TR+

TR

M

M

MOTORT/T

MOTORTRAY

21SP IN

29TR F IN

12T.T R IN

28TR T IN

27MUTE IN

IC06

IC01 (2/2)

67

REG

Q119REG I

10REG B

11REG OUT

7VCC

8VCC

+5V

+7.5V

XRST6

SPEED11

CONTRL5SWITCH

Q04

13

14

TR+

TR

7

14

T.T+

T.T

4MUTE

2DATA

3CLOK

1STB

IC02

MOTOR DRIVEREG CONTROL

T.T/TRAY

36

23

14

13

15

16

17

8

25

18

SP

OA

LIMITSWITCH

S05

10

XLA

T

CLOCKGEN.

PWM

PWM 77

78

NR

R

22

XLO

N

13

2IC05

MIX AMP

MUTE

Q311

CD L

SCOR

SENS

SQSO

XLAT

SQCK

DATA

CE

STB

CLK

DO

BMAIN

SECTION(Page)

:AM

• R CH is omitted

SFR101

COUNT

FOK

CLK

DO

HCD-GRX3/RX

— 19 — — 20 — — 21 — — 22 — — 23 —

IC01 (CD DECORD BOARD) CXA1782BQ IC101 (MAIN BOARD) LA1186

IC301 (MAIN BOARD) LC75392

IC201 (MAIN BOARD) TA8189N

IC02 (CD DECORD BOARD) TC9173P

5-3. IC BLOCK DIAGRAMS

IC03 (CD DECORD BOARD) BA5941FP

IC602 (PANEL BOARD) BU2092

+–

LEVEL SHIFT

+ –+–

1 2 3 4 5 6 7 8 9 10 11 12 13 14

28 27

LEVEL SHIFT

+ –

+–

MUTE

+–

+–

LEVEL SHIFT

+ –+–

LEVEL SHIFT

+ –

+–

+–

151617181921 202226 25 24 23

+–NC

Vcc

VccVcc

VCC

BIAS

IN

IN1B

IN1A

IN2B

IN2A

GND

GND

MUT

E

VCC

OUT2

A

OUT2

B

OUT1

A

OUT1

B

IN4B

IN4A

IN3B

IN3A

OP O

UT

OP IN

(–)

OP IN

(+)

GND

NC VCC

OUT3

A

OUT3

B

OUT4

A

OUT4

B

DRIVER

DRIVER

GND

MUTE

CONTROL

XRST

T.T(M)

POSI.1

POSI.2

T.T.SW

VDD

STB

CLOK

DATA I

DATA 0

LOADINGM-

LOADINGM+

SENSOR

1

8

2

3

4

5

6

7

16

9

15

TC14

13

12

11

10

SERIAL I/OCONTROL

LATCH

LATCHLATCH

36

PHD2

PHD1

PHD

33

LD

32

RF M

31

RF O

30

RF I

29

CP

28

CB

27

CC1

26

CC2

25

FOK

24 SENS

23 C. OUT

22 XRST

21 DATA

20 XLT

19 CLK

18 VCC

17 ISET

16 SL 0

15 SL M

14 SL P

13

12

TA O

TA M

11

FSET

10

TG2

9

TGU

8

SRCH

7

FE M

6

FE O

5

FLB

4

FGD

3

FDFC

T

2

FEI

1

FEO

48VC

47TDFCT

46TZC

45ATSC

44TEI

43LPFI

42TEO

41VEE

40EI

39E

38F

37FE BIAS

+

+

–+

+ –

+ –

+–

+– +–

+

– +

+

+–

+–

+–

+–

+–

+ –

+–

+–

–

+

+

–

–

+

+

–

+–

+–

+–

+ –

APC

–

–

–

–

LEVELS

FOK

MIRR

DFCT

RF IV AMP2

RF IV AMP1

FE A

MP

F IV AMP

E IV AMP

TE AMP

FZC COMP

BAL1

BAL2

BAL3

TOG1

TOG2

TOG3

TTL

IIL

IIL

TTL

TTL

IIL

• IIL DATA RESISTOR • INPUT SHIFT RESISTOR

• ADDRESS DECODER

• OUTPUT DECODER

HPF COMP LPF COMP

TZC COMP

DFCT

DFCT

TM1

FS4

ATSC

• WINDOW COMP

• FCS PHASE COMPENSATION

• TRACKING

• PHASE COMPENSATION

• ISET

FS1

FS2

TM4

TM5

TM6

TM3

TM7

TG2

• F

SET

TG1

TM2

+

–

TOG1-3 FS1-4 TG1-2 TM1-7 PS1-4

BAL1-3

35 34

+ –

3

6

9

12

15

2

5

8

11

14

1

4

7

10

13

28

25

22

19

16

29

26

23

20

17

30

27

24

21

18

+–

+–+–

LATCH

DECODER

CONTROL

SHIFTREGISTER

–+

LVROUT

LVRIN

LTOUT

LTCOM

LT4

LT3

LT2

LT1

L4

L3

L2

L1

VDD

CL

DI

RVROUT

RVRIN

RTOUT

RTCOM

RT4

RT3

RT2

RT1

R4

R3

R2

R1

VREF

VSS

CE

RF IN 1

2

3

4

5

6

7

8

9

BYPAS

GND

GND

MIX IN

IF

OSC

VCC

AFC

RF

VREF

MIX

REG

OSC BUF

CH2/A CH2/B NF VCC CG NF ALCMETAL

OUTPREOUT

TAPE A/TAPE B

RECOUT

RECIN

CH1/A CH1/B NF GND1 M/H NF

CH2CH2

ALC

M/N

CH1

GNDGND

CH1+–

+–

+– +

–

A/B

GNDMETALOUT

PREOUT

MIXOUT

RECOUT

RECIN

IREFVREF2

VREF1

24 23 22 21 20 19 18 17 16 15 14 13

1 2 3 4 5 6 7 8 9 10 11 12

1 2 3 4 5 6 7 8 9

1016 15 14 13 12 11

CONTROLCIRCUIT

12 BITSHIFT

REGISTER

12 BITSTORAGEREGISTER

OUTPUTBUFFER

(OPEN DRAIN)

1718

VDD

OE Q11

Q10

Q9 Q8 Q7 Q6 Q5Q4Q3Q2Q1Q0LC

K

CLOC

K

DATAVSS

3

6

9

12

15

18

2

5

8

11

14

17

1

4

7 10

13

16SHIFT

REGISTER

LATCH

ENABLE

SIN

CK

LATCH

SOUT

EN

RST

GND

GND

VDD

O1

O2

O3

O4

O5

O6

O7

O8

GND

IC603 (PANEL BOARD) BU2114

— 65 —

5-13. IC PIN FUNCTIONIC601 µPD780205FG (SYSTEM CONTROL) / PANEL BOARD

Pin No.

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

I/O

—

O

O

O

O

O

O

O

—

—

I

I

—

—

I

—

O

O

I

O

O

O

O

I

—

O

O

—

I

I

I

I

I

O

—

O

—

I

I

—

O

I

O

I

I

—

I

I

I

I

Pin Name

VDD

POWER OUT

S. MUTE OUT

TU. MUTE OUT

TUNED OUT

TAPE REC OUT

DBFB NORMAL

NC

NC

RESET

X2

X1

VSS

NC

POWER DOWN IN

VDD

SOCK

DATA

SOSO

XLAT

CE

CLK

DO

DI

VSS

CD STB

FLAT

VSS

K4

K3

K2

K1

K0

AVDD

AVREF

A LATCH

B LATCH

SCOR

REMOTE IN

VSS

NC

VSS

DECK STB

VR UP

VR DOWN

VDD

FM ST IN

SYNC REC IN

VSS

VSS

Description

VDD

Power switch output. ON: H, OFF: L

System mute output. ON: H, OFF: L

Tuner mute output. ON: H, OFF: L

Surround output. ON: H, OFF: L (Not used)

Function tape output. Tape: H, Others: L (Not used)

DBFB normal (U2: DBFB). ON: H, Others: L

DBFB high. ON: H, Others: L (Not used)

Not used

Reset input

X’tal 4.194314 MHz

X’tal 4.194314 MHz

Ground

Not used (open)

Power down input. AC ON: H, AC OFF: L

VDD

CXD2508A SQCK, CLOCK output

CXD2508A data output

CXD2508A SQSO input

CXD2508A XLAT output. Latch: L, Others: H

Chip enable output to LC7218, LC75392. Data: H, Address: L

CLK output

Data output

Data input

Ground

STB output to SN74HC4094. STB: L, Others: H

Flat output. Flat: H, Others: L (Not used)

Ground

Key input 4 to A/D

Key input 3 to A/D

Key input 2 to A/D

Key input 1 to A/D

Key input 0 to A/D

VDD of A/D converter

Reference voltage of A/D converter

Latch output to BU2092. Latch: H, Others: L

Not used

CXD2508A SCOR

Remote signal input. ON: H, OFF: L

Ground

Shift or load output to SN74HC165. Shift: H, Load: L (Not used)

Data input to SN74HC165 (Ground)

STB output to BU2114, SN74HC4094. STB:H, Others: L (Not used)

VR encoder A input. ON:L, OFF: H

VR encoder B input. ON:L, OFF: H

VDD

FM stereo indicator input. Stereo:L, Mono: H

Synchro record input. Record:L, Other: H

CD encoder A input. ON: L, OFF: H (Ground)

CD encoder B input. ON: L, OFF: H (Ground)

— 66 —

Pin No.

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

71

72

73

74

75

76

77

78

79

80

81

82

83

84

85

86

87

88

89

90

91

92

93

94

95

96

97

98

99

100

I/O

I

I

I

—

I

I

I

I

I

I

I

O

I

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

—

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

Description

Input from CXD2508A SENS

Input from CXD2508A FOK. OK: H, Others: L

Input from CXD2508A COUNT

Ground

Input from CD mechanism pick up switch. Up: L, Others: H

Input from CD mechanism pick down switch. Down: L, Others: H

Input from CD mechanism disc count switch. Count: L, Others: H

Input from CD mechanism turn table switch. ON: L, OFF: H

Input from CD mechanism tray open switch. Open: L, Others: H

Input from CD mechanism tray close switch. Open: L, Others: H

AMS signal input. During program: H, Interval between programs: L

Serial mute (tuner) output (Not used)

Input from destination select mode switch. ON: H, OFF: L

FLD segment signal output P1. ON: H, OFF: L















(–) negative power supply







FLD grid signal output 15. ON: H, OFF: L















Pin Name

SENS

FOK

COUNT

VSS

PIC UP

PIC DOWN

DISC COUNT SW

TURN TABLE SW

TRAY OPEN SW

TRAY CLOSE SW

VSS

SERI MUTE

(TUNER)

MODE SW IN

P1

P2

P3

P4

P5

P6

P7

P8

P9

P10

P11

P12

P13

P14

P15

–V LOAD

P16

P17

P18

P19

P20

P21

G15

G14

G13

G12

G11

G10

G9

G8

G7

G6

G5

G4

G3

G2

G1

SECTION 6EXPLODED VIEWS

NOTE:• -XX, -X mean standardized parts, so they may

have some differences from the original one.• Items marked “*” are not stocked since they

are seldom required for routine service. Somedelay should be anticipated when ordering theseitems.

• The mechanical parts with no reference numberin the exploded views are not supplied.

• Hardware (# mark) list and accessories andpacking materials are given in the last of thisparts list.

— 67 —

When indicating parts by reference number,please include the board name.

The components identified by mark ! ordotted line with mark ! are critical for safety.Replace only with part number specified.

Les composants identifiés par une marque! sont critiques pour la sécurité.Ne les remplacer que par une pièce portantle numéro spécifié.

