HCD-AZ2D/AZ5D - SERVICE MANUAL

SERVICE MANUAL

DVD DECK RECEIVER

E ModelAustralian Model

HCD-AZ2D/AZ5DVer. 1.0 2005.06

SPECIFICATIONS

9-879-718-012005F0579-1© 2005.06

Sony CorporationAudio GroupPublished by Sony Engineering Corporation

• HCD-AZ2D is the amplifier, disc player, tapedeck and tuner section in DHC-AZ2D.

• HCD-AZ5D is the amplifier, disc player tapedeck and tuner section in DHC-AZ5D.

Amplifier sectionHCD-AZ5DThe following measured at AC 120, 127, 220, 240 V, 50/60 HzDIN power output (rated): 75 + 75 watts

(4 ohms at 1 kHz, DIN)Continuous RMS power output (reference)Front speaker: 100 + 100 watts

(4 ohms at 1 kHz, 10% THD)

Center speaker: 50 watts (8 ohms at 1 kHz, 10% THD)

Surround speaker: 50 + 50 watts(8 ohms at 1 kHz, 10% THD)

Subwoofer: 180 watts (2 ohms at 100 Hz, 10% THD)

HCD-AZ2DThe following measured at AC 120, 127, 220, 240 V, 50/60 HzDIN power output (rated): 75 + 75 watts

(4 ohms at 1 kHz, DIN)Continuous RMS power output (reference)

100 + 100 watts(4 ohms at 1 kHz, 10% THD)

InputsVIDEO/SAT IN (audio) (phono jacks):

voltage 250/450 mV, impedance 47 kilohms

MIC 1/MIC 2 (phone jacks):sensitivity 1 mV, impedance 10 kilohms

OutputsVIDEO/SAT OUT (audio) (phono jacks):

voltage 250 mV, impedance 1 kilohm

VIDEO OUT (phono jack):max. output level 1 Vp-p, unbalanced, Sync negative, load impedance 75 ohms

S VIDEO OUT (4-pin/mini-DIN jack):Y: 1 Vp-p, unbalanced, Sync negative,C: 0.286 Vp-p, load impedance 75 ohms

COMPONENT VIDEO OUT:Y: 1 Vp-p, 75 ohmsPB, PR: 0.7 Vp-p, 75 ohms

DVD DIGITAL OUT (DHC-AZ2D only)(Square optical connector jack, rear panel)Wavelength 660 nmPHONES (stereo mini jack):

accepts headphones of 8 ohms or more

FRONT SPEAKER: Use only the supplied speaker SS-AZ7D.

SURROUND SPEAKER (HCD-AZ5D only):Use only the supplied speaker SS-RS7D.

CENTER SPEAKER (HCD-AZ5D only):Use only the supplied speaker SS-CT7D.

SUBWOOFER (HCD-AZ5D only):Use only the supplied speaker SS-WG7D.

Disc player section System Compact disc and digital

audio and video systemLaser Semiconductor laser

(DVD: λ =650 nm, CD: λ =790 nm)Emission duration: continuous

Frequency response DVD (PCM 48 kHz):2 Hz − 22 kHz (±1 dB) CD: 2 Hz − 20 kHz (±1 dB)

Video color system formatLatin American model: NTSCOther models: NTSC, PAL

DVDModel Name Using Similar Mechanism NEW

SectionDVD Mechanism Type CDM86-DVBU101

Optical Pick-up Block Name KHM-310CAB

Tape deck-A Model Name Using Similar Mechanism NEW

Section Tape Transport Mechanism Type CMAL5Z230

Tape deck-B Model Name Using Similar Mechanism NEW

Section Tape Transport Mechanism Type CMAL1Z254A

This system incorporates Dolby1) Digital, Dolby Pro Logic (II) adaptive matrix surround decoder, and DTS2) Digital Surround System.1) Manufactured under license from Dolby

Laboratories.“Dolby”, “Pro Logic”, and the double-D symbol are trademarks of Dolby Laboratories.

2) Manufactured under license from Digital Theater Systems, Inc. “DTS” and “DTS Digital Surround” are registered trademarks of Digital Theater Systems, Inc.

– Continued on next page –

Photo: HCD-AZ5D

2

HCD-AZ2D/AZ5D

Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be

damaged by heat.

Flexible Circuit Board Repairing• Keep the temperature of the soldering iron around 270 ˚C

during repairing.• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering

or unsoldering.

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardous radiationexposure.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

This appliance is classified as a CLASS 1 LASER product. This marking is located on the rear exterior.

When the self-diagnosis function is activated to prevent the system from malfunctioning, a 5-character service number (e.g., C 13 50) with a combination of a letter and 4 digits appears on the screen and the front panel display. In this case, check the following table.

Self-diagnosis Function (When letters/numbers appear in the display)

First 3 characters of the service number

Cause and/or corrective action

C 13 The disc is dirty.

,Clean the disc with a soft cloth .

C 31 The disc is not inserted correctly.

,Restart the system, then reinsert the disc correctly.

E XX

(xx is a number)

To prevent a malfunction, the system has performed the self-diagnosis function.

,Contact your nearest Sony dealer or local authorized Sony service facility and give the 5-character service number.

Example: E 61 10

SELF DIAGNOSIS FUNCTION

Tuner sectionFM stereo, FM/AM superheterodyne tunerFM tuner sectionTuning range 87.5 − 108.0 MHz

(50-kHz step)Antenna FM lead antennaAntenna terminals 75 ohms unbalancedIntermediate frequency 10.7 MHz

AM tuner sectionTuning range Latin American model: 530 − 1,710 kHz

(with the interval set at 10 kHz)531 − 1,710 kHz(with the interval set at 9 kHz)

531 − 1,602 kHz (with the interval set at 9 kHz)

Other models: 530 − 1,710 kHz (with the interval set at 10 kHz)531 − 1,602 kHz (with the interval set at 9 kHz)

Antenna AM loop antennaAntenna terminals External antenna terminalIntermediate frequency 450 kHz

GeneralPower requirementsAustralian model: 230 − 240 V AC, 50/60 Hz Saudi Arabian model: 120 − 127 V,

220 − 240 V AC, 50/60 HzAdjustable with voltage selector

Indian and Russian models: 220 − 240 V AC, 50/60 Hz

Thai model: 220 V AC, 50/60 HzKorean model: 220 V AC, 60 HzOther models: 120 V, 220 − 240V AC,

50/60 HzAdjustable with voltage selector

Power consumptionHCD-AZ5D 170 wattsHCD-AZ2D 100 watts

Dimensions (w/h/d)HCD-AZ5D Approx. 190 × 381 ×

317 mmHCD-AZ2D Approx. 190 × 381 ×

317 mm

MassHCD-AZ5D Approx. 6.7 kgHCD-AZ2D

Design and specifications are subject to changewithout notice.

Approx. 6.2 kg

Tape deck sectionRecording system 4-track 2-channel stereoFrequency response 50 − 13,000 Hz (±3 dB),

using Sony TYPE I cassette

Saudi Arabian and Russian models:

3

HCD-AZ2D/AZ5D

You can play back the following discs on this system. Other discs cannot be played back.