1

2

3

4

5

6

78

9

10

CD mechanism deckPT302

12

not supplied

#10

#10

#10

#10

#11

#11

#3

#11

#12

#3#11

#11

#11#3

#14

#14

#4

#4

#3

#11

#11

#11

#11

#10

#14

#2

#3

13

Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks

6-1. CABINET SECTION

1 4-210-584-01 WINDOW, CD* 2 4-210-616-01 COVER (-GRX), TOP

3 4-210-579-01 HOLDER, MAIN PC BOARD* 4 A-4405-480-A MAIN BOARD, COMPLETE (US,CND)* 4 A-4405-482-A MAIN BOARD, COMPLETE (E,AUS,SP,MY,TW)

* 4 A-4405-483-A MAIN BOARD, COMPLETE (MX)* 5 4-210-591-01 CABINET (A), REAR* 6 4-210-617-01 COVER, REAR (US,CND)* 6 4-210-618-01 COVER, REAR (E,SP,MY,TW)* 6 4-210-619-01 COVER, REAR (AUS,MX)

* 7 A-4405-477-A AMP BOARD, COMPLETE (US,CND)* 8 1-670-445-11 FUSE BOARD

!9 1-551-506-99 CORD, POWER (E,MX)!9 1-559-583-11 CORD, POWER (US,CND)!9 1-696-966-11 CORD, POWER (AUS)!9 1-765-558-11 CORD, POWER (SP,MY,TW)* 10 3-703-244-00 BUSHING (2104), CORD (AUS,SP,MY,TW)

10 3-703-571-11 BUSHING (S) (4516), CORD (US,CND,E,MX)12 4-210-580-01 SPACER (SCC-20), PC BOARD

* 13 1-771-477-11 VOLSEL BOARD!PT302 1-431-950-11 TRANSFORMER, POWER (US,CND)!PT302 1-431-952-11 TRANSFORMER, POWER (E,AUS,SP,MY,TW)

!PT302 1-431-953-11 TRANSFORMER, POWER (MX)

• AbbreviationCND : CanadianAUS : AustralianMX : Mexico

AED : North EuropeanSP : SingaporeMY : Malaysia

TW : TaiwanAR : ArgentineG : German

— 68 —


6-2. FRONT PANEL SECTION

51

5552

5657

5354

59

82

58

60

61 62

63

80

81

63

81

7968

67 6978

7170

66

64

65

86

72

77

74

7684

75

83

85

Cassette mechanism deck

79

73

#15

#15#15

#15

#16

#16#16

#16

#16

#16

#16#16

#16

#16

#16

#16

#16

#16

#16#16

not supplied

not supplied

not supplied

51 4-210-586-01 WINDOW (R), CASSETTE52 4-210-588-01 DOOR (R), CASSETTE53 4-210-577-01 SPRING (R), CASSETTE54 4-210-572-01 HOLDER (R), CASSETTE55 4-210-585-01 WINDOW (L), CASSETTE

56 4-210-587-01 DOOR (L), CASSETTE57 4-210-576-01 SPRING (L), CASSETTE58 4-210-571-01 HOLDER (L), CASSETTE59 4-992-154-01 RUBBER, FOOT60 4-210-592-01 WINDOW, DISPLAY

61 4-210-581-01 HOLDER, CD BUTTON62 4-962-708-01 EMBLEM (4-A), SONY63 4-992-131-01 DAMPER (GRY), GEAR64 4-210-553-01 BUTTON, POWER65 4-210-554-01 BUTTON, CLOCK

66 4-210-570-01 BUTTON (B), CD67 4-210-556-01 BUTTON, MODE68 4-210-560-01 BUTTON, REC69 4-210-562-01 KNOB, VOLUME

70 4-210-561-01 KNOB, JOG71 4-210-563-01 RING, JOG72 4-210-593-01 PLATE, DISPLAY73 4-210-558-01 BUTTON, SURROUND74 4-210-557-01 BUTTON, NEXT

75 4-210-555-01 BUTTON, FUNCTION76 4-210-559-01 BUTTON, UP/DOWN77 4-210-552-01 PANEL (B), FRONT78 4-210-574-01 WASHER (9Q), VOLUME79 4-210-578-01 SPRING, EJECT LEVER

80 4-210-575-01 LEVER, EJECT81 4-210-573-01 HOLDER, EJECT82 4-210-551-01 PANEL (A), FRONT

* 83 A-4405-479-A PANEL BOARD, COMPLETE (US,CND,MX)* 83 A-4405-485-A PANEL BOARD, COMPLETE (E,AUS,SP,MY,TW)

* 84 1-670-441-11 VOLUME BOARD* 85 A-4414-609-A DECK BOARD, COMPLETE* 86 1-670-443-11 CD BUTTON BOARD

— 69 —

6-3. CASSETTE MECHANISM DECK SECTION


151 1-759-633-11 DECK, MECHANICAL152 9-880-883-01 HOLDER HEAD ASSY153 9-880-884-01 FRAME HEAD154 9-880-885-01 SPRING AZIMUTH155 9-880-886-01 ARM PINCH L ASSY

156 9-880-887-01 ARM PINCH R ASSY157 9-880-889-01 COIL ASSY

158 9-880-890-01 PLUNGER159 9-880-891-01 MODE SW160 9-880-892-01 SWITCH LEAF161 9-880-893-01 BELT162 9-880-894-01 HOLDER HEAD ASSY

163 9-880-895-01 BELT164 9-880-896-01 MOTOR ASSY

161

158

not supplied157

160159

151

164

not supplied

not supplied

160

154

154

156

162

153

155

not supplied

156

152

153

155159160

158

157

not suppliednot supplied

163

not supplied

not supplied

— 70 —

6-4. CD MECHANISM DECK SECTION 1


* 201 1-670-801-11 MOTOR BOARD202 3-669-480-11 + PTPWH 2203 4-992-168-01 TRAY, CHANGER BASE204 4-992-180-01 PLATE, BLIND205 4-992-181-01 LEVER, SENSOR (SW)

206 4-992-182-01 SPRING, SENSOR (SW) LEVER207 4-992-170-01 BELT, LOADING208 4-992-171-01 PULLEY, GEAR209 4-992-179-01 GEAR, TR210 4-992-177-01 GEAR, TR LOCK

211 4-992-178-01 GEAR (C), RELAY212 4-992-187-01 CUSHION213 4-992-186-01 CUSHION, SW LEVER214 4-992-173-01 GEAR (B), RELAY

215 4-992-183-01 SCREW, RELAY GEAR (B)216 4-992-174-01 GEAR, CHANGE217 4-992-184-01 WASHER, CHANGE GEAR218 4-992-176-01 SPRING, CHANGE GEAR219 4-992-185-01 WASHER, CHANGE PLATE

220 4-992-172-01 GEAR (A), RELAY* 221 4-993-032-01 PLATE, CHANGE

222 4-993-033-01 WASHER, POLY ETHYLENE* 223 1-670-798-11 SW (B) BOARD* 224 1-670-797-11 SW (A) BOARD

* 225 4-993-034-01 GUIDE, RAIL226 4-993-140-01 TURN TABLEM103 X-4948-765-1 MOTOR ASSY (TURN TABLE)

203

223

204

209

225

225

217

215

219

214

221211

222

218

216220

207

210

213

212

208

206

205201

224

212

226202

#5

#5

M103

#5

#7

#7

#9

— 71 —

6-5. CD MECHANISM DECK SECTION 2

259

264

263

257

267256

258

262

261

254

266

252

253

251

268

259

255

#1

#1

#1 #1

#7

not supplied

#7

#7

#10

Base unit block

#1

M104


251 1-769-856-11 WIRE (FLAT TYPE) (5 CORE)252 4-992-190-01 UD-CAM253 4-992-191-01 UD-GEAR254 4-992-195-01 MAGNET

* 255 4-992-196-01 CHASSIS, MAIN

256 4-992-197-01 BELT, LOADING GEAR257 4-992-198-01 PULLEY (B), GEAR258 4-992-199-01 GEAR, SLIDE259 4-992-200-01 ROLLER

261 4-992-192-01 SPRING, BRAKE CAM262 4-992-193-01 LEVER, SW

* 263 1-670-800-11 SW (D) BOARD* 264 1-670-799-11 SW (C) BOARD

266 4-992-194-01 CLAMP

267 4-992-201-01 WASHER, POLYETHYLENE* 268 A-4414-924-A CD DECODER BOARD, COMPLETE

M104 X-4948-766-1 MOTOR ASSY (A) (TRAY)

— 72 —


6-6. BASE UNIT SECTION (KSM-213BCM)

302303302

307

306308

303

305

310

304

309

304

301

M101M102

#6

#6#6 #6

#18

not supplied

301 4-992-164-01 BASE, KSM MECHANICAL302 4-992-165-01 DAMPER (GREEN)303 4-992-166-01 DAMPER (RED)304 4-992-167-01 SPRING, MECHANICAL BASE305 2-626-907-01 GEAR (A) (S)

306 2-626-908-01 SHAFT, SLED

307 2-627-003-02 GEAR (B)!308 8-848-379-31 OPTICAL PICK-UP KSS-213B/S-N* 309 1-639-678-12 MOTOR (6P)(S) BOARD

310 1-783-740-11 WIRE (FLAT TYPE) (16 CORE)M101 X-2625-877-1 MOTOR ASSY (SPINDLE)

M102 X-2625-769-1 MOTOR ASSY (SLED)

The components identified bymark ! or dotted line with mark! are critical for safety.Replace only with part numberspecified.

Les composants identifiés parune marque ! sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numéro spécifié.

NOTE:• Due to standardization, replacements in the

parts list may be different from the partsspecified in the diagrams or the componentsused on the set.

• -XX, -X mean standardized parts, so they mayhave some difference from the original one.

• Items marked “*” are not stocked since theyare seldom required for routine service. Somedelay should be anticipated when ordering theseitems.

• CAPACITORS:uF: µF

• RESISTORSAll resistors are in ohms.METAL: metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF: nonflammable

• COILSuH: µH

• SEMICONDUCTORSIn each case, u: µ, for example:uA...: µA... , uPA... , µPA... ,uPB... , µPB... , uPC... , µPC... ,uPD..., µPD...

When indicating parts by reference number,please include the board name.

The components identified by mark ! ordotted line with mark ! are critical for safety.Replace only with part number specified.

Les composants identifiés par une marque! sont critiques pour la sécurité.Ne les remplacer que par une pièce portantle numéro spécifié.


— 73 —

SECTION 7ELECTRICAL PARTS LIST AMP

* A-4405-477-A AMP BOARD, COMPLETE*********************

* 1-533-293-11 FUSE HOLDER

< CAPACITOR >

C705 1-126-961-11 ELECT 2.2uF 20% 50VC706 1-126-961-11 ELECT 2.2uF 20% 50VC707 1-162-302-11 CERAMIC 0.0022uF 20% 16VC709 1-126-967-11 ELECT 47uF 20% 16VC710 1-126-967-11 ELECT 47uF 20% 16V

C711 1-126-968-11 ELECT 100uF 20% 50VC712 1-126-967-11 ELECT 47uF 20% 16VC715 1-126-967-11 ELECT 47uF 20% 16VC716 1-126-964-11 ELECT 10uF 20% 50VC719 1-137-150-11 FILM 0.01uF 5% 100V

C720 1-137-150-11 FILM 0.01uF 5% 100VC721 1-137-354-11 FILM 0.1uF 5% 100VC722 1-137-354-11 FILM 0.1uF 5% 100VC723 1-126-961-11 ELECT 2.2uF 20% 50VC724 1-137-150-11 FILM 0.01uF 5% 100V

C725 1-126-235-11 ELECT 100uF 20% 16VC726 1-126-967-11 ELECT 47uF 20% 16VC730 1-126-963-11 ELECT 4.7uF 20% 50VC735 1-162-282-31 CERAMIC 100PF 10% 50VC736 1-162-282-31 CERAMIC 100PF 10% 50V

C741 1-117-750-11 ELECT 3300uF 20% 63VC742 1-117-750-11 ELECT 3300uF 20% 63VC743 1-137-354-11 FILM 0.1uF 5% 100VC744 1-137-354-11 FILM 0.1uF 5% 100VC745 1-137-354-11 FILM 0.1uF 5% 100V

C746 1-137-354-11 FILM 0.1uF 5% 100VC748 1-161-055-00 CERAMIC 0.022uF 10% 50VC749 1-161-055-00 CERAMIC 0.022uF 10% 50VC750 1-126-943-11 ELECT 2200uF 20% 25VC752 1-126-933-11 ELECT 100uF 20% 16V

C753 1-161-055-00 CERAMIC 0.022uF 10% 50VC754 1-161-055-00 CERAMIC 0.022uF 10% 50VC755 1-126-948-11 ELECT 100uF 20% 35VC756 1-126-948-11 ELECT 100uF 20% 35VC757 1-161-055-00 CERAMIC 0.022uF 10% 50V

C758 1-126-949-11 ELECT 220uF 20% 35VC759 1-161-055-00 CERAMIC 0.022uF 10% 50VC760 1-126-933-11 ELECT 100uF 20% 16VC761 1-161-055-00 CERAMIC 0.022uF 10% 50VC762 1-126-935-11 ELECT 470uF 20% 16V

C763 1-161-055-00 CERAMIC 0.022uF 10% 50VC768 1-161-055-00 CERAMIC 0.022uF 10% 50VC770 1-126-967-11 ELECT 47uF 20% 50VC775 1-107-712-11 ELECT 3.3uF 20% 50VC776 1-161-055-00 CERAMIC 0.022uF 10% 50V

C777 1-161-055-00 CERAMIC 0.022uF 10% 50VC778 1-126-960-11 ELECT 1uF 20% 50VC781 1-126-933-11 ELECT 100uF 20% 16VC782 1-126-949-11 ELECT 220uF 20% 35VC783 1-161-055-00 CERAMIC 0.022uF 10% 50V

C784 1-161-055-00 CERAMIC 0.022uF 10% 50VC785 1-161-055-00 CERAMIC 0.022uF 10% 50V

< CONNECTOR >

CN703 1-564-510-11 PLUG, CONNECTOR 7P

< DIODE >

D701 8-719-025-88 DIODE GBU4JL-6088D705 8-719-031-85 DIODE 1N4002LD706 8-719-031-85 DIODE 1N4002LD707 8-719-031-85 DIODE 1N4002LD708 8-719-031-85 DIODE 1N4002L

D711 8-719-110-31 DIODE RD12ES-B2D712 8-719-921-67 DIODE MTZJ-8.2BD713 8-719-982-15 DIODE MTZJ-27BD714 8-719-010-34 DIODE UZ-4.7BSCD715 8-719-911-19 DIODE 1SS119

D716 8-719-911-19 DIODE 1SS119D717 8-719-911-19 DIODE 1SS119D718 8-719-911-19 DIODE 1SS119D720 8-719-031-85 DIODE 1N4002LD721 8-719-911-19 DIODE 1SS119

D731 8-719-031-85 DIODE 1N4002LD732 8-719-031-85 DIODE 1N4002L

< FUSE >

!F701 1-576-104-11 FUSE 2A/250V (US,CND,AUS)

< IC >

IC401 8-749-900-34 IC STK-4182MK2IC402 8-759-111-68 IC UPC1237HA



• AbbreviationCND : CanadianAUS : AustralianMX : Mexico

TW : TaiwanAR : ArgentineSP : SingaporeMY : Malaysia

Ref. No. Part No. Description Remarks

— 74 —


CD BUTTON

< TERMINAL >

JK703 1-694-443-11 TERMINAL BOARD

< TRANSISTOR >

Q701 8-729-188-23 TRANSISTOR 2SD882-PQ702 8-729-188-23 TRANSISTOR 2SD882-PQ703 8-729-232-32 TRANSISTOR 2SA965Q706 8-729-194-57 TRANSISTOR 2SC945-PQ707 8-729-194-57 TRANSISTOR 2SC945-P

Q708 8-729-119-76 TRANSISTOR 2SA1175-HFEQ709 8-729-231-55 TRANSISTOR 2SC2878-ABQ710 8-729-231-55 TRANSISTOR 2SC2878-AB

< RESISTOR >

R705 1-249-438-11 CARBON 56K 5% 1/4WR706 1-249-438-11 CARBON 56K 5% 1/4WR707 1-249-466-11 CARBON 56K 5% 1/4WR708 1-249-466-11 CARBON 56K 5% 1/4WR709 1-247-128-00 CARBON 750 1% 1/4W

R710 1-247-128-00 CARBON 750 1% 1/4WR711 1-260-103-11 CARBON 2.2K 5% 1/2WR712 1-260-103-11 CARBON 2.2K 5% 1/2WR713 1-249-405-11 CARBON 100 5% 1/4W FR714 1-249-405-11 CARBON 100 5% 1/4W F

R715 1-247-717-11 CARBON 2.2K 5% 1/4W FR716 1-247-717-11 CARBON 2.2K 5% 1/4W FR718 1-247-713-11 CARBON 1K 5% 1/4W FR719 1-247-887-00 CARBON 220K 5% 1/4WR720 1-247-887-00 CARBON 220K 5% 1/4W

R721 1-249-406-11 CARBON 120 5% 1/4W FR722 1-249-406-11 CARBON 120 5% 1/4W FR723 1-220-853-11 METAL 0.1 10% 2WR724 1-220-853-11 METAL 0.1 10% 2WR725 1-249-420-11 CARBON 1.8K 5% 1/4W F

R726 1-249-420-11 CARBON 1.8K 5% 1/4W FR727 1-249-459-11 CARBON 12K 5% 1/4WR728 1-249-459-11 CARBON 12K 5% 1/4WR729 1-247-717-11 CARBON 2.2K 5% 1/4W FR730 1-249-465-11 CARBON 47K 5% 1/4W

R731 1-247-887-00 CARBON 220K 5% 1/4WR732 1-247-713-11 CARBON 1K 5% 1/4W FR734 1-247-721-11 CARBON 4.7K 5% 1/4W FR735 1-260-076-11 CARBON 10 5% 1/2WR736 1-260-076-11 CARBON 10 5% 1/2W

R741 1-213-036-11 FUSIBLE 1 5% 1W FR742 1-247-706-11 CARBON 330 5% 1/4W FR743 1-247-714-11 CARBON 1.2K 5% 1/4W FR744 1-247-708-11 CARBON 470 5% 1/4W FR747 1-247-807-11 CARBON 100 5% 1/4W

R748 1-247-807-11 CARBON 100 5% 1/4WR751 1-247-807-11 CARBON 100 5% 1/4WR755 1-249-438-11 CARBON 56K 5% 1/4WR756 1-249-438-11 CARBON 56K 5% 1/4WR761 1-247-839-11 CARBON 2.2K 5% 1/4W

R762 1-247-839-11 CARBON 2.2K 5% 1/4WR765 1-247-855-11 CARBON 10K 5% 1/4WR767 1-247-839-11 CARBON 2.2K 5% 1/4W

< RELAY >

RL701 1-515-921-11 RELAY (12V)************************************************************

* 1-670-443-11 CD BUTTON BOARD****************

< LED >

LED602 8-719-046-80 DIODE SML19416W-TP4LED603 8-719-046-80 DIODE SML19416W-TP4LED604 8-719-046-80 DIODE SML19416W-TP4

< RESISTOR >

R680 1-247-841-11 CARBON 2.7K 5% 1/4WR681 1-247-845-11 CARBON 3.9K 5% 1/4W FR682 1-247-851-11 CARBON 6.8K 5% 1/4WR683 1-247-859-11 CARBON 15K 5% 1/4WR684 1-247-869-11 CARBON 39K 5% 1/4W

< SWITCH >

S624 1-762-875-11 SWITCH, KEYBOARD (DISK 1)S625 1-762-875-11 SWITCH, KEYBOARD (DISK 2)S626 1-762-875-11 SWITCH, KEYBOARD (DISK 3)S627 1-762-875-11 SWITCH, KEYBOARD (DISK SKIP)S628 1-762-875-11 SWITCH, KEYBOARD (OPEN/EJECT)

************************************************************

* A-4414-924-A CD DECODER BOARD, COMPLETE****************************

< CAPACITOR >

C02 1-126-963-11 ELECT 4.7uF 20% 50VC03 1-126-933-11 ELECT 100uF 20% 10VC04 1-162-306-11 CERAMIC 0.01uF 20% 16VC04A 1-164-159-11 CERAMIC 0.1uF 50VC05 1-136-159-00 FILM 0.033uF 5% 50V

C06 1-162-306-11 CERAMIC 0.01uF 20% 16VC07 1-136-159-00 FILM 0.033uF 5% 50VC07A 1-162-199-31 CERAMIC 10PF 5% 50VC08 1-161-494-00 CERAMIC 0.022uF 25VC09 1-126-959-11 ELECT 0.47uF 20% 50V

C10 1-162-306-11 CERAMIC 0.01uF 20% 16VC11 1-126-933-11 ELECT 100uF 20% 10VC11A 1-164-159-11 CERAMIC 0.1uF 50VC12 1-162-306-11 CERAMIC 0.01uF 20% 16VC13 1-164-159-11 CERAMIC 0.1uF 50V

C14 1-162-302-11 CERAMIC 0.0022uF 30% 16VC15 1-164-159-11 CERAMIC 0.1uF 50VC16 1-136-159-00 FILM 0.033uF 5% 50VC17 1-136-165-00 FILM 0.1uF 5% 50VC18 1-164-159-11 CERAMIC 0.1uF 50V

C19 1-126-963-11 ELECT 4.7uF 20% 50VC20 1-162-306-11 CERAMIC 0.01uF 20% 16VC21 1-136-157-00 FILM 0.022uF 5% 50VC22 1-126-933-11 ELECT 100uF 20% 10VC23 1-164-159-11 CERAMIC 0.1uF 50V

C24 1-126-965-11 ELECT 22uF 20% 50VC25 1-126-960-11 ELECT 1uF 20% 50VC26 1-161-494-00 CERAMIC 0.022uF 25VC27 1-162-306-11 CERAMIC 0.01uF 20% 16VC28 1-164-159-11 CERAMIC 0.1uF 50V

CD DECODERAMP


— 75 —


C30 1-126-933-11 ELECT 100uF 20% 10VC30A 1-164-159-11 CERAMIC 0.1uF 50VC31 1-162-600-11 CERAMIC 0.0047uF 30% 16VC32 1-162-301-11 CERAMIC 0.0015uF 30% 16VC33 1-162-306-11 CERAMIC 0.01uF 20% 16V

C34 1-162-286-31 CERAMIC 220PF 10% 50VC35 1-162-306-11 CERAMIC 0.01uF 20% 16VC36 1-126-963-11 ELECT 4.7uF 20% 50VC37 1-164-159-11 CERAMIC 0.1uF 50VC37A 1-126-925-11 ELECT 470uF 20% 10V

C38 1-102-958-00 CERAMIC 20PF 5% 50VC39 1-102-958-00 CERAMIC 20PF 5% 50VC41A 1-162-294-31 CERAMIC 0.001uF 10% 50VC42A 1-162-294-31 CERAMIC 0.001uF 10% 50VC44A 1-162-294-31 CERAMIC 0.001uF 10% 50V

C45 1-126-934-11 ELECT 220uF 20% 10VC46 1-126-933-11 ELECT 100uF 20% 10VC51 1-162-288-31 CERAMIC 330PF 10% 50VC51A 1-126-959-11 ELECT 0.47uF 20% 50VC52 1-162-288-31 CERAMIC 330PF 10% 50V

C53 1-162-284-31 CERAMIC 150PF 10% 50VC54 1-162-284-31 CERAMIC 150PF 10% 50VC55 1-162-284-31 CERAMIC 150PF 10% 50VC56 1-162-284-31 CERAMIC 150PF 10% 50VC57 1-126-961-11 ELECT 2.2uF 20% 50V

C58 1-126-961-11 ELECT 2.2uF 20% 50VC59 1-162-294-31 CERAMIC 0.001uF 10% 50VC60 1-162-294-31 CERAMIC 0.001uF 10% 50VC81 1-164-159-11 CERAMIC 0.1uF 50VC83 1-164-159-11 CERAMIC 0.1uF 50V

C84 1-162-282-31 CERAMIC 100PF 10% 50VC85 1-162-292-31 CERAMIC 680PF 10% 50VC86 1-162-282-31 CERAMIC 100PF 10% 50VC86A 1-161-494-00 CERAMIC 0.022uF 25VC87 1-162-282-31 CERAMIC 100PF 10% 50V

C88 1-162-282-31 CERAMIC 100PF 10% 50VC90 1-161-494-00 CERAMIC 0.022uF 25VC90A 1-164-159-11 CERAMIC 0.1uF 50VC98 1-161-494-00 CERAMIC 0.022uF 25V

< CONNECTOR >

CN01 1-580-475-11 SOCKET, CONNECTOR 16PCN05 1-564-721-11 PIN, CONNECTOR (SMALL TYPE) 5PCN06 1-695-366-21 PIN, CONNECTOR (PC BOARD) 5PCN09 1-770-528-31 PIN, CONNECTOR (PC BOARD) 21P

< DIODE >

D01 8-719-911-19 DIODE 1SS119-25D04 8-719-921-41 DIODE 1SS133TD04A 8-719-991-33 DIODE 1SS176

< IC >

IC01 8-752-069-56 IC CXA1782BQIC02 8-759-388-27 IC TC9173PIC03 8-759-429-31 IC BA5941FPIC04 8-752-373-06 IC CXD2508AQIC05 8-759-505-55 IC NJM4558L

IC06 8-759-505-55 IC NJM4558L

< COIL >

L01 1-410-509-11 INDUCTOR 10uH

< TRANSISTOR >

Q01 8-729-195-23 TRANSISTOR 2SA952Q02 8-729-195-23 TRANSISTOR 2SA952Q04 8-729-194-57 TRANSISTOR 2SC945-PQ11 8-729-195-23 TRANSISTOR 2SA952

< RESISTOR >

R01 1-249-459-11 CARBON 12K 5% 1/4WR02 1-249-430-11 CARBON 12K 5% 1/4WR03 1-249-397-11 CARBON 22 5% 1/4W FR04A 1-249-409-11 CARBON 220 5% 1/4WR05 1-247-863-11 CARBON 22K 5% 1/4W

R06 1-247-847-11 CARBON 4.7K 5% 1/4WR07 1-249-430-11 CARBON 12K 5% 1/4WR07A 1-249-430-11 CARBON 12K 5% 1/4WR07B 1-249-430-11 CARBON 12K 5% 1/4WR08 1-249-460-11 CARBON 15K 5% 1/4W

R09 1-249-460-11 CARBON 15K 5% 1/4WR09A 1-247-847-11 CARBON 4.7K 5% 1/4WR10 1-247-718-11 CARBON 2.7K 5% 1/4W FR11 1-249-438-11 CARBON 56K 5% 1/4WR12 1-247-879-11 CARBON 100K 5% 1/4W

R13 1-247-896-11 CARBON 510K 5% 1/4WR13A 1-247-861-11 CARBON 18K 5% 1/4WR14 1-247-879-11 CARBON 100K 5% 1/4WR14A 1-247-861-11 CARBON 18K 5% 1/4WR15 1-247-881-00 CARBON 120K 5% 1/4W

R16 1-247-887-00 CARBON 220K 5% 1/4WR17 1-247-879-11 CARBON 100K 5% 1/4WR18 1-249-428-11 CARBON 8.2K 5% 1/4W FR19 1-249-431-11 CARBON 15K 5% 1/4WR21 1-247-863-11 CARBON 22K 5% 1/4W