List of playable discs

The “DVD VIDEO” logo and “DVD-RW” logo are trademarks.

Playable discs

Format of discs Disc logo

DVD VIDEO

DVD-RW

VIDEO CD

Audio CD

CD-R/CD-RW

Region code of DVDs you can play on this system

Your system has a region code printed on the back of the unit and will only play DVDs labeled with identical region code.

DVDs labeled will also be played on this system.If you try to play any other DVD, the message “Playback prohibited by area limitations.” will appear on the TV screen. Depending on the DVD, no region code indication may be labeled even though playing the DVD is prohibited by area restrictions.

Discs that this system cannot play

• CD-ROMs/CD-Rs/CD-RWs other than those recorded in the following formats:− music CD format− video CD format− MP3 (MPEG1 Audio Layer-3)/JPEG/

DivX1) format that conforms to ISO96602) Level 1/Level 2 or Joliet

• CD-ROMs recorded in PHOTO CD format• Data part of CD-Extras• Super Audio CDs DVD-ROMs/DVD-Rs/DVD-RWs/DVD+Rs/

DVD+RWs other than those recorded in DivX format conforming to Universal Disk Format (UDF).1)

• DVD-ROMs/DVD-Rs/DVD-RWs/DVD+Rs/DVD+RWs recorded in Multi Session

• DVD-RAMs• DVD Audio discs• A DVD with a different region code.• An 8 cm disc with an adapter• Discs with non-standard shapes (e.g., heart,

square, star) cannot be played on this unit. Attempting to do so may damage the unit. Do not use such discs.

• A disc with paper or stickers on it.• A disc that has the adhesive, cellophane tape,

or a sticker still left on it.1)Except for DHC-AZ5D Latin American model and

DHC-AZ2D2)A logical format of files and folders on a CD-ROMs,

defined by ISO (International Organization for standardization).

Notes about CD-R/CD-RW/DVD-R/DVD-RW/DVD+R/DVD+RW

• In some cases, CD-Rs, CD-RWs, DVD-Rs, DVD-RWs, DVD+R or DVD+RW cannot be played on this system depending upon the recording quality or physical condition of the disc, or the characteristics of the recording device. Furthermore, the disc will not play if it has not been correctly finalized. For more information, see the operating instructions for the recording device.

• A disc recorded in packet write format cannot be played.

Note on playback operations of DVDs and VIDEO CDs

Some playback operations of DVDs and VIDEO CDs may be intentionally set by software producers. Since this system plays DVDs and VIDEO CDs according to the disc contents the software producers designed, some playback features may not be available. Also, refer to the instructions supplied with the DVDs or VIDEO CDs.

ALL

MODEL NO. HCD-AZXX

DVD DECK RECEIVERAC: 00V 00Hz 00W

SERIAL NO:

X Region codeMusic discs encoded with copyright protection technologies

This product is designed to playback discs that conform to the Compact Disc (CD) standard. Recently, various music discs encoded with copyright protection technologies are marketed by some record companies. Please be aware that among those discs, there are some that do not conform to the CD standard and may not be playable by this product.

Note on DualDiscs

A DualDisc is a two sided disc product which mates DVD recorded material on one side with digital audio material on the other side.However, since the audio material side does not conform to the Compact Disc (CD) standard, playback on this product is not guaranteed.

Cautions when playing a disc that is recorded in Multi Session

• This system can play Multi Session CDs when an MP3 audio track is contained in the first session. Any subsequent MP3 audio tracks recorded in later sessions can also be played back.

• This system can play Multi Session CDs when a JPEG image file is contained in the first session. Any subsequent JPEG image files recorded in later sessions can also be played back.

• If audio tracks and images in music CD format or video CD format are recorded in the first session, only the first session will be played back.

• CD-R and CD-RW discs recorded in multi-session that have not ended by “closing the session” are not supported.

• With CD-ROMs/CD-Rs/CD-RWs that contain DivX video files in addition to MP3 audio tracks or JPEG image files, the system plays only the DivX video files.*

* Except for DHC-AZ5D Latin American model and DHC-AZ2D

Copyrights

This product incorporates copyright protection technology that is protected by U.S. patents and other intellectual property rights. Use of this copyright protection technology must be authorized by Macrovision, and is intended for home and other limited viewing uses only unless otherwise authorized by Macrovision. Reverse engineering or disassembly is prohibited.

4

HCD-AZ2D/AZ5D

TABLE OF CONTENTS

1. SERVICING NOTES ............................................... 5

2. GENERAL ................................................................... 9

3. DISASSEMBLY3-1. Disassembly Flow ........................................................... 113-2. Side Panel (A)/(B) ........................................................... 123-3. Front Panel Section ......................................................... 123-4. Tape Mech Deck (CMAL1Z254A) (Deck-B) ................. 133-5. Top Panel (TC) Section ................................................... 133-6. Tape Mech Deck (CMAL5Z230) (Deck-A) .................... 143-7. DC Fan (M901) ............................................................... 143-8. DVD Mechanism Deck (CDM86-DVBU101) ................ 153-9. Optical Pick-up Block (KHM-310CAB) ......................... 163-10. Motor (Pulley) Assy (Loading) (M001) .......................... 163-11. Holder (BU) Assy ............................................................ 173-12. Lever (BU Lock) ............................................................. 173-13. Close Lever ...................................................................... 183-14. Lever (DIR), Gear (IDL-B) ............................................. 183-15. Chassis (Top) ................................................................... 193-16. Lever (Loading-L/R) ....................................................... 203-17. Lever (Disc Sensor)/(Disc Stop) ..................................... 213-18. Gear (IDL-C) ................................................................... 21

4. TEST MODE .............................................................. 22

5. MECHANICAL ADJUSTMENTS ....................... 25

6. ELECTRICAL ADJUSTMENTS ......................... 25

7. DIAGRAMS7-1. Block Diagram – RF Servo/Video Section – ................... 277-2. Block Diagram – Tuner/Tape Section – .......................... 287-3. Block Diagram – Audio Section – .................................. 297-4. Block Diagram – AMP Section – .................................... 307-5. Block Diagram – Panel/Power Supply Section – ............ 317-6. Printed Wiring Board – DMB10 Board (Side A) – ......... 337-7. Printed Wiring Board – DMB10 Board (Side B) – ...... 347-8. Schematic Diagram – DMB10 Board (1/4) – ................ 357-9. Schematic Diagram – DMB10 Board (2/4) – ................ 367-10. Schematic Diagram – DMB10 Board (3/4) – ................ 377-11. Schematic Diagram – DMB10 Board (4/4) – ................ 38

7-12. Printed Wiring Board – MS-214 Board – ...................... 397-13. Schematic Diagram – MS-214 Board – ........................ 397-14. Printed Wiring Board – MAIN Board – ........................ 407-15. Schematic Diagram – Main Board (1/4) – .................... 417-16. Schematic Diagram – Main Board (2/4) – .................... 427-17. Schematic Diagram – Main Board (3/4) – .................... 437-18. Schematic Diagram – Main Board (4/4) – .................... 447-19. Printed Wiring Board

– S-MASTER Board (Component Side) – ...................... 457-20. Printed Wiring Board

– S-MASTER Board (Conductor Side) – ........................ 467-21. Schematic Diagram – S-MASTER Board (1/4) – ......... 477-22. Schematic Diagram – S-MASTER Board (2/4) – ......... 487-23. Schematic Diagram – S-MASTER Board (3/4) – ......... 497-24. Schematic Diagram – S-MASTER Board (4/4) – ......... 507-25. Printed Wiring Board – MIC Board – .......................... 517-26. Schematic Diagram – MIC Board – ............................. 527-27. Printed Wiring Boards – Output Section – ................... 537-28. Schematic Diagram – Output Section – ......................... 547-29. Printed Wiring Boards – Display Section – .................. 557-30. Schematic Diagram – Display Section – ........................ 567-31. Printed Wiring Boards – Key Section – ........................ 577-32. Schematic Diagram – Key Section – .............................. 58

8. EXPLODED VIEWS8-1. Side Panel Section .......................................................... 758-2. Front Panel Section ........................................................ 768-3. Top Panel (TC) Section .................................................. 778-4. Main Board Section ........................................................ 788-5. DMB10 Board Section .................................................. 798-6. Chassis Section ............................................................... 808-7. DVD Mechanism Deck Section-1

(CDM86-DVBU101) ....................................................... 818-8. DVD Mechanism Deck Section-2



(CDM86-DVBU101) ....................................................... 84

9. ELECTRICAL PARTS LIST ................................ 85

5

HCD-AZ2D/AZ5D

The laser diode in the optical pick-up block may suffer electrostaticbreak-down because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission,observe from more than 30 cm away from the objective lens.

UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the lead-free mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed with

the lead free mark due to their particular size)

: LEAD FREE MARKUnleaded solder has the following characteristics.

• Unleaded solder melts at a temperature about 40 ˚C higherthan ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350 ˚C.Caution: The printed pattern (copper foil) may peel away if

the heated tip is applied for too long, so be careful!• Strong viscosity

Unleaded solder is more viscou-s (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

RELEASING THE DISC SLOT LOCKThe disc slot lock function for the antitheft of an demonstrationdisc in the store is equipped.

Releasing Procedure:1. Press `/1 button to turn the power on.2. Touch the [DVD] sensor to select the “DVD”.3. Touch the x sensor and press the Z button simultaneously

and hold down until “UNLOCKED” displayed on thefluorescent indicator tube (around 5 seconds).

Note: When “LOCKED” is displayed, the slot lock is not released by turningpower on/off with the `/1 button.

NOTE OF REPLACEMENT THE DMB10 BOARDNew part of EEPROM (IC103) on the DMB10 board can not beused. Therefore, if the mounted DMB10 board is replaced, exchangenew EEPROM with that used before the replacement.

NOTES ON HANDLING THE OPTICAL PICK-UPBLOCK OR BASE UNIT

SECTION 1SERVICING NOTES

MODEL IDENTIFICATION– Back Panel –

• AbbreviationAUS : Australian modelE2 : 120V AC area in E modelE3 : 240V AC area in E modelE12 : 220-240V AC area in E modelE13 : 220-230V AC area in E model (Russian model)E15 : Iranian modelEA : Saudi Arabia modelKR : Korean modelMY : Malaysia modelPH : Philippines modelSP : Singapore modelTH : Thai model

PART No.

Model PART No.

HCD-AZ2D: SP, MY 2-349-677-0[]

HCD-AZ2D: E2 2-349-677-1[]

HCD-AZ2D: E12, E13 2-349-677-2[]

HCD-AZ2D: AUS 2-349-677-3[]

HCD-AZ2D: EA 2-349-677-4[]

HCD-AZ2D: KR 2-349-677-5[]

HCD-AZ2D: PH 2-349-677-6[]

HCD-AZ2D: E3, E15 2-349-677-7[]

HCD-AZ5D: SP, MY 2-548-561-0[]

HCD-AZ5D: E2 2-548-561-1[]

HCD-AZ5D: E12, E13 2-548-561-2[]

HCD-AZ5D: AUS 2-548-561-3[]

HCD-AZ5D: EA 2-548-561-4[]

HCD-AZ5D: TH 2-548-561-5[]

HCD-AZ5D: E3, E15 2-548-561-6[]

6

HCD-AZ2D/AZ5D

TAPE MECH DECK (CMAL5Z230) (DECK-A) SERVICE POSITION

TAPE MECH DECK (CMAL1Z254A) (DECK-B) SERVICE POSITION

tape mech deck (CMAL5Z230) (deck-A)

top panel (TC) section

tape mech deck (CMAL1Z254A) (deck-B)

7

HCD-AZ2D/AZ5D

DVD MECHANISM DECK (CDM86-DVBU101) SERVICE POSITION• In checking the DVD mechanism deck (CDM86-DVBU101), prepare extension jig (Part No. J-2501-241-A: 1.00mm pitch, 7 cores,

length 300mm).

DMB10 board(CN202)

DVD mechanism deck(CDM86-DVBU101)

MS-214 board(CN001)

Connect extension jig (J-2501-241-A) to theMS-214 board (CN001) and DVB10 board (CN202).

DMB10 BOARD SERVICE POSITION• In checking the DMB10 board, prepare two extension jigs (Part No. J-2501-102-A: 1.00mm pitch, 13 cores, length 300mm and Part No.

J-2501-244-A: 1.00mm pitch, 21 cores, length 300mm).

DMB10 board(CN106)

DMB10 board(CN302)

MAIN board(CN203)

MAIN board(CN201)

Connect extension jig (J-2501-102-A) to theMAIN board (CN203) and DMB10 board (CN106).

Connect extension jig (J-2501-244-A) to theMAIN board (CN201) and DMB10 board (CN302).

8

HCD-AZ2D/AZ5D

S-MASTER BOARD SERVICE POSITION• In checking the S-MASTER board, prepare extension jig (Part No. J-2501-082-A: 1.25mm pitch, 9 cores, length 300mm).

MAIN board(CN102)

S-MASTER board(CN502)

Connect extension jig (J-2501-082-A) to theS-MASTER board (CN502) and MAIN board (CN102).

9

HCD-AZ2D/AZ5DSECTION 2GENERAL

This section is extracted frominstruction manual.