R22 1-247-879-11 CARBON 100K 5% 1/4WR23 1-249-430-11 CARBON 12K 5% 1/4WR24 1-247-883-00 CARBON 150K 5% 1/4WR25 1-247-879-11 CARBON 100K 5% 1/4WR26 1-247-855-11 CARBON 10K 5% 1/4W

R27 1-249-430-11 CARBON 12K 5% 1/4WR28 1-247-855-11 CARBON 10K 5% 1/4WR29 1-247-843-11 CARBON 3.3K 5% 1/4WR30 1-247-843-11 CARBON 3.3K 5% 1/4WR31 1-247-855-11 CARBON 10K 5% 1/4W

R32 1-247-903-00 CARBON 1M 5% 1/4WR33 1-247-855-11 CARBON 10K 5% 1/4WR34 1-247-879-11 CARBON 100K 5% 1/4WR35 1-247-847-11 CARBON 4.7K 5% 1/4WR36 1-247-847-11 CARBON 4.7K 5% 1/4W

R37 1-247-807-11 CARBON 100 5% 1/4WR38 1-247-807-11 CARBON 100 5% 1/4WR39 1-247-847-11 CARBON 4.7K 5% 1/4WR41 1-247-807-11 CARBON 100 5% 1/4WR42 1-247-807-11 CARBON 100 5% 1/4W

R44 1-247-807-11 CARBON 100 5% 1/4WR50 1-247-847-11 CARBON 4.7K 5% 1/4W

CD DECODER


— 76 —


R52 1-247-721-11 CARBON 4.7K 5% 1/4W FR53 1-249-411-11 CARBON 330 5% 1/4WR56 1-247-847-11 CARBON 4.7K 5% 1/4WR57 1-249-427-11 CARBON 6.8K 5% 1/4W FR58 1-249-442-11 CARBON 510 5% 1/4W

R59 1-247-903-00 CARBON 1M 5% 1/4WR61 1-247-855-11 CARBON 10K 5% 1/4WR62 1-247-855-11 CARBON 10K 5% 1/4WR63 1-247-855-11 CARBON 10K 5% 1/4WR64 1-247-855-11 CARBON 10K 5% 1/4W


R70 1-249-430-11 CARBON 12K 5% 1/4WR71 1-249-430-11 CARBON 12K 5% 1/4WR72 1-249-430-11 CARBON 12K 5% 1/4WR73 1-247-839-11 CARBON 2.2K 5% 1/4WR74 1-247-839-11 CARBON 2.2K 5% 1/4W

R75 1-247-847-11 CARBON 4.7K 5% 1/4WR76 1-247-847-11 CARBON 4.7K 5% 1/4WR79 1-249-405-11 CARBON 100 5% 1/4W FR80 1-247-883-00 CARBON 150K 5% 1/4WR81 1-247-807-11 CARBON 100 5% 1/4W

R82 1-247-807-11 CARBON 100 5% 1/4WR83 1-249-469-11 CARBON 100K 5% 1/4WR84 1-249-465-11 CARBON 47K 5% 1/4WR85 1-249-465-11 CARBON 47K 5% 1/4WR86 1-249-465-11 CARBON 47K 5% 1/4W

R87 1-249-465-11 CARBON 47K 5% 1/4WR88 1-249-469-11 CARBON 100K 5% 1/4WR89 1-247-839-11 CARBON 2.2K 5% 1/4WR90 1-247-839-11 CARBON 2.2K 5% 1/4WR90B 1-247-831-11 CARBON 1K 5% 1/4W

R91 1-247-839-11 CARBON 2.2K 5% 1/4WR92 1-247-839-11 CARBON 2.2K 5% 1/4WR93 1-249-420-11 CARBON 1.8K 5% 1/4W FR94 1-249-420-11 CARBON 1.8K 5% 1/4W F

< VARIABLE RESISTOR >

VR01 1-228-996-00 RES, ADJ, METAL 47KVR02 1-228-998-00 RES, ADJ, METAL 220K

< CRYSTAL >

XTL01 1-760-123-11 VIBRATOR, CRYSTAL 33.8688MHz************************************************************

* A-4414-609-A DECK BOARD, COMPLETE*********************

< CAPACITOR >

C201 1-162-292-31 CERAMIC 680PF 10% 50VC202 1-162-292-31 CERAMIC 680PF 10% 50VC203 1-162-292-31 CERAMIC 680PF 10% 50VC204 1-162-292-31 CERAMIC 680PF 10% 50VC205 1-162-286-31 CERAMIC 220PF 10% 50V

C206 1-162-286-31 CERAMIC 220PF 10% 50VC207 1-162-286-31 CERAMIC 220PF 10% 50VC208 1-162-286-31 CERAMIC 220PF 10% 50V

C209 1-126-933-11 ELECT 100uF 20% 10VC210 1-126-933-11 ELECT 100uF 20% 10VC211 1-161-054-00 CERAMIC 0.018uF 10% 25VC212 1-161-054-00 CERAMIC 0.018uF 10% 25VC213 1-126-960-11 ELECT 1uF 20% 50V

C214 1-126-960-11 ELECT 1uF 20% 50VC215 1-162-301-11 CERAMIC 0.0015uF 30% 16VC216 1-162-301-11 CERAMIC 0.0015uF 30% 16VC217 1-126-967-11 ELECT 47uF 20% 16VC218 1-126-940-11 ELECT 330uF 20% 16V

C219 1-126-962-11 ELECT 3.3uF 20% 50VC221 1-126-962-11 ELECT 3.3uF 20% 50VC222 1-126-962-11 ELECT 3.3uF 20% 50VC223 1-162-290-31 CERAMIC 470PF 10% 50VC224 1-162-290-31 CERAMIC 470PF 10% 50V

C225 1-164-736-31 CERAMIC 0.0012uF 10% 50VC226 1-164-736-31 CERAMIC 0.0012uF 10% 50VC227 1-162-286-31 CERAMIC 220PF 10% 50VC228 1-162-286-31 CERAMIC 220PF 10% 50VC229 1-126-933-11 ELECT 100uF 20% 16V

C230 1-126-933-11 ELECT 100uF 20% 16VC231 1-126-962-11 ELECT 3.3uF 20% 50VC232 1-126-962-11 ELECT 3.3uF 20% 50VC233 1-162-294-31 CERAMIC 0.001uF 10% 50VC234 1-162-294-31 CERAMIC 0.001uF 10% 50V

C237 1-161-494-00 CERAMIC 0.022uF 25VC238 1-126-961-11 ELECT 2.2uF 20% 50VC251 1-137-351-11 FILM 0.022uF 5% 100VC252 1-137-350-11 FILM 0.015uF 5% 100VC253 1-137-150-11 FILM 0.01uF 5% 100V

C254 1-130-479-00 MYLAR 0.0047uF 5% 50VC255 1-126-967-11 ELECT 47uF 20% 16VC501 1-126-934-11 ELECT 220uF 20% 16VC502 1-126-960-11 ELECT 1uF 20% 50VC503 1-162-286-31 CERAMIC 220PF 10% 50V

C504 1-162-286-31 CERAMIC 220PF 10% 50VC505 1-162-286-31 CERAMIC 220PF 10% 50VC506 1-126-959-11 ELECT 0.47 20% 50VC507 1-126-959-11 ELECT 0.47 20% 50VC551 1-162-306-11 CERAMIC 0.01uF 20% 16V

C553 1-126-960-11 ELECT 1uF 20% 50VC554 1-126-956-11 ELECT 0.1uF 20% 50VC555 1-126-960-11 ELECT 1uF 20% 50VC556 1-126-933-11 ELECT 100uF 20% 16V

< CONNECTOR >

* CN603 1-568-273-11 SOCKET, CONNECTOR 7P

< DIODE >

D201 8-719-911-19 DIODE 1SS119D202 8-719-911-19 DIODE 1SS119D501 8-719-911-19 DIODE 1SS119D502 8-719-911-19 DIODE 1SS119D551 8-719-911-19 DIODE 1SS119

D552 8-719-911-19 DIODE 1SS119

< IC >

IC201 8-759-242-58 IC TA8189NIC501 8-759-234-75 IC TC74HC4094AP

CD DECODER DECK


— 77 —


IC502 8-759-916-52 IC SN74HC165AN

< COIL >

L251 1-416-771-11 COIL (BIAS)

< TRANSISTOR >

Q201 8-729-194-57 TRANSISTOR 2SC945-PQ202 8-729-194-57 TRANSISTOR 2SC945-PQ203 8-729-194-57 TRANSISTOR 2SC945-PQ204 8-729-194-57 TRANSISTOR 2SC945-PQ205 8-729-194-57 TRANSISTOR 2SC945-P

Q206 8-729-194-57 TRANSISTOR 2SC945-PQ207 8-729-119-76 TRANSISTOR 2SA1175-HFEQ208 8-729-173-37 TRANSISTOR 2SA733PQ209 8-729-194-57 TRANSISTOR 2SC945-PQ213 8-729-194-57 TRANSISTOR 2SC945-P

Q214 8-729-194-57 TRANSISTOR 2SC945-PQ251 8-729-142-46 TRANSISTOR 2SC2001-LKQ252 8-729-173-37 TRANSISTOR 2SA733PQ253 8-729-194-57 TRANSISTOR 2SC945-PQ501 8-729-194-57 TRANSISTOR 2SC945-P

Q502 8-729-993-43 TRANSISTOR 2SA934RQ503 8-729-173-37 TRANSISTOR 2SA733PQ504 8-729-140-96 TRANSISTOR 2SD774-34Q505 8-729-173-37 TRANSISTOR 2SA733PQ506 8-729-140-96 TRANSISTOR 2SD774-34

Q551 8-729-194-57 TRANSISTOR 2SC945-PQ552 8-729-194-57 TRANSISTOR 2SC945-P

< RESISTOR >

R201 1-249-393-11 CARBON 10 5% 1/4W FR202 1-249-393-11 CARBON 10 5% 1/4W FR203 1-247-688-11 CARBON 10 5% 1/4W FR204 1-247-688-11 CARBON 10 5% 1/4W FR205 1-249-401-11 CARBON 47 5% 1/4W F

R206 1-247-696-11 CARBON 47 5% 1/4W FR207 1-249-428-11 CARBON 8.2K 5% 1/4W FR208 1-249-428-11 CARBON 8.2K 5% 1/4W FR209 1-247-889-00 CARBON 270K 5% 1/4WR210 1-247-889-00 CARBON 270K 5% 1/4W

R211 1-247-891-00 CARBON 330K 5% 1/4WR212 1-247-891-00 CARBON 330K 5% 1/4WR213 1-247-847-11 CARBON 4.7K 5% 1/4WR214 1-247-847-11 CARBON 4.7K 5% 1/4WR215 1-247-891-00 CARBON 330K 5% 1/4W

R216 1-247-891-00 CARBON 330K 5% 1/4WR219 1-249-430-11 CARBON 12K 5% 1/4WR220 1-249-430-11 CARBON 12K 5% 1/4WR221 1-247-855-11 CARBON 10K 5% 1/4WR222 1-247-704-11 CARBON 220 5% 1/4W F


R228 1-247-881-00 CARBON 120K 5% 1/4WR229 1-249-420-11 CARBON 1.8K 5% 1/4W FR230 1-249-420-11 CARBON 1.8K 5% 1/4W FR231 1-247-839-11 CARBON 2.2K 5% 1/4WR232 1-247-839-11 CARBON 2.2K 5% 1/4W

R233 1-247-863-11 CARBON 22K 5% 1/4WR234 1-247-863-11 CARBON 22K 5% 1/4WR235 1-247-847-11 CARBON 4.7K 5% 1/4WR236 1-247-847-11 CARBON 4.7K 5% 1/4WR239 1-249-381-11 CARBON 1 5% 1/4W F

R240 1-247-855-11 CARBON 10K 5% 1/4WR241 1-247-847-11 CARBON 4.7K 5% 1/4WR242 1-247-847-11 CARBON 4.7K 5% 1/4WR243 1-249-430-11 CARBON 12K 5% 1/4WR244 1-247-839-11 CARBON 2.2K 5% 1/4W

R245 1-247-839-11 CARBON 2.2K 5% 1/4WR246 1-249-434-11 CARBON 27K 5% 1/4WR252 1-249-393-11 CARBON 10 5% 1/4W FR253 1-247-708-11 CARBON 470 5% 1/4W FR501 1-247-713-11 CARBON 1K 5% 1/4W F

R502 1-249-417-11 CARBON 1K 5% 1/4W FR503 1-249-417-11 CARBON 1K 5% 1/4W FR504 1-247-847-11 CARBON 4.7K 5% 1/4WR505 1-249-417-11 CARBON 1K 5% 1/4W FR506 1-249-417-11 CARBON 1K 5% 1/4W F

R507 1-249-417-11 CARBON 1K 5% 1/4W FR508 1-247-847-11 CARBON 4.7K 5% 1/4WR509 1-247-839-11 CARBON 2.2K 5% 1/4WR510 1-247-855-11 CARBON 10K 5% 1/4WR511 1-247-855-11 CARBON 10K 5% 1/4W