Main unit

CD SYNC qkDeck A 4Deck B 0DIMMER wfDIRECTION qlDisc slot 7DISPLAY wgDisplay window 3DSGX wsDVD 2ECHO LEVEL qsEQ SELECT w;

MIC 1/2 jack qfMIC LEVEL qdPC 2PHONES jack qg PRESET +/− qhPROGRESSIVE wdRemote sensor 8SOUND FIELD waTAPE A/B 2TUNER/BAND 2VIDEO/SAT 2VOLUME +/− control qa

?/1 (power) 1Z PUSH OPEN/CLOSE (deck A)

(eject) 5Z (eject) 6Z PUSH OPEN/CLOSE (deck B)

(eject) 9nN (play) qhX (pause) qhx (stop) qh> (go forward) qh. (go back) qhz START qj

ALPHABETICAL ORDER

A – N M – Z

BUTTON DESCRIPTIONS

?/1

12

7

8

0qa

qs

qd

653 4

qgqf

qh

qj

qkqlw;

wawswdwfwg

9

LOCATION OF CONTROLS

10

HCD-AZ2D/AZ5D

Remote control

ALBUM +/− wfANGLE 5AUDIO 4CLEAR es

DISC SKIP1) w;DISPLAY qjENTER qsFM MODE wsFUNCTION +/− 2KARAOKE MODE qgKARAOKE PON qhMENU 6Number buttons2) qfPICTURE NAVI 3PRESET + whPRESET − e;

REPEAT wsSLEEP qkSOUND FIELD waSUBTITLE wdTHEATRE SYNC qlTIMER MENU egTIME/TEXT efTOP MENU qdTUNING + 9TUNING − qaTV wkTV CH + whTV CH − e;TV/VIDEO qkTV VOL +/−2) 7VOLUME +/−2) 7

?/1 (power) 1TV ?/1 1

REPLAY/ADVANCE 8

c STEP/STEP C 8SLOW y 9M (fast forward) 9X (pause) q;

SLOW qam (rewind) qaM/m/</, qs

DISPLAY wg> (go forward) whx (stop) wj. (go back) e;H (play)2) wlO RETURN ea-/-- esKEY CONTROL #/2 ed1) The DISC SKIP button is not

available for this model.2) The H, number 5 and

VOLUME + (TV VOL +) buttons have tactile dots. Use the tactile dots as references when operating the system.

ALPHABETICAL ORDER

A – Q R – Z

BUTTON DESCRIPTIONS

Use buttons on the remote for the operation.

1 Press ?/1 to turn on the system.

2 Press TIMER MENU.

3 Press M or m repeatedly to set the hour.

4 Press ENTER.

5 Press M or m repeatedly to set the minute.

6 Press ENTER.

The clock starts working.

To adjust the clock

1 Press TIMER MENU.

2 Press M or m to select “CLOCK SET?”, then press ENTER.

3 Do the same procedures as step 3 to 6 above.

Notes• The clock settings are canceled when you disconnect

the power cord or if a power failure occurs.

• You cannot set the clock in Power Saving Mode.

Setting the clock

11

HCD-AZ2D/AZ5DSECTION 3

DISASSEMBLY

• This set can be disassembled in the order shown below.

3-1. DISASSEMBLY FLOW

3-2. SIDE PANEL (A)/(B)(Page 12)

3-3. FRONT PANEL SECTION(Page 12)

3-4. TAPE MECH DECK(CMAL1Z254A) (DECK-B)(Page 13)

3-5. TOP PANEL (TC) SECTION(Page 13)

3-6. TAPE MECH DECK(CMAL5Z230) (DECK-A)(Page 14)

3-7. DC FAN (M901)(Page 14)

3-8. DVD MECHANISM DECK(CDM86-DVBU101)(Page 15)

3-9. OPTICAL PICK-UP BLOCK(KHM-310CAB)(Page 16)

3-10. MOTOR (PULLEY) ASSY(LOADING) (M001)(Page 16)

3-11. HOLDER (BU) ASSY(Page 17)

3-12. LEVER (BU LOCK)(Page 17)

3-13. CLOSE LEVER(Page 18)

3-14. LEVER (DIR),GEAR (IDL-B)(Page 18)

3-15. CHASSIS (TOP)(Page 19)

3-16. LEVER (LOADING-L/R)(Page 20)

3-17. LEVER (DISC SENSOR)/(DISC STOP)(Page 21)

3-18. GEAR (IDL-C)(Page 21)

SET

12

HCD-AZ2D/AZ5D

Note: Follow the disassembly procedure in the numerical order given.

3-2. SIDE PANEL (A)/(B)

2 three screws(BVTP 3 × 8)


3

4

7

8

1 three flat head screws

6 three flat head screws

5 side panel (A)

9 side panel (B)

3-3. FRONT PANEL SECTION

1 two screws(BVTP 3 × 8)

3 two claws

41 two screws

(BVTP 3 × 8)2 three ground wires

1 screw(BVTP 3 × 8)

8 wire (flat type) (8 core)(CN304)

9 connector(CN302)

q; front panel section

9 connector(CN1050)




13

HCD-AZ2D/AZ5D

3-4. TAPE MECH DECK (CMAL1Z254A) (DECK-B)

3-5. TOP PANEL (TC) SECTION

1 two screws(BVTP 2.6)


4 ground wire

5


6 wire (flat type) (8 core)

7 tape mech deck (CMAL1Z254A) (deck-B)

2 cover (TCM B)




3 ground wire

4 top panel (TC) section

1 connector(CN301)

14

HCD-AZ2D/AZ5D

3-6. TAPE MECH DECK (CMAL5Z230) (DECK-A)

3-7. DC FAN (M901)

2 cover (TCM A)

6 tape mech deck (CMAL5Z230) (deck-A)

5 ground wire


1 three screws(BVTP 2.6)



4 screw(BVTT 3 × 6)

5 screw(BVTP 3 × 8) (AZ2D)



9 DC fan (M901)

q; back panel

7 connector(CN954)

6

5 two screws(BVTP 3 × 8) (AZ5D)



5 seven screws(BVTP 3 × 8)


3 tuner unit (TM-10KR) (AZ2D: Korean model)tuner unit (TM-10E) (except AZ2D: Korean model)

15

HCD-AZ2D/AZ5D

3-8. DVD MECHANISM DECK (CDM86-DVBU101)


2 two claws

35 three screws

(BVTP 3 × 8)


NOTE WHEN REMOVING DVD MECHANISM DECK (CDM86-DVBU101)Some Screws on the CDM86-DVBU101 are hidden by the Front Panel,and accordingly remove four Screws (BVTP3x8) on the Front Panel andshift the Front Panel toward the front, and then remove the Screws on the CDM86-DVBU101.

CAUTION


6

q; wire (flat type) (24 core)

8 Lift up the FFC holder.

7 two claws

9 Be sure to execute a solder bridge as a measure againststatic electricity when removing the OP block (DVBU101). (Otherwise, the OP block will be destroyed.)

qa connector

qs DVD mechanism deck(CDM86-DVBU101)

16

HCD-AZ2D/AZ5D

3-9. OPTICAL PICK-UP BLOCK (KHM-310CAB)

1 two insulator screws

2 two insulators2 two insulators

3 optical pick-up block(KHM-310CAB)

1 two insulator screws

3-10. MOTOR (PULLEY) ASSY (LOADING) (M001)

3 Remove two solders.

2 two screws(B 2.6 × 8)

5 MS-214 board

4 motor (pully) assy (loading)(M001)

1 belt (MOT)

17

HCD-AZ2D/AZ5D

3-11. HOLDER (BU) ASSY

1 screw(B 2.6 × 8)

2 lever (CL UP2)

6 holder (BU) assy

5 floating screw(PTPWH M2.6)

5 floating screw(PTPWH M2.6)

4 LHL support

3 two screws(B 2 × 6)

3-12. LEVER (BU LOCK)

3 three hooks4 lever (BU lock)

2 gear (BU lock)

1 gear (cap)

18

HCD-AZ2D/AZ5D

3-13. CLOSE LEVER

1 washer (3-1-0.4)

2 SPR-E lever close

4 shaft disc stop

5 close lever

3 claw

3-14. LEVER (DIR), GEAR (IDL-B)

4 pulley (gear)

3 nylon washer 1.7

2 claw

washer

0 Lever (DIR)

6 gear (IDL-A)

qa gear (IDL-B)1 tension coil spring (DIR)

9 stoper

7 Loosen the screw.

8 Hold the release lever and change the direction.

5 gear (cap)

19

HCD-AZ2D/AZ5D

3-15. CHASSIS (TOP)

1 screw(B 2.6 × 8)

4 three screws(B 2.6 × 8)

3 two screws(B 2 × 10)

5 chassis (top)

2 lever (CL UP2)

20

HCD-AZ2D/AZ5D

3-16. LEVER (LOADING-L/R)

lever (loading-R)

Align the horizontal position.

lever (loading-L)

Install the both levers so that they move symmetrically.

2 two hooks

4 two hooks

BOTTOM VIEW

3 lever (loading-L)

5 lever (loading-R)

SPT-T (loading-R) SPR-T (loading-L)

11

PRECAUTION DURING LEVER (LOADING R / L) INSTALLATION

21

HCD-AZ2D/AZ5D

3-18. GEAR (IDL-C)

3-17. LEVER (DISC SENSOR)/(DISC STOP)

chassis (top)

hole

Install the lever (disc stop) so that the both holes are aligned.

hole

1 gear (cap)

3 two claws

5 two hooks

6 lever (disc stop) lever (disc stop)

4 lever (disc sensor)

PRECAUTION DURING DISC STOP LEVER INSTALLATION

2 gear (IDL L)

4 three hooks2 two claws

6 claw

1 gear (IDL-F)

7 gear (IDL-C)

3 gear (IDL-D)

5 lever (gear loading) assy

22

HCD-AZ2D/AZ5DSECTION 4TEST MODE

COLD RESETThe cold reset clears data except DVD data stored in the RAM toinitial conditions. Execute this mode when returning the set to thecustomers.Procedure:

1. Press the ?/1 button to turn the power on.

2. Press two buttons of ?/1 , [DISPLAY]and touch the x sensorsimultaneously.

3. The message “COLD RESET” is displayed on the fluorescentindicator tube, then become standby mode.

PANEL TEST MODEThis mode is used to check the fluorescent indicator tube, LED,model, destination, software version and key.Procedure:

1. Press two buttons of [DIMMER] , [DIRECTION] and touch thex sensor simultaneously.

2. All LEDs and segments in fluorescent indicator tube are lightedup.

3. When you want to enter the software version display mode,

touch the .– sensor. The model name is displayed.

4. Each time .– sensor is touched, the display changes fromdestination, MC version, SYS version, UI version, DVDversion, ST version, TA version, TM version, TC version inthis order, and returns to the model name display.

5. When > + sensor is touched while the version numbers arebeing displayed except model name and destination, the dateof the software creation appear. When > + sensor is touchedagain, the display returns to the software version display. When

.– sensor is touched while the date of the software creationis being displayed, the date of the software creation is displayedin the same order of software version display.

6. Press the [DSGX] button, the key check mode is activated.7. In the key check mode, the fluorescent indicator tube displays

“K 0”. Each time a button is pressed, “K 0” value increases.However, once a button has been pressed, it is no longer takeninto account.

8. To release from this mode, press three buttons in the samemanner as step 1 or disconnect the power cord.

MEMORY CLEAR MODEThis mode moves clears main microprocessor data stored in theRAM to initial conditions. Use this mode when returning the set tothe customer after repair.Procedure:

1. Press the ?/1 button to turn the power on.2. Touch the [DVD] sensor to select the “DVD”.3. Press the [EQ SELECT] button and touch two sensors of [DVD],

x simultaneously.4. After the “STANDBY” blinking display finish, the message

“MECH A LOCK” is displayed on the fluorescent indicatortube.

DISC SLOT LOCKThis mode let you lock the disc slot. When this mode is activated,the disc will not eject when Z button is pressed. The message“LOCKED” will be displayed in on the fluorescent indicator tube.Procedure:

1. Press the ?/1 button to turn the power on.2. Touch the [DVD] sensor to select the “DVD”.

3. Touch the x sensor and press the Z button simultaneouslyand hold down until “LOCKED” or “UNLOCKED” displayedon the fluorescent indicator tube (around 5 seconds).

TUNER STEP CHANGE(Except Saudi Arabian and Russian models)The step interval of AM channels can be toggled between 9 kHzand 10 kHz.Procedure:

1. Press the ?/1 button to turn the power on.2. Touch the [TUNER/BAND] sensor to select the “AM”.3. Press the ?/1 button to turn the power off.

4. Touch the .– sensor and press ?/1 button simultaneously.The set power on automatically. The message “AM 9k Step”or AM10k Step” displayed on the fluorescent indicator tubeand thus the channel step is changed.

FUNCTION NAME CHANGEThis mode let you change from VIDEO to SAT and vice-versa.Procedure:

1. Press the ?/1 button to turn the power on.2. Touch the [VIDEO/SAT] sensor and press ?/1 button

simultaneously. The set power on automatically and thefunction will changed to SAT. Do the same procedures againto change from SAT to VIDEO.

COLOR SYSTEM CHANGE(Except Latin American and Russian models)This mode let you change the color system of the video output fromPAL to NTSC or vice-versa.Procedure:

1. Press the ?/1 button to turn the power on.2. Touch the [DVD] sensor to select the “DVD”.3. Press the ?/1 button to turn the power off.

4. Touch the X sensor and press ?/1 button simultaneously.5. The message “COLOR PAL” or “COLOR NTSC” will be

displayed on the fluorescent indicator tube.

23

HCD-AZ2D/AZ5D

1. DVD SERVICE MODE GENERAL DESCRIPTIONThe Mirror Time and TOP measurement allows you to makediagnosis and adjustment simply by using the remote commanderand monitor TV. The instructions, diagnosis results, etc. are givenon the on-screen display (OSD).

2. STARTING DVD SERVICE MODE1. Press the ?/1 button to turn the power on.2. Touch the [DVD] sensor to select the “DVD”.

3. Press the Z button and touch two sensors of x , [VOLUME

+] simultaneously.4. The message “SERVICE IN” will be displayed on the

fluorescent indicator tube and the Rimocon Diagnosis Menuis displayed on the on-screen display on the monitor TV asfollows. The model name, IF-con version and Syscon versionis displayed at the bottom of the on-screen display.

Remocon Diagnosis Menu

0. External Chip Check1. Servo Parameter Check2. Drive Manual Operation3. Emergency History4. Version Information5. Video Level Adjustment

Model Name :AZXD_XXIF-con :Ver.xx.xx (xxxx)Syscon :Ver.x.xxx

5. To execute each function, press its number by using numericbutton on the remote commander (RM-AMU001)

6. To release from this mode, press the ?/1 button to turn thepower off.

3. DRIVE MANUAL OPERATIONThe Drive Manual Operation menu consists of five main functions.On the Remocon Diagnosis Menu screen, press [2] button on theremote commander, and the following Drive Manual Operationmenu will be displayed.