R512 1-249-417-11 CARBON 1K 5% 1/4W FR513 1-247-846-11 CARBON 4.3K 5% 1/4WR514 1-247-855-11 CARBON 10K 5% 1/4WR515 1-247-855-11 CARBON 10K 5% 1/4WR516 1-249-413-11 CARBON 470 5% 1/4W F

R517 1-247-847-11 CARBON 4.7K 5% 1/4WR518 1-247-863-11 CARBON 22K 5% 1/4WR519 1-247-847-11 CARBON 4.7K 5% 1/4WR520 1-247-847-11 CARBON 4.7K 5% 1/4WR521 1-247-721-11 CARBON 4.7K 5% 1/4W F

R522 1-247-721-11 CARBON 4.7K 5% 1/4W FR523 1-247-847-11 CARBON 4.7K 5% 1/4WR524 1-247-863-11 CARBON 22K 5% 1/4WR525 1-247-855-11 CARBON 10K 5% 1/4WR526 1-247-855-11 CARBON 10K 5% 1/4W

R527 1-249-413-11 CARBON 470 5% 1/4W FR528 1-247-847-11 CARBON 4.7K 5% 1/4WR551 1-247-855-11 CARBON 10K 5% 1/4WR553 1-247-885-00 CARBON 180K 5% 1/4WR554 1-247-899-11 CARBON 680K 5% 1/4W

R555 1-247-855-11 CARBON 10K 5% 1/4WR556 1-249-413-11 CARBON 470 5% 1/4W FR557 1-247-885-00 CARBON 180K 5% 1/4WR558 1-247-899-11 CARBON 680K 5% 1/4WR559 1-247-855-11 CARBON 10K 5% 1/4W

R560 1-249-413-11 CARBON 470 5% 1/4W FR561 1-247-855-11 CARBON 10K 5% 1/4WR562 1-247-879-11 CARBON 100K 5% 1/4WR563 1-247-704-11 CARBON 220 5% 1/4W FR205A 1-249-409-11 CARBON 220 5% 1/4W F

R206A 1-249-409-11 CARBON 220 5% 1/4W F

< ADJ >

SFR501 1-228-991-00 RES, ADJ, METAL 2.2K************************************************************

DECK


— 78 —


* 1-670-445-11 FUSE BOARD***********

1-533-293-11 FUSE HOLDER

< TERMINAL >

AC1 1-535-416-00 TERMINALAC2 1-535-416-00 TERMINALP6 1-535-416-00 TERMINALP7 1-535-416-00 TERMINAL

< FUSE >

!F702 1-576-108-11 FUSE 4A/125V

< RESISTOR >

!R001 1-202-727-00 CARBON 4.7M 5% 1/3W (US,CND)************************************************************

* A-4405-480-A MAIN BOARD, COMPLETE (US,CND)*********************

* A-4405-482-A MAIN BOARD, COMPLETE (E,AUS,SP,MY,TW)*********************

* A-4405-483-A MAIN BOARD, COMPLETE (MX)*********************

< CAPACITOR >

C101 1-161-379-00 CERAMIC 0.01uF 20% 25VC102 1-161-379-00 CERAMIC 0.01uF 20% 25VC103 1-162-195-31 CERAMIC 4.7PF 10% 50VC104 1-161-494-00 CERAMIC 0.022uF 25VC105 1-162-206-31 CERAMIC 20PF 5% 50V

C106 1-161-494-00 CERAMIC 0.022uF 25VC108 1-126-933-11 ELECT 100uF 20% 16VC109 1-162-191-31 CERAMIC 2.2PF 10% 50VC110 1-162-191-31 CERAMIC 2.2PF 10% 50VC111 1-162-217-31 CERAMIC 56PF 5% 50V

C112 1-162-294-31 CERAMIC 0.001uF 10% 50VC115 1-161-379-00 CERAMIC 0.01uF 20% 25VC116 1-130-014-00 FILM 470PF 5% 50VC117 1-162-205-31 CERAMIC 18PF 5% 50VC118 1-126-933-11 ELECT 100uF 20% 16V

C120 1-161-494-00 CERAMIC 0.022uF 25VC121 1-162-203-31 CERAMIC 15PF 5% 50VC122 1-126-961-11 ELECT 2.2uF 20% 50VC123 1-126-960-11 ELECT 1uF 20% 50VC124 1-162-206-31 CERAMIC 20PF 5% 50V

C125 1-126-960-11 ELECT 1uF 20% 50VC126 1-110-671-31 CERAMIC 47000PF 50VC127 1-126-964-11 ELECT 10uF 20% 50VC128 1-161-494-00 CERAMIC 0.022uF 25VC129 1-109-889-11 ELECT 1uF 20% 50V

C130 1-161-054-00 CERAMIC 0.018uF 10% 25VC131 1-161-054-00 CERAMIC 0.018uF 10% 25VC132 1-161-051-00 CERAMIC 0.01uF 10% 50VC133 1-161-051-00 CERAMIC 0.01uF 10% 50VC137 1-126-959-11 ELECT 0.47uF 20% 50V

C140 1-126-933-11 ELECT 100uF 20% 16VC141 1-161-494-00 CERAMIC 0.022uF 25VC142 1-126-933-11 ELECT 100uF 20% 16VC143 1-126-959-11 ELECT 0.47uF 20% 50VC144 1-161-494-00 CERAMIC 0.022uF 25V

C145 1-162-217-31 CERAMIC 56PF 5% 50VC146 1-161-744-00 CERAMIC 0.01uF 250VC148 1-161-494-00 CERAMIC 0.022uF 25VC149 1-161-744-00 CERAMIC 0.01uF 250VC151 1-128-551-11 ELECT 22uF 20% 25V

C152 1-162-294-31 CERAMIC 0.001uF 10% 50VC154 1-162-294-31 CERAMIC 0.001uF 10% 50VC155 1-162-294-31 CERAMIC 0.001uF 10% 50VC156 1-102-516-11 CERAMIC 27PF 5% 50VC157 1-102-516-11 CERAMIC 27PF 5% 50V

C158 1-126-967-11 ELECT 47uF 20% 16VC159 1-164-159-11 CERAMIC 0.1uF 50VC160 1-126-963-11 ELECT 4.7uF 20% 50VC161 1-126-963-11 ELECT 4.7uF 20% 50VC162 1-161-494-00 CERAMIC 0.022uF 25V

C163 1-161-494-00 CERAMIC 0.022uF 25VC164 1-126-962-11 ELECT 3.3uF 20% 50VC166 1-161-494-00 CERAMIC 0.022uF 25VC167 1-162-282-31 CERAMIC 100PF 10% 50VC175 1-130-485-00 MYLAR 0.015uF 5% 50V

C176 1-130-485-00 MYLAR 0.015uF 5% 50VC177 1-161-494-00 CERAMIC 0.022uF 25VC181 1-164-159-11 CERAMIC 0.1uF 50VC301 1-164-159-11 CERAMIC 0.1uF 50VC302 1-162-306-11 CERAMIC 0.01uF 20% 16V

C303 1-162-306-11 CERAMIC 0.01uF 20% 16VC305 1-126-959-11 ELECT 0.47uF 20% 50VC306 1-126-959-11 ELECT 0.47uF 20% 50VC307 1-126-959-11 ELECT 0.47uF 20% 50VC308 1-126-959-11 ELECT 0.47uF 20% 50V

C309 1-162-282-31 CERAMIC 100PF 10% 50VC310 1-162-282-31 CERAMIC 100PF 10% 50VC311 1-126-959-11 ELECT 0.47uF 20% 50VC312 1-126-959-11 ELECT 0.47uF 20% 50VC313 1-137-150-11 FILM 0.01uF 5% 100V

C314 1-137-150-11 FILM 0.01uF 5% 100VC317 1-136-479-11 FILM 0.001uF 5% 100VC318 1-136-479-11 FILM 0.001uF 5% 100VC319 1-136-480-11 FILM 0.0015uF 5% 100VC320 1-136-480-11 FILM 0.0015uF 5% 100V

C321 1-162-600-11 CERAMIC 0.0047uF 30% 16VC322 1-162-600-11 CERAMIC 0.0047uF 30% 16VC325 1-137-350-11 FILM 0.015uF 5% 100VC326 1-137-350-11 FILM 0.015uF 5% 100VC327 1-126-934-11 ELECT 220uF 20% 16V

C328 1-126-934-11 ELECT 220uF 20% 16VC329 1-162-282-31 CERAMIC 100PF 10% 50VC330 1-162-282-31 CERAMIC 100PF 10% 50VC331 1-126-960-11 ELECT 1uF 20% 50VC332 1-126-960-11 ELECT 1uF 20% 50V

C333 1-126-933-11 ELECT 100uF 20% 16VC334 1-126-960-11 ELECT 1uF 20% 50VC335 1-126-960-11 ELECT 1uF 20% 50VC336 1-126-962-11 ELECT 3.3uF 20% 50VC337 1-126-962-11 ELECT 3.3uF 20% 50V

C339 1-126-959-11 ELECT 0.47uF 20% 50VC340 1-126-959-11 ELECT 0.47uF 20% 50V

FUSE



MAIN


— 79 —


C341 1-126-960-11 ELECT 1uF 20% 50VC342 1-126-960-11 ELECT 1uF 20% 50VC343 1-126-963-11 ELECT 4.7uF 20% 50VC344 1-126-963-11 ELECT 4.7uF 20% 50VC345 1-137-353-11 FILM 0.047uF 5% 100V

C346 1-137-353-11 FILM 0.047uF 5% 100VC347 1-162-303-11 CERAMIC 0.0033uF 30% 16VC348 1-162-303-11 CERAMIC 0.0033uF 30% 16VC349 1-162-294-31 CERAMIC 0.001uF 10% 50VC350 1-162-294-31 CERAMIC 0.001uF 10% 50V

C351 1-137-354-11 FILM 0.1uF 5% 100VC352 1-137-354-11 FILM 0.1uF 5% 100VC353 1-126-962-11 ELECT 3.3uF 20% 50VC354 1-126-962-11 ELECT 3.3uF 20% 50VC355 1-126-933-11 ELECT 100uF 20% 16V

C356 1-126-933-11 ELECT 100uF 20% 16VC360 1-162-290-31 CERAMIC 470PF 10% 50VC361 1-162-290-31 CERAMIC 470PF 10% 50VC368 1-109-889-11 ELECT 1uF 20% 50VC371 1-161-494-00 CERAMIC 0.022uF 25V

C372 1-161-494-00 CERAMIC 0.022uF 25VC374 1-137-350-11 FILM 0.015uF 5% 100VC375 1-136-290-11 FILM 0.0062uF 5% 100VC376 1-136-290-11 FILM 0.0062uF 5% 100VC377 1-137-350-11 FILM 0.015uF 5% 100V

C378 1-126-959-11 ELECT 0.47uF 20% 50VC379 1-126-959-11 ELECT 0.47uF 20% 50VC391 1-162-292-31 CERAMIC 680PF 10% 50VC392 1-162-292-31 CERAMIC 680PF 10% 50VC393 1-162-292-31 CERAMIC 680PF 10% 50V

C394 1-162-294-31 CERAMIC 0.001uF 10% 50VC395 1-164-159-11 CERAMIC 0.1uF 50VC396 1-164-159-11 CERAMIC 0.1uF 50VC398 1-164-159-11 CERAMIC 0.1uF 50VC401 1-161-494-00 CERAMIC 0.022uF 25V

C402 1-126-948-11 ELECT 100uF 20% 35VC403 1-126-933-11 ELECT 100uF 20% 16VC404 1-161-494-00 CERAMIC 0.022uF 25VC405 1-126-933-11 ELECT 100uF 20% 16VC406 1-126-960-11 ELECT 1uF 20% 50V

C407 1-126-960-11 ELECT 1uF 20% 50VC408 1-162-294-31 CERAMIC 0.001uF 10% 50VC409 1-162-294-31 CERAMIC 0.001uF 10% 50VC410 1-126-933-11 ELECT 100uF 20% 16VC411 1-126-933-11 ELECT 100uF 20% 16V

C413 1-126-964-11 ELECT 10uF 20% 50VC414 1-126-964-11 ELECT 10uF 20% 50VC415 1-161-494-00 CERAMIC 0.022uF 25VC416 1-161-494-00 CERAMIC 0.022uF 25VC417 1-126-933-11 ELECT 100uF 20% 16V

C418 1-126-933-11 ELECT 100uF 20% 16VC419 1-161-494-00 CERAMIC 0.022uF 25VC420 1-161-494-00 CERAMIC 0.022uF 25VC421 1-164-159-11 CERAMIC 0.1uF 50VC431 1-126-964-11 ELECT 10uF 20% 50V

C432 1-126-961-11 ELECT 2.2uF 20% 50VC435 1-126-961-11 ELECT 2.2uF 20% 50VC436 1-126-961-11 ELECT 2.2uF 20% 50VC439 1-126-961-11 ELECT 2.2uF 20% 50VC440 1-126-961-11 ELECT 2.2uF 20% 50V