Drive Manual Operation

1. Servo Control2. Track/Layer Jump3. Manual Adjustment4. Tray Aging Mode5. MIRR time Adjust0. Return to Top Menu

DVD SECTION 4. MIRROR TIME ADJUSTMENTOn the Drive Manual Operation menu screen, press [5] button onthe remote commander, and the following MIRR time Adjust Menuwill be displayed.

MIRR time Adjust Menu

1. CD MIRR time Check:2. DVD MIRR time Check:3. Threshold:4. Save to EEPROM5. Default set MIRR time

[Open] Tray open [Close] tray close[0] Return to previous menu

There are five main commands in the Mirr time Adjust menu. Thefunctions of each command are described in the following page.

1. CD MIRR time CheckThis command checks the Mirror time value for CD disc.

2. DVD MIRR time CheckThis command checks the Mirror time value for DVD disc.

3. ThresholdThis command displays the threshold value between CD and DVDmirror time.

4. Save to EEPROMThis command saves an adjusted mirror time value to the EEPROM.

5. Default set MIRR timeThis command will set CD and DVD mirror time to firm ware defaultvalue.

[Open]/[Close]

Pressing the Z button controls the tray for disc change during mirrortime adjustment.[0] Return to previous menu.Press the [0] button on the remote commander to return to previousmenu.

EXECUTING MIRROR TIME ADJUSTMENTIn order to execute mirror time adjustment, the following standardprocedures must be followed.

1. Set to the MIRR time Adjust Menu mode.2. Press the [5] button on the remote commander to select the “5

Default set MIRR time”.3. Press the [3] button on the remote commander to select the “3

Threshold”.4. Check the value of Threshold on the screen. If it is 75, go to

next step. If it is not so, return to step 2.

24

HCD-AZ2D/AZ5D

MIRR time Adjust Menu

1. CD MIRR time Check:2. DVD MIRR time Check:3. Threshold: 754. Save to EEPROM5. Default set MIRR time

[Open] Tray open [Close] Tray close[0] Return to previous menu

5. Insert the DVD test disc (HLX-504) (Part No.J-6090-088-A)6. Press the [2] button on the remote commander to select the “2

DVD MIRR time Check”.7. Wait for hexadecimal value to display on the screen.8. Check the value (##) of DVD MIRR time on the screen. If ##

is 28 to 70, go to next step. If it is not so, return to step 5.

MIRR time Adjust Menu1. CD MIRR time Check:2. DVD MIRR time Check: $$ ##3. Threshold:4. Save to EEPROM5. Default set MIRR time


9. Press the [4] button on the remote commander to select the “4.Save to EEPROM”

10. Check that $$ is the same as the value of ## on the screen. Ifit is not so, return to step 5.

11. Take out the DVD test disc (HLX-504) and insert the CD testdisc (YEDS-18) (Part No.3-703-998-01).

12. Press the [1] button on the remote commander to select the“1.CD MIRR time Check”.

13. Wait for hexadecimal value to display on the screen.14. Check the value (@@) of CD MIRR time on the screen. If @@

is 5A to E8, go to next step. If it is not so, return to step 11.

MIRR time Adjust Menu1. CD MIRR time Check: && @@2. DVD MIRR time Check: $$ ##3. Threshold:4. Save to EEPROM5. Default set MIRR time


15. Press the [4] button on the remote commander to select the “4.Save to EEPROM”.

16. Check that && is the same as the value of @@ on the screen. Ifit is not so, return to step 11.

17. Take out the CD test disc (YEDS-18)18. Release the MIRR time Adjust Menu mode.

5. EXECUTING IOP MEASUREMENTIn order to execute IOP measurement, the following standardprocedures must be followed.

1. Set to the Drive Manual Operation mode.2. Press the [3] button on the remote commander, and the

following Manual Adjust menu will be displayed.

Manual Adjust1. Track Balance Adjust:2. Track Gain Adjust:3. Focus Balance Adjust:4. Focus Gain Adjust:5. Eq Boost Adjust:6. Iop:7. TRV. Level:8. S curve (FE) Level:9. RFL(PI) Level:0. MIRR Time:

↑ ↓ Change Value[RETURN] Return to previous menu

3. Press the [6] button on the remote commander to select the“6. IOP”.

4. Wait for hexadecimal Value to display on the screen.

Manual Adjust

1. Track Balance Adjust:2. Track Gain Adjust:3. Focus Balance Adjust:4. Focus Gain Adjust:5. Eq Boost Adjust:6. Iop: ED7. TRV. Level:8. S curve(FE) Level:9. RFL(PI) Level:0. MIRR Time:

↑ ↓ Change Value[RETURN] Return to previous menu

5. Convert value (ED) from hexadecimal to decimal usingconversion table.

6. If the remainder is smaller than 93 (decimal), then it is OK.However if the value is higher than 93, then the BU (baseunit) is defective and need to be change.

7. Release the Manual Adjust menu mode.

6. DVD RAM CLEARThis mode clears DVD data stored in the DVD RAM to initialconditions.

1. On the Rimocon Diagnosis Menu screen, press [4] button onthe remote commander to select the “4.Version Information”.

2. Press in order of [MENU] button and [CLEAR] button on theremote commander.

3. Press in order of [MENU] button and [CLEAR] button on theremote commander to clear DVD data.

4. The message “Initialize all data” will be displayed on thescreen.

5. The message will change into “Initialize all data Complete”in about six seconds, and the clearness of the DVD data iscompleted.

25


MECHANICAL ADJUSTMENTSSECTION 6

ELECTRICAL ADJUSTMENTS

PRECAUTION1. Clean the following parts with a denatured-alcohol-moistened

swab :record/playback head pinch rollererase head rubber beltscapstan idlers

2. Demagnetize the record/playback head with a headdemagnetizer.

3. Do not use a magnetized screwdriver for the adjustments.4. After the adjustments, appiy suitable locking compound to

the parts adjusted.5. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.

• Torque Measurement

Mode Torque Meter Meter Reading

3.06 N⋅m to 6.96 N⋅mFWD CQ-102C 31 to 71 g⋅cm

(0.43 – 0.98 oz⋅inch)

FWD0.19 N⋅m to 0.58 N⋅m

Back TensionCQ-102C 2 to 6 g⋅cm

(0.02 – 0.08 oz⋅inch)

3.06 N⋅m to 6.96 N⋅mREV CQ-102RC 31 to 71 g⋅cm

(0.43 – 0.98 oz⋅inch)

REV0.19 N⋅m to 0.58 N⋅m

Back TensionCQ-102RC 2 to 6 g⋅cm

(0.02 – 0.08 oz⋅inch)

6.96 N⋅m to14.02 N⋅mFF/REW CQ-201B 71 to 143 g⋅cm

(0.98 – 1.99 oz⋅inch)

9.80 N⋅mFWD Tension CQ-403A 100 g or more

(3.53 oz or more)

9.80 N⋅mREV Tension CQ-403R 100 g or more

(3.53 oz or more)

0 dB=0.775 VDECK SECTION

Procedure:1. Mode: Playback

2. Turn the adjustment screw and check output peaks. If the peaksdo not match for L-CH and R-CH, turn the adjustment screwso that outputs match within 1dB of peak.

1. Demagnetize the record/playback head with a headdemagnetizer.

2. Do not use a magnetized screwdriver for the adjustments.3. After the adjustments, apply suitable locking compound to the

parts adjust.

TEST Tape

RECORD/PLAYBACK HEAD AZIMUTH ADJUSTMENT

Note: Perform this adjustments for both decks.

Tape Signal Used for

P-4-A063 6.3 kHz, -10 dB Azimuth Adjustment

DECK–A DECK–B

set

MAIN boardVIDEO/SAT OUT jack (J101)

+–

level meter

test tapeP-4-A063(6.3 kHz, –10 dB)

Screwposition

L-CHpeak

within1dB

Outputlevel

L-CHpeak

R-CHpeak

within1dB

Screwposition

R-CHpeak

26

HCD-AZ2D/AZ5D

3. Mode: Playback

4. After the adjustments, apply suitable locking compound tothe pats adjusted.

Adjustment Location: Playback Head (DECK-A)Record/Playback/Erase Head (DECK-B)

RFMON LEVEL CHECK

Procedure :1. Connect the oscilloscope to CN105 pin 6 (RFMON) and

CN105 pin 3 (GND) on the DMB10 board.2. Press the `/1 button to turn the power on.3. Insert the test disc (DVD: TDV-520CSO (Part No. J-2501-

236-A), CD: LUV-P01 (Part No. 4-999-032-01) and touch theY sensor to playback.

4. Confirm that oscilloscope waveform is as shown in thefigure below. (eye pattern)A good eye pattern means that the diamond shape (◊) in thecenter of the waveform can be clearly distinguished.

Checking Location:

DVD SECTION

set

test tapeP-4-A063(6.3 kHz, –10 dB)

oscilloscope

V H

waveform of oscilloscope

in phase 45° 90° 135° 180°

good wrong

MAIN boardVIDEO/SAT OUT jack (J101)

reverse

forward

forward

+–

DMB10 board

CN105 pin 6 (RFMON)CN105 pin 3 (GND)

oscilloscope(DC range)

VOLT/DIV: 200 mVTIME/DIV: 500 ns

level:0.8 ± 0.2 Vp-p (DVD)0.8 ± 0.2 Vp-p (CD)

IC102

– DMB10 BOARD (Side A) –

IC201

CN1051

6

2727

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

SECTION 7DIAGRAMS

7-1. BLOCK DIAGRAM – RF SERVO/VIDEO SECTION –

FLASH ROMIC101

DQ0 – DQ7

AD0 – AD7

A-1, A0 – A20

IOA0 – IOA21

DIGITAL OPTICALTRANSCEIVER

IC231

D/A CONVERTERIC301

OPTICAL PICK-UPBLOCK

(KHM-310CAB)

RF AMP, SERVO DSP,MPEG DECODER

IC102

FOCUS/TRACKING COIL DRIVE,SPINDLE/SLED/LOADING MOTOR DRIVE

IC201

AUTOMATIC POWERCONTROL (FOR CD)

Q102-1

DVDRF IP6

MA8MB9MC10MD11

RF

DVDA2

SDTI114

DVDB3DVDC4DVDD5

VOA/AVOB/BVOC/CVOD/D

TNI18VOE/E+GTPI19VOF/F+H

V2029VC

LDO123LD (780)

AUTOMATIC POWERCONTROL (FOR DVD)

Q102-2LDO222LD (650)

FOO42

CD ONSWITCHQ101-1

DVD ONSWITCHQ101-2

VR (780)

MSW

LIMSW

187VR (650)

FCS+

MSW

MDI120MDI221

PD

176LIMIT

Q103

DVDDIGITAL

OUT

IOCS

CE

SD-RAMIC104

X10127MHz

S003(TRIGGER)

FL

FR

A

36FCS– 37

1

TRO41TRK+ 35TRK– 34

4

FMO38SL+ 29SL– 30

10

DMO37SP+ 27SP– 28

3132

42

4647

13

SPFG47

REV185FWD186

45

TROPENPWM39

ASDATA0 217 LOUT1+ 2LOUT1– 1ROUT1+ 48ROUT1– 47

MCLK

ACLK

10ACLK 215BICK9ABCK 214LRCK17ALRCK 213

SDA20SDA 103

SPDATA 209

SCL19SCL 102

PDN8XRST 220

SPDIF 225

XTAL

I

229

TRG-

SW

104

XTAL

O

228

EEPROMIC103SD

A

6

SCL

5

MIC 205

MIX AMPIC3711

SDTI215 SL

SR

ASDATA1 218 LOUT2+ 46LOUT2– 45ROUT2+ 44

43ROUT2–

MIX AMPIC3731

SDTI316 FC

SW


39ROUT3–

MIX AMPIC3751

SDTI413 LT

RT


32ROUT4–

MIX AMPIC3771

FL, FR, SL, SR, FC, SW, LT, RT

CMIC

BSPDATA, ACLK, ABCK, ALRCK

81 – 84,86 – 88, 91

29, 31, 33, 35,38, 40, 42, 44

93, 78, 53 – 59, 75, 74,72 – 67, 92, 60, 61, 76, 89

45, 25 – 18, 8 – 1,48, 17, 16, 9, 10

DQ0 – DQ15

RD0 – RD15

A0 – A11

RA0 – RA11

2, 4, 5, 7, 8, 10, 11, 13, 42,44, 45, 47, 48, 50, 51, 53

125 – 123, 121, 120, 118, 117,115, 135, 133 – 128, 126

147, 149 – 151, 166 – 164,162, 160, 159, 146, 158

23 – 26,29 – 34, 22, 35

77

26

IOOE

OE

79

28

IOW

RW

E

66

11

BA0

BA0

143

20

BA1

BA1

145

21

RCLK

CLK

156

38

CKE

CKE

157

37

DQM

0LD

QM

113

15

DQM

1UD

QM

137

39RA

S/R

AS

140

18CA

S/C

AS

139

17

RCS

/CS

142

19

RWE

/WE

138

WID

E

171

16

• SIGNAL PATH

: CD PLAY

: DVD PLAY

: AUDIO

: VIDEO

: Y

: CHROMA

: COMPONENT VIDEO

FOCUSCOIL DRIVE

TRACKINGCOIL DRIVE

SLEDMOTOR DRIVE

SPINDLEMOTOR DRIVE

REGULATOR

2524

1617

MUTE123MUTE12 18419

MUTEMUTE34 18320TSDMTSD-M 18122

IOPMON4040

8

MUTE5 21

15

LOADINGMOTOR DRIVE

BUFFER

BUFFER

MM001(LOADING)

RF+3.3V

SW+5V

S002(CHUCKING)

CKSW

179

S001(DISC IN/OUT)