C442 1-161-494-00 CERAMIC 0.022uF 25VC445 1-126-962-11 ELECT 3.3uF 20% 50VC446 1-126-962-11 ELECT 3.3uF 20% 50VC447 1-126-964-11 ELECT 10uF 20% 50VC731 1-162-306-11 CERAMIC 0.01uF 20% 16V

C732 1-162-306-11 CERAMIC 0.01uF 20% 16V

< FILTER >

CF101 1-567-390-11 FILTER,CERAMIC 10.7MCF102 1-527-996-11 FILTER, CERAMICCF103 1-527-996-11 FILTER, CERAMICCF104 1-579-856-31 DISCRIMINATOR, CERAMICCF105 1-577-091-11 OSCILLATOR, CERAMIC

< CONNECTOR >

* CN303 1-770-335-11 PIN, CONNECTOR (PC BOARD) 20P

< TRIMMER >

CT101 1-141-304-21 CAP, TRIMMER 10PFCT102 1-141-304-21 CAP, TRIMMER 10PFCT104 1-141-304-21 CAP, TRIMMER 10PF

< DIODE >

D101 8-719-911-19 DIODE 1SS119D102 8-719-911-19 DIODE 1SS119D103 8-719-911-19 DIODE 1SS119D104 8-719-911-19 DIODE 1SS119D105 8-719-059-68 DIODE KV1340A

D106 8-719-059-68 DIODE KV1340AD107 8-719-800-72 DIODE 1SV149-BD109 8-719-911-19 DIODE 1SS119D110 8-719-109-89 DIODE RD5.6ESB2D111 8-719-911-19 DIODE 1SS119

D113 8-719-911-19 DIODE 1SS119D301 8-719-911-19 DIODE 1SS119D302 8-719-911-19 DIODE 1SS119D305 8-719-911-19 DIODE 1SS119D401 8-719-110-31 DIODE RD12ES-B2

D402 8-719-921-54 DIODE MTZJ-6.2B

< IC >

IC101 8-759-801-96 IC LA1186IC103 8-759-820-53 IC LA1145MIC301 8-759-473-59 IC LC75392IC302 8-759-244-66 IC TC74AC534PIC303 8-759-112-93 IC UPC4570HA-1

IC401 8-759-356-16 IC NJM4556AD

< JACK >

JK101 1-694-092-21 TERMINAL BOARD (SPEAKER)JK301 1-766-396-11 JACK, PIN 4PJK401 1-785-081-11 JACK (LARGE TYPE)

< COIL >

L101 1-429-550-11 TRANSFORMER, FM ANTL102 1-429-551-11 TRANSFORMER, FM RFL103 1-411-798-11 COIL, FM OSCL104 1-411-901-11 COIL, ANTENNAL105 1-429-555-11 TRANSFORMER, MW OSC

MAIN


— 80 —


L106 1-412-507-11 INDUCTOR 47uHL107 1-412-507-11 INDUCTOR 47uHL109 1-412-503-11 INDUCTOR 22uHL113 1-412-503-11 INDUCTOR 22uH

< TRANSISTOR >

Q101 8-729-015-41 TRANSISTOR 2SC1675-T1Q102 8-729-178-63 TRANSISTOR 2SC2786-KQ108 8-729-041-83 TRANSISTOR 2SK544EQ112 8-729-194-57 TRANSISTOR 2SC945-PQ113 8-729-194-57 TRANSISTOR 2SC945-P

Q114 8-729-902-80 TRANSISTOR DTA114YSQ116 8-729-194-57 TRANSISTOR 2SC945-PQ117 8-729-194-57 TRANSISTOR 2SC945-PQ301 8-729-194-57 TRANSISTOR 2SC945-PQ302 8-729-194-57 TRANSISTOR 2SC945-P

Q303 8-729-194-57 TRANSISTOR 2SC945-PQ304 8-729-194-57 TRANSISTOR 2SC945-PQ307 8-729-224-62 TRANSISTOR 2SK246-GRQ308 8-729-194-57 TRANSISTOR 2SC945-PQ309 8-729-194-57 TRANSISTOR 2SC945-P

Q310 8-729-422-57 TRANSISTOR UN4111Q319 8-729-194-57 TRANSISTOR 2SC945-PQ320 8-729-194-57 TRANSISTOR 2SC945-PQ321 8-729-194-57 TRANSISTOR 2SC945-PQ322 8-729-194-57 TRANSISTOR 2SC945-P

Q401 8-729-232-32 TRANSISTOR 2SA965Q403 8-729-142-46 TRANSISTOR 2SC2001-LKQ404 8-729-119-76 TRANSISTOR 2SA1175-HFEQ407 8-729-231-55 TRANSISTOR 2SC2878-ABQ408 8-729-231-55 TRANSISTOR 2SC2878-AB

Q409 8-729-140-96 TRANSISTOR 2SD774-34Q410 8-729-422-57 TRANSISTOR UN4111Q415 8-729-993-43 TRANSISTOR 2SA934RQ416 8-729-194-57 TRANSISTOR 2SC945-PQ417 8-729-029-72 TRANSISTOR DTC114YS

< RESISTOR >

R101 1-247-879-11 CARBON 100K 5% 1/4WR102 1-249-417-11 CARBON 1K 5% 1/4W FR103 1-247-692-11 CARBON 22 5% 1/4W FR104 1-247-807-11 CARBON 100 5% 1/4WR105 1-249-417-11 CARBON 1K 5% 1/4W F

R106 1-247-807-11 CARBON 100 5% 1/4WR107 1-249-427-11 CARBON 6.8K 5% 1/4W FR109 1-247-879-11 CARBON 100K 5% 1/4WR110 1-247-867-11 CARBON 33K 5% 1/4WR111 1-249-417-11 CARBON 1K 5% 1/4W F

R112 1-247-807-11 CARBON 100 5% 1/4WR113 1-247-879-11 CARBON 100K 5% 1/4WR114 1-247-879-11 CARBON 100K 5% 1/4WR115 1-249-417-11 CARBON 1K 5% 1/4W FR116 1-247-692-11 CARBON 22 5% 1/4W F

R117 1-247-855-11 CARBON 10K 5% 1/4WR118 1-247-807-11 CARBON 100 5% 1/4WR119 1-249-413-11 CARBON 470 5% 1/4W FR120 1-247-843-11 CARBON 3.3K 5% 1/4WR121 1-247-843-11 CARBON 3.3K 5% 1/4W

R123 1-247-847-11 CARBON 4.7K 5% 1/4WR123 1-249-428-11 CARBON 8.2K 5% 1/4W FR124 1-247-843-11 CARBON 3.3K 5% 1/4W

R126 1-249-417-11 CARBON 1K 5% 1/4W FR127 1-249-417-11 CARBON 1K 5% 1/4W FR128 1-247-883-00 CARBON 150K 5% 1/4WR129 1-247-883-00 CARBON 150K 5% 1/4WR130 1-249-405-11 CARBON 100 5% 1/4W F

R131 1-247-713-11 CARBON 1K 5% 1/4W FR132 1-247-855-11 CARBON 10K 5% 1/4WR133 1-247-843-11 CARBON 3.3K 5% 1/4WR134 1-249-427-11 CARBON 6.8K 5% 1/4W FR135 1-249-417-11 CARBON 1K 5% 1/4W F

R136 1-247-847-11 CARBON 4.7K 5% 1/4WR137 1-247-725-11 CARBON 10K 5% 1/4W FR138 1-249-405-11 CARBON 100 5% 1/4W FR139 1-247-855-11 CARBON 10K 5% 1/4WR140 1-247-855-11 CARBON 10K 5% 1/4W

R141 1-247-839-11 CARBON 2.2K 5% 1/4WR142 1-247-839-11 CARBON 2.2K 5% 1/4WR143 1-247-839-11 CARBON 2.2K 5% 1/4WR144 1-249-411-11 CARBON 330 5% 1/4WR147 1-247-843-11 CARBON 3.3K 5% 1/4W

R151 1-247-843-11 CARBON 3.3K 5% 1/4WR152 1-247-903-00 CARBON 1M 5% 1/4WR155 1-249-409-11 CARBON 220 5% 1/4W FR156 1-247-863-11 CARBON 22K 5% 1/4WR171 1-249-411-11 CARBON 330 5% 1/4W

R301 1-249-434-11 CARBON 27K 5% 1/4WR302 1-249-434-11 CARBON 27K 5% 1/4WR303 1-247-847-11 CARBON 4.7K 5% 1/4WR304 1-247-847-11 CARBON 4.7K 5% 1/4WR305 1-249-417-11 CARBON 1K 5% 1/4W F

R306 1-249-417-11 CARBON 1K 5% 1/4W FR307 1-247-847-11 CARBON 4.7K 5% 1/4WR308 1-247-847-11 CARBON 4.7K 5% 1/4WR309 1-249-440-11 CARBON 82K 5% 1/4WR310 1-249-440-11 CARBON 82K 5% 1/4W




R328 1-249-434-11 CARBON 27K 5% 1/4WR329 1-249-430-11 CARBON 12K 5% 1/4WR330 1-249-430-11 CARBON 12K 5% 1/4WR331 1-247-717-11 CARBON 2.2K 5% 1/4W FR332 1-247-717-11 CARBON 2.2K 5% 1/4W F

R333 1-247-717-11 CARBON 2.2K 5% 1/4W FR334 1-247-725-11 CARBON 10K 5% 1/4W FR334 1-247-855-11 CARBON 10K 5% 1/4WR335 1-247-855-11 CARBON 10K 5% 1/4WR336 1-247-847-11 CARBON 4.7K 5% 1/4W

MAIN


— 81 —


R337 1-247-704-11 CARBON 220 5% 1/4W FR338 1-247-708-11 CARBON 470 5% 1/4W FR339 1-247-897-11 CARBON 560K 5% 1/4WR340 1-247-897-11 CARBON 560K 5% 1/4WR341 1-249-418-11 CARBON 1.2K 5% 1/4W F

R342 1-249-418-11 CARBON 1.2K 5% 1/4W FR344 1-247-839-11 CARBON 2.2K 5% 1/4WR345 1-247-839-11 CARBON 2.2K 5% 1/4WR346 1-247-843-11 CARBON 3.3K 5% 1/4WR347 1-247-843-11 CARBON 3.3K 5% 1/4W


R355 1-247-863-11 CARBON 22K 5% 1/4WR356 1-247-839-11 CARBON 2.2K 5% 1/4WR357 1-247-839-11 CARBON 2.2K 5% 1/4WR358 1-247-871-11 CARBON 47K 5% 1/4WR359 1-247-871-11 CARBON 47K 5% 1/4W


R367 1-247-879-11 CARBON 100K 5% 1/4WR368 1-247-847-11 CARBON 4.7K 5% 1/4WR369 1-247-847-11 CARBON 4.7K 5% 1/4WR370 1-247-883-00 CARBON 150K 5% 1/4WR371 1-247-883-00 CARBON 150K 5% 1/4W

R372 1-247-887-00 CARBON 220K 5% 1/4WR373 1-247-887-00 CARBON 220K 5% 1/4WR375 1-247-710-11 CARBON 560 5% 1/4W FR378 1-247-867-11 CARBON 33K 5% 1/4WR379 1-247-867-11 CARBON 33K 5% 1/4W

R380 1-249-427-11 CARBON 6.8K 5% 1/4W FR381 1-249-427-11 CARBON 6.8K 5% 1/4W FR383 1-259-634-11 CARBON 18 2% 1WR384 1-249-469-11 CARBON 100K 5% 1/4WR385 1-247-879-11 CARBON 100K 5% 1/4W


R391 1-247-879-11 CARBON 100K 5% 1/4WR394 1-247-710-11 CARBON 560 5% 1/4W FR395 1-247-863-11 CARBON 22K 5% 1/4WR396 1-247-863-11 CARBON 22K 5% 1/4WR401 1-247-717-11 CARBON 2.2K 5% 1/4W F

R402 1-249-417-11 CARBON 1K 5% 1/4W FR404 1-247-871-11 CARBON 47K 5% 1/4WR405 1-247-871-11 CARBON 47K 5% 1/4WR406 1-247-855-11 CARBON 10K 5% 1/4WR407 1-247-855-11 CARBON 10K 5% 1/4W

R408 1-247-871-11 CARBON 47K 5% 1/4WR409 1-247-871-11 CARBON 47K 5% 1/4WR410 1-247-710-11 CARBON 560 5% 1/4W FR411 1-247-710-11 CARBON 560 5% 1/4W FR412 1-247-694-11 CARBON 33 5% 1/4W F

R413 1-247-694-11 CARBON 33 5% 1/4W FR414 1-247-839-11 CARBON 2.2K 5% 1/4WR415 1-247-839-11 CARBON 2.2K 5% 1/4WR416 1-247-871-11 CARBON 47K 5% 1/4WR417 1-247-855-11 CARBON 10K 5% 1/4W

R420 1-249-413-11 CARBON 470 5% 1/4W FR422 1-249-417-11 CARBON 1K 5% 1/4W FR430 1-249-417-11 CARBON 1K 5% 1/4W FR431 1-247-883-00 CARBON 150K 5% 1/4WR432 1-247-871-11 CARBON 47K 5% 1/4W

R433 1-247-871-11 CARBON 47K 5% 1/4WR434 1-247-839-11 CARBON 2.2K 5% 1/4WR435 1-247-839-11 CARBON 2.2K 5% 1/4WR436 1-247-855-11 CARBON 10K 5% 1/4WR437 1-249-427-11 CARBON 6.8K 5% 1/4W F

R438 1-249-427-11 CARBON 6.8K 5% 1/4W FR450 1-247-855-11 CARBON 10K 5% 1/4WR451 1-247-863-11 CARBON 22K 5% 1/4WR452 1-249-417-11 CARBON 1K 5% 1/4W FR453 1-247-839-11 CARBON 2.2K 5% 1/4W

R454 1-247-839-11 CARBON 2.2K 5% 1/4WR455 1-247-855-11 CARBON 10K 5% 1/4WR456 1-247-855-11 CARBON 10K 5% 1/4WR457 1-247-855-11 CARBON 10K 5% 1/4WR467 1-249-417-11 CARBON 1K 5% 1/4W F

< ADJ >

SFR101 1-228-995-00 RES, ADJ, METAL 22K

< SWITCH >

SW101 1-762-735-11 SWITCH, SLIDE (E,AUS,SP,MY,TW)

< TRANSFORMER >

T101 1-429-553-11 TRANSFORMER, FM IFTT102 1-429-554-11 TRANSFORMER, AM IFT

< VIBRATOR >

X101 1-579-585-11 VIBRATOR, CRYSTAL 7.2MHz************************************************************

* 1-639-678-12 MOTOR (6P)(S)BOARD*******************

< CONNECTOR >

* CN1 1-564-722-11 PIN,CONNECTOR (SMALL TYPE)6P

< MOTOR >

M101 X-2625-877-1 MOTOR ASSY (SPINDLE)M102 X-2625-769-1 MOTOR ASSY (SLED)

< SWITCH >

S1 1-572-085-11 SWITCH,LEAF(LIMIT)

************************************************************

* A-4405-479-A PANEL BOARD, COMPLETE (US,CND,MX)***********************

* A-4405-485-A PANEL BOARD, COMPLETE (E,AUS,SP,MY,TW)***********************

* 4-210-620-01 HOLDER, DISPLAY

MAIN PANELMOTOR (6P)(S)


— 82 —


< CAPACITOR >

C601 1-126-916-11 ELECT 1000uF 20% 6.3VC602 1-161-494-00 CERAMIC 0.022uF 25VC603 1-164-159-11 CERAMIC 0.1uF 50VC604 1-126-933-11 ELECT 100uF 20% 16VC605 1-126-967-11 ELECT 47uF 20% 16V

C606 1-164-159-11 CERAMIC 0.1uF 50VC607 1-126-961-11 ELECT 2.2uF 20% 50VC608 1-126-960-11 ELECT 1uF 20% 50VC609 1-164-159-11 CERAMIC 0.1uF 50VC610 1-126-964-11 ELECT 10uF 20% 50V

C611 1-161-494-00 CERAMIC 0.022uF 25VC612 1-102-510-11 CERAMIC 12PF 5% 50VC613 1-102-510-11 CERAMIC 12PF 5% 50VC614 1-126-960-11 ELECT 1uF 20% 50VC615 1-126-019-11 ELECT 10uF 20% 25V

C616 1-110-671-31 FILM 0.047uFC617 1-162-302-11 CERAMIC 0.0022uF 20% 16VC618 1-126-964-11 ELECT 10uF 20% 50VC619 1-161-494-00 CERAMIC 0.022uF 25VC620 1-161-494-00 CERAMIC 0.022uF 25V

C621 1-126-964-11 ELECT 10uF 20% 50VC622 1-126-964-11 ELECT 10uF 20% 50VC623 1-162-294-31 CERAMIC 0.001uF 10% 50VC633 1-162-600-11 CERAMIC 0.0047uF 30% 16VC634 1-162-600-11 CERAMIC 0.0047uF 30% 16V

C635 1-162-600-11 CERAMIC 0.0047uF 30% 16VC636 1-162-600-11 CERAMIC 0.0047uF 30% 16VC637 1-162-600-11 CERAMIC 0.0047uF 30% 16VC638 1-162-600-11 CERAMIC 0.0047uF 30% 16V

< CONNECTOR >

CN601 1-770-331-11 CONNECTOR, D-SUB (11W1)CN602 1-568-861-11 SOCKET, CONNECTOR 18PCN602 8-719-031-85 DIODE 1N4002L

< DIODE >

D601 8-719-911-19 DIODE 1SS119D602 8-719-031-85 DIODE 1N4002LD603 8-719-911-19 DIODE 1SS119D604 8-719-911-19 DIODE 1SS119D605 8-719-911-19 DIODE 1SS119

D607 8-719-987-63 DIODE 1N4148D608 8-719-911-19 DIODE 1SS119D609 8-719-987-63 DIODE 1N4148D610 8-719-911-19 DIODE 1SS119D611 8-719-911-19 DIODE 1SS119

D612 8-719-991-33 DIODE 1SS133D613 8-719-911-19 DIODE 1SS119D614 8-719-991-33 DIODE 1SS133D615 8-719-991-33 DIODE 1SS133D616 8-719-911-19 DIODE 1SS119

D617 8-719-991-33 DIODE 1SS133D618 8-719-991-33 DIODE 1SS133D619 8-719-991-33 DIODE 1SS133

< FLUORESCENT INDICATOR >

FLD601 1-517-761-11 INDICATOR TUBE, FLUORESCENT

< IC >

IC601 8-759-540-23 IC uPD78020SGF-043-3BAIC602 8-759-275-23 IC BU2092IC603 8-759-473-61 IC BU2114

< COIL >

L601 1-408-096-00 INDUCTOR 470uHL602 1-408-611-31 INDUCTOR 47mHL603 1-408-611-31 INDUCTOR 47mH

< LED >

LED605 8-719-044-69 DIODE SEL1910DTP3LED606 8-719-044-69 DIODE SEL1910DTP3LED607 8-719-921-01 DIODE EBR5534SLED608 8-719-312-70 DIODE SEL1410GLED609 8-719-312-70 DIODE SEL1410G

LED610 8-719-312-70 DIODE SEL1410GLED611 8-719-312-70 DIODE SEL1410G

< TRANSISTOR >

Q601 8-729-194-57 TRANSISTOR 2SC945-PQ602 8-729-194-57 TRANSISTOR 2SC945-PQ603 8-729-194-57 TRANSISTOR 2SC945-PQ604 8-729-119-76 TRANSISTOR 2SA1175-HFEQ605 8-729-194-57 TRANSISTOR 2SC945-P

Q606 8-729-900-63 TRANSISTOR DTA124ESQ607 8-729-900-63 TRANSISTOR DTA124ESQ608 8-729-900-63 TRANSISTOR DTA124ESQ609 8-729-900-63 TRANSISTOR DTA124ESQ610 8-729-900-63 TRANSISTOR DTA124ES

Q611 8-729-900-63 TRANSISTOR DTA124ESQ612 8-729-900-63 TRANSISTOR DTA124ESQ613 8-729-900-63 TRANSISTOR DTA124ES

< RESISTOR >

R601 1-247-871-11 CARBON 47K 5% 1/4WR602 1-249-417-11 CARBON 1K 5% 1/4W FR603 1-247-871-11 CARBON 47K 5% 1/4WR604 1-249-417-11 CARBON 1K 5% 1/4W FR605 1-247-871-11 CARBON 47K 5% 1/4W

R606 1-247-839-11 CARBON 2.2K 5% 1/4WR607 1-247-839-11 CARBON 2.2K 5% 1/4WR608 1-247-839-11 CARBON 2.2K 5% 1/4WR609 1-247-855-11 CARBON 10K 5% 1/4WR610 1-247-713-11 CARBON 1K 5% 1/4W F

R611 1-249-431-11 CARBON 15K 5% 1/4WR612 1-247-871-11 CARBON 47K 5% 1/4WR613 1-249-417-11 CARBON 1K 5% 1/4W FR614 1-249-417-11 CARBON 1K 5% 1/4W FR615 1-247-713-11 CARBON 1K 5% 1/4W F

R616 1-247-713-11 CARBON 1K 5% 1/4W FR617 1-247-713-11 CARBON 1K 5% 1/4W FR618 1-247-713-11 CARBON 1K 5% 1/4W FR619 1-247-855-11 CARBON 10K 5% 1/4WR620 1-247-855-11 CARBON 10K 5% 1/4W

R621 1-247-725-11 CARBON 10K 5% 1/4W FR622 1-247-855-11 CARBON 10K 5% 1/4WR623 1-247-855-11 CARBON 10K 5% 1/4WR624 1-247-855-11 CARBON 10K 5% 1/4WR625 1-247-847-11 CARBON 4.7K 5% 1/4W

PANEL


— 83 —


R626 1-247-847-11 CARBON 4.7K 5% 1/4WR627 1-247-847-11 CARBON 4.7K 5% 1/4WR628 1-247-847-11 CARBON 4.7K 5% 1/4WR629 1-247-847-11 CARBON 4.7K 5% 1/4WR630 1-247-847-11 CARBON 4.7K 5% 1/4W

R631 1-247-847-11 CARBON 4.7K 5% 1/4WR632 1-247-847-11 CARBON 4.7K 5% 1/4WR633 1-247-721-11 CARBON 4.7K 5% 1/4W FR634 1-247-721-11 CARBON 4.7K 5% 1/4W FR635 1-247-721-11 CARBON 4.7K 5% 1/4W F

R636 1-247-871-11 CARBON 47K 5% 1/4WR637 1-247-839-11 CARBON 2.2K 5% 1/4WR638 1-249-409-11 CARBON 220 5% 1/4W FR639 1-247-702-11 CARBON 150 5% 1/4W FR640 1-247-702-11 CARBON 150 5% 1/4W F

R641 1-247-702-11 CARBON 150 5% 1/4W FR642 1-247-702-11 CARBON 150 5% 1/4W FR643 1-247-702-11 CARBON 150 5% 1/4W FR644 1-247-702-11 CARBON 150 5% 1/4W FR645 1-246-451-15 CARBON 120 5% 1/4W

R646 1-246-451-15 CARBON 120 5% 1/4WR647 1-249-407-11 CARBON 150 5% 1/4W FR648 1-249-407-11 CARBON 150 5% 1/4W FR649 1-249-407-11 CARBON 150 5% 1/4W FR650 1-249-407-11 CARBON 150 5% 1/4W F

R651 1-249-407-11 CARBON 150 5% 1/4W FR652 1-249-407-11 CARBON 150 5% 1/4W FR653 1-247-847-11 CARBON 4.7K 5% 1/4WR655 1-247-855-11 CARBON 10K 5% 1/4WR661 1-247-714-11 CARBON 1.2K 5% 1/4W F

R662 1-249-420-11 CARBON 1.8K 5% 1/4W FR663 1-247-718-11 CARBON 2.7K 5% 1/4W FR664 1-247-720-11 CARBON 3.9K 5% 1/4W FR665 1-249-427-11 CARBON 6.8K 5% 1/4W FR666 1-249-431-11 CARBON 15K 5% 1/4W

R667 1-249-436-11 CARBON 39K 5% 1/4WR668 1-249-418-11 CARBON 1.2K 5% 1/4W FR669 1-249-420-11 CARBON 1.8K 5% 1/4W FR670 1-247-718-11 CARBON 2.7K 5% 1/4W FR671 1-249-418-11 CARBON 1.2K 5% 1/4W F

R672 1-249-420-11 CARBON 1.8K 5% 1/4W FR673 1-249-418-11 CARBON 1.2K 5% 1/4W FR674 1-249-420-11 CARBON 1.8K 5% 1/4W FR675 1-247-718-11 CARBON 2.7K 5% 1/4W FR676 1-249-424-11 CARBON 3.9K 5% 1/4W F

R677 1-249-427-11 CARBON 6.8K 5% 1/4W FR678 1-249-431-11 CARBON 15K 5% 1/4WR679 1-249-436-11 CARBON 39K 5% 1/4WR690 1-247-855-11 CARBON 10K 5% 1/4W

< SWITCH >

S601 1-572-647-11 SWITCH, KEY BOARD (TUNER/BAND)S602 1-572-647-11 SWITCH, KEY BOARD (CD)S603 1-572-647-11 SWITCH, KEY BOARD (TAPE B)S604 1-572-647-11 SWITCH, KEY BOARD (TAPE B)S605 1-572-647-11 SWITCH, KEY BOARD (TAPE A)

S606 1-572-647-11 SWITCH, KEY BOARD (TAPE A)S607 1-572-647-11 SWITCH, KEY BOARD (FUNCTION)S608 1-572-647-11 SWITCH, KEY BOARD (EDIT/DIRECTION)S609 1-572-647-11 SWITCH, KEY BOARD (REPEAT/MEMORY)S610 1-572-647-11 SWITCH, KEY BOARD (STEREO/MONO)

S611 1-572-647-11 SWITCH, KEY BOARD (STOP)S612 1-572-647-11 SWITCH, KEY BOARD (POWER)S613 1-572-647-11 SWITCH, KEY BOARD (CLOCK/TIMER SET)S614 1-572-647-11 SWITCH, KEY BOARD (TIMER SELECT)S615 1-572-647-11 SWITCH, KEY BOARD (ENTER/NEXT)

S616 1-572-647-11 SWITCH, KEY BOARD (FILE SELECT)S617 1-572-647-11 SWITCH, KEY BOARD (DBFB)S618 1-572-647-11 SWITCH, KEY BOARD (DISPLAY/MONO)S619 1-572-647-11 SWITCH, KEY BOARD (SURROUND)S620 1-572-647-11 SWITCH, KEY BOARD (REC)

S621 1-572-647-11 SWITCH, KEY BOARD (PAUSE)S622 1-572-647-11 SWITCH, KEY BOARD (CD SYNC)S623 1-572-647-11 SWITCH, KEY BOARD (PLAY MODE)S611A 1-572-647-11 SWITCH, KEY BOARD

< VIBRATOR >

X601 1-760-096-11 VIBRATOR, CRYSTAL************************************************************

* 1-670-442-11 SENSOR BOARD*************

< SENSOR >

RM601 8-749-013-84 IC SPS-447-1************************************************************

* 1-670-797-11 SW (A) BOARD*************

< SWITCH >

S04 1-771-169-11 SWITCH************************************************************

* 1-670-798-11 SW (B) BOARD*************

< SWITCH >

S03 1-771-169-11 SWITCH************************************************************

* 1-670-799-11 SW (C) BOARD*************

< SWITCH >

S02 1-571-300-31 SWITCH, ROTARY************************************************************

* 1-670-800-11 SW (D) BOARD************

< SWITCH >

S01 1-571-300-31 SWITCH, ROTARY************************************************************

PANEL SENSOR SW (A) SW (B) SW (C) SW (D)


— 84 —


* 1-670-441-11 VOLUME BOARD**************

< RESISTOR >

R685 1-249-424-11 CARBON 3.9K 5% 1/4W FR686 1-249-427-11 CARBON 6.8K 5% 1/4W F

< SWITCH >

S629 1-762-875-11 SWITCH, KEYBOARD (TUNING/FF)S630 1-762-875-11 SWITCH, KEYBOARD (TUNING/REW)

< VARIABLE RESISTOR >

VR601 1-475-807-11 ENCODER, ROTARY (VOLUME)VR602 1-475-841-11 ENCODER (MULTI JOG)

************************************************************

MISCELLANEOUS**************

!9 1-551-506-99 CORD, POWER (E,MX)!9 1-559-583-11 CORD, POWER (US,CND)!9 1-696-966-11 CORD, POWER (AUS)!9 1-765-558-11 CORD, POWER (SP,MY,TW)

87 1-773-077-11 WIRE (FLAT TYPE) (18 CORE)

151 1-759-633-11 DECK, MECHANICAL!PT302 1-431-950-11 TRANSFORMER, POWER (US,CND)!PT302 1-431-952-11 TRANSFORMER, POWER (E,AUS,SP,MY,TW)!PT302 1-431-953-11 TRANSFORMER, POWER (MX)************************************************************

ACCESSORIES & PACKING MATERIALS********************************

1-475-827-11 REMOTE COMMANDER (RM-SG7)1-475-828-11 REMOTE COMMANDER (RM-SG7B)1-501-374-11 ANTENNA, LOOP1-501-594-11 ANTENNA (FM)3-862-439-11 MANUAL, INSTRUCTION (ENGLISH) (US,CND)



VOLUME

3-862-439-21 MANUAL, INSTRUCTION (FRENCH) (CND)3-862-439-31 MANUAL, INSTRUCTION (FRENCH/SPANISH)

(E,SP,MY,MX,TW)3-862-439-91 MANUAL, INSTRUCTION (CHINESE)

(SP,MY,TW)4-982-031-01 COVER, BATTERY (RM-SG7)

************************************************************

*************** HARDWARE LIST***************

#2 7-682-546-04 SCREW +B 3X5#3 7-682-547-04 SCREW +B 3X6#4 7-682-548-04 SCREW +B 3X8#5 7-685-131-19 SCREW +P 2.6X4 TYPE2 SLIT#6 7-685-139-29 SCREW, TAPPING, (M2.6X20)

#7 7-685-134-19 SCREW +PTPWH 2.6X8 (TYPE2)#8 7-685-138-19 SCREW +BTP 2.6X16 TYPE2 N-S#9 7-624-118-01 RING, RETAINING E-2.5#10 7-685-903-31 SCREW +PTPWH 3X10 (TYPE2)#11 7-682-549-04 SCREW +B 3X10

#12 7-682-550-04 SCREW +B 3X12#13 7-682-903-11 SCREW +PWH 3X6#14 7-682-904-11 SCREW +PWH 4X8#15 7-685-103-19 SCREW +P 2X5 TYPE2 SLIT#16 7-685-106-19 SCREW +P 2X10 TYPE2 SLIT

#17 7-685-245-19 SCREW +KTP 3X6 TYPE2 NON-SLIT#18 7-621-255-15 SCREW +P 2X3#19 7-685-547-19 SCREW +BTP 3X10 TYPE2 N-S#20 7-685-548-19 SCREW +BTP 3X12 TYPE2 N-S#21 7-685-903-21 SCREW +PTPWH 3X8 (TYPE2)

Sony CorporationHome A&V Products Company9-922-804-11

98C167043-1Printed in Singapore ©1998.3

Published by General Engineering Dept.(Shibaura)

HCD-GRX3/RX55/R300

––––––––––– ––––––––––––––––––––––1-126-925-11 ELECT 470uF 20% 10V1-162-201-31 CERAMIC 12PF 5% 50V––––––––––– ––––––––––––––––––––––1-162-294-31 CERAMIC 0.001uF 10% 50V––––––––––– ––––––––––––––––––––––1-136-154-00 FILM 0.012uF 5% 50V1-162-306-11 CERAMIC 0.01uF 20% 16V1-126-927-11 ELECT 2200uF 20% 10V

1-162-294-31 CERAMIC 0.001uF 10% 50V1-102-942-00 CERAMIC 5PF 0.5PF 50V1-102-942-00 CERAMIC 5PF 0.5PF 50V1-126-934-11 ELECT 220uF 20% 10V1-162-289-31 CERAMIC 390PF 10% 50V1-162-289-31 CERAMIC 390PF 10% 50V1-162-288-31 CERAMIC 330PF 10% 50V1-162-288-31 CERAMIC 330PF 10% 50V1-162-288-31 CERAMIC 330PF 10% 50V1-162-288-31 CERAMIC 330PF 10% 50V––––––––––– ––––––––––––––––––––––1-162-294-31 CERAMIC 0.001uF 10% 50V1-162-294-31 CERAMIC 0.001uF 10% 50V1-162-294-31 CERAMIC 0.001uF 10% 50V1-162-294-31 CERAMIC 0.001uF 10% 50V1-164-159-11 CERAMIC 0.1uF 50V

8-719-991-33 DIODE ISS133T8-719-921-41 DIODE MTZJ-5.18-719-991-33 DIODE ISS133T

8-759-234-75 IC TC74HC4094AP8-759-579-80 IC BA5936S

1-249-393-11 CARBON 10 5% 1/4W1-249-438-11 CARBON 56K 5% 1/4W1-249-440-11 CARBON 82K 5% 1/4W1-249-431-11 CARBON 15K 5% 1/4W1-249-385-11 CARBON 2.2 5% 1/4W1-274-871-11 CARBON 47K 5% 1/4W1-249-411-11 CARBON 330 5% 1/4W1-247-867-11 CARBON 33K 5% 1/4W

1-249-432-11 CARBON 18K 5% 1/4W1-249-417-11 CARBON 1K 5% 1/4W1-247-867-11 CARBON 33K 5% 1/4W1-247-867-11 CARBON 33K 5% 1/4W1-247-867-11 CARBON 33K 5% 1/4W1-247-867-11 CARBON 33K 5% 1/4W1-249-409-11 CARBON 220 5% 1/4W1-249-432-11 CARBON 18K 5% 1/4W1-247-855-11 CARBON 10K 5% 1/4W1-249-432-11 CARBON 18K 5% 1/4W1-247-855-11 CARBON 10K 5% 1/4W1-247-867-11 CARBON 33K 5% 1/4W1-247-863-11 CARBON 22K 5% 1/4W

1-670-801-11 MOTOR BOARD************<CAPACITOR>

1-126-963-11 ELECT 4.7uF 20% 50V1-164-159-11 CERAMIC 0.1uF 50V

<CONNECTOR>1-568-824-11 SOCKET, CONNECTOR 5P

HCD-GRX3/RX55/R300US Model

Canadian ModelHCD-RX55

E ModelHCD-GRX3/R300

Australian ModelHCD-GRX3

SERVICE MANUAL

CORRECTION-1Correct your service manual as shown below.

• PARTS LISTPage CORRECT

Ref. No. Part No. Description Remarks Part No. Description RemarksC02 1-126-963-11 ELECT 4.7uF 20% 50VC04B ––––––––––– ––––––––––––––––––––––C07A 1-162-199-31 CERAMIC 10PF 5% 50VC08 1-161-494-00 CERAMIC 0.022uF 25VC23A ––––––––––– ––––––––––––––––––––––C26 1-161-494-00 CERAMIC 0.022uF 25VC27 1-162-306-11 CERAMIC 0.01uF 20% 16VC28 1-164-159-11 CERAMIC 0.1uF 50VC29A ––––––––––– ––––––––––––––––––––––

C30B ––––––––––– ––––––––––––––––––––––C38 1-102-958-00 CERAMIC 20PF 5% 50VC39 1-102-958-00 CERAMIC 20PF 5% 50VC46 1-126-933-11 ELECT 100uF 20% 10VC51 1-162-288-31 CERAMIC 330PF 10% 50VC52 1-162-288-31 CERAMIC 330PF 10% 50VC53 1-162-284-31 CERAMIC 150PF 10% 50VC54 1-162-284-31 CERAMIC 150PF 10% 50VC55 1-162-284-31 CERAMIC 150PF 10% 50VC56 1-162-284-31 CERAMIC 150PF 10% 50VC84 1-162-282-31 CERAMIC 100PF 10% 50VC85 1-162-292-31 CERAMIC 680PF 10% 50VC86 1-162-282-31 CERAMIC 100PF 10% 50VC87 1-162-282-31 CERAMIC 100PF 10% 50VC88 1-162-282-31 CERAMIC 100PF 10% 50VC90 1-161-494-00 CERAMIC 0.022uF 25V

D01 8-719-911-19 DIODE ISS119-25D04 8-719-921-41 DIODE ISS113TD04A 8-719-991-33 DIODE ISS176

IC02 8-759-388-27 IC TC9173PIC03 8-759-429-31 IC BA5941FP

R03 1-249-397-11 CARBON 22 5% 1/4WR14 1-247-879-11 CARBON 100K 5% 1/4WR15 1-247-881-00 CARBON 120K 5% 1/4WR26 1-247-855-11 CARBON 10K 5% 1/4WR27 1-249-430-11 CARBON 12K 5% 1/4WR28 1-247-855-11 CARBON 10K 5% 1/4WR36 1-247-847-11 CARBON 4.7K 5% 1/4WR50 1-247-847-11 CARBON 4.7K 5% 1/4W

R53 1-249-411-11 CARBON 330 5% 1/4WR58 1-249-442-11 CARBON 510 5% 1/4WR65 1-247-864-11 CARBON 24K 5% 1/4WR66 1-247-864-11 CARBON 24K 5% 1/4WR67 1-247-864-11 CARBON 24K 5% 1/4WR68 1-247-864-11 CARBON 24K 5% 1/4WR79 1-249-405-11 CARBON 100 5% 1/4WR89 1-247-839-11 CARBON 2.2K 5% 1/4WR90 1-247-839-11 CARBON 2.2K 5% 1/4WR91 1-247-839-11 CARBON 2.2K 5% 1/4WR92 1-247-839-11 CARBON 2.2K 5% 1/4WR93 1-249-420-11 CARBON 1.8K 5% 1/4WR94 1-249-420-11 CARBON 1.8K 5% 1/4W

* ––––––––––– ––––––––––––––––––––––

C01 ––––––––––– ––––––––––––––––––––––C82 ––––––––––– ––––––––––––––––––––––

* CN06 ––––––––––– ––––––––––––––––––––––

INCORRECT

74

75

76

81

— 2 —Sony Corporation

Home A&V Products Company9-922-804-91

98L1643-1Printed in Japan ©1998.12

Published by Quality Assurance Dept.(Shibaura)

Subject : Correction of electrical parts.

(ECN-TA803970)(ECN-TA803983)

: Indicates corrected portion

— 3 — — 4 —

(ADDED)

(DELETED)

(ADDED)

(DELETED)

(ADDED)

(DELETED)

(DELETED)

HCD-GRX3/RX55/R300 - Forum Futura Sciences

Documents

Transcript of HCD-GRX3/RX55/R300 - Forum Futura Sciences