OCKS

W

177

REGO2REGO1

P_I_

DVD_

SIIF

SDO

32

19

98

P_I_

DVD_

XIFC

SIX

FCS

26

100

P_I_

MRE

QM

REQ

25

114

P_I_

KRM

ODKR

MOD

27

207

P_O_

DVD_

SOIF

SDI

31

101

PI_D

VD_S

CKIF

CK

33

99

P_O_

DVD_

BUSY

IFBS

Y

28

105

P_ID

_IO_

SYSR

STPR

ST

34

P_VI

DEO_

MUT

E

23

110

SWITCHQ2001

SWITCHQ464

P_DVD_I_MTK_SLOT_IN

SYSTEMCONTROLLER

IC401 (1/5)

CENTER VOLTAGEGENERATOR

Q3801

ABCK

ALRC

K

SPDA

TA

VIDEO OUTJ1202

S VIDEO OUTJ1201196YUV2

194YUV1

198YUV3

DSEL

188

J1203COMPONENTVIDEO OUT

Y

PB/CB

PR/CR

202YUV5

202YUV4

203YUV6

VIDEO AMP, 75Ω DRIVERIC1201

4 CVBS IN

2 C IN

6 Y IN

10 CY IN

12 CB IN

14 CR IN

23CVBS OUT

26C OUT

21Y OUT

20CY OUT

18CB OUT

16CR OUT

27S-DC OUT

3

MUT

E1

13

MUT

E2

25

S1

9

I/P

C Y

: DIGITAL OUT

(AZ2D)

(AZ5D)

(AZ5D)

(AZ5D)

(Page 29)

(Page 29)

(Page 29)

2828

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-2. BLOCK DIAGRAM – TUNER/TAPE SECTION –

T301BIAS OSC

BIAS OSCQ318

REC BIASSWITCH

Q316, 317A+9V

R-CH

TUNER UNIT

AM

FM ANT

AM ANT

ST-LST-R

STDOUT

TUNED

STDINSTCLK

STCE

FM 75ΩCOAXIAL

ANTENNA

HRPE301(REC/PB/ERASE)

(DECK-B)

HP301(PB)

(DECK-A)

L-CH

L-CH

R-CH

R-CH

R-CH

R-CH

ERASE

R-CH

MUTINGQ303

MUTING CONTROLSWITCH

Q314, 315

R-CH

MUTINGQ301, 302

R-CH


Q311 – 313


Q361

MUTINGQ104

71

70

48 50EQ

68

111098

67 66

DECK A/B SELECT SWITCH,REC/PB EQ AMP

IC101 (1/2)

AMS

AMS DETECTQ341 – 343

AMS MUTINGQ140, 363

A CAPM+M

TAPE MECHANISMDECK BLOCK

A PLAY

A TRGM+

B PLAYA SHUTB SHUTA HALFB HALFF-RECR-REC

(DECK-A)

B TRGM+

(DECK-B)

41 ST-CE39 ST-CLK38 ST-DOUT40 ST-DIN

37 ST TUNED

75 TC AMS IN

70 TC LINE MUTE

44 P_TC_AMS_MUTE

22 TC A PLAY SW

68 TC PB/REC

69 TC REC MUTE

67 TC BIAS

80 TC B PLAY SW97 TAPE A SHUT90 TAPE B SHUT21 TC A HALF91 TAPE B HALF/REC

36 TC A TRG

79 TC B TRG

35 TC A CAPM

DST-L

FREC-L

EPB-L

MUTINGQ103

R-CH


Q362

TRIGGER PLUNGERDRIVE (DECK-A)

Q323, 324

TRIGGER PLUNGERDRIVE (DECK-B)

Q321, 322

CAPSTAN/REELMOTOR DRIVE (DECK-A)

Q326, 327

B CAPM+M 78 TC B CAPMCAPSTAN/REEL

MOTOR DRIVE (DECK-B)Q328, 329

SYSTEM CONTROLLERIC401 (2/5)

• SIGNAL PATH

: TAPE PLAY (DECK-B)

: REC

: TAPE PLAY (DECK-A)

: TUNER (FM/AM)

• R-ch is omitted due to same as L-ch.

BIASTRAP

C306, L301

CAPSTAN/REEL(DECK-A)

CAPSTAN/REEL(DECK-B)

(Page 29)

(Page 29)

(Page 29)

2929

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-3. BLOCK DIAGRAM – AUDIO SECTION –

AFL, FR, SL, SR,FC, SW, LT, RT

MUTINGQ270

MUTINGQ271

MUTINGQ272

MUTINGQ273

EPB-L

CMIC

RT

FL

FR

LT

SR

SW

C

SL

MUTINGQ274

MUTINGQ275

MUTINGQ276

MUTINGQ277

2

1

R-CH

R-CH

R-CH

13

6465

DST-L

R-CH

J101 (1/2)

CN1

VIDEO/SATIN

L

R

62

J1060MIC 1

J1061MIC 2

MIC AMPIC1060 (1/2)

MIC AMPIC1060 (2/2)

RV1060MIC LEVEL

DIGITAL ECHOIC1061

RV1061ECHO LEVEL

SELE

CTOR

TONE

63 42 41 37+

6

59 56 53

52 51

+R-CH+R-CH

BASSBOOST

31 30 29

403938


Q263

77 P_A_MUTE

65 P_MIC_IN

P_AM

PIC_

DATA

71

P_AM

PIC_

CLK

P_O_DVD_POWER

72

P_VA

CS

69

R-CH

R-CH

MUTINGQ201FEED BACK

SWITCHQ101

R-CH

I/FMCU

3435

48

HP_MUTING 61P_HEADPHONE IN 63

P_LINE_MUTING 66P_RECOUT_MUTING 46


Q262

MUTINGQ141


Q171

MUTINGQ1


Q113

MUTINGQ31, 32


Q30

MUTINGQ33

MUTINGQ34

MUTINGQ35

MUTINGQ36

R-CH

FL, FR, SL,SR, C, SW

H

DVD POWERJ

REC-LF

FEED BACK G

SPDATA, ACLK,ABCK, ALRCK

B

FL

FR

SL

C

SPDATA

A/D CONVERTERIC3601

LIN

R-CH

ACLKABCK

ALRCK

1

RIN2

12DOUT15SCKI11BCK10LRCK

J101 (2/2)

R-CH

VIDEO/SAT OUT

L

R


INPUT SELECT SWITCH,TONE CONTROL,ELECTRICAL VOLUME, BASS BOOST AMP

IC101 (2/2)

AUDIO SELECT SWITCHIC261

• SIGNAL PATH

: REC

: VIDEO/SAT OUT

: VIDEO/SAT IN

: MIC INPUT

: TAPE PLAY

: TUNER (FM/AM)

: AUDIO

• R-ch is omitted due to same as L-ch.

: USB

PC

3

2

1

D+

D–

VBUSUSB CONTROL

SWITCHQ11, 12

9 D+

8 D–

21

HOST

28

XTI

27

SSPN

D

1

XTO

X1112MHz

14VOUTL15VOUTR

USB D/ACONVERTER

IC1

R-CH

X0

X1

Y0

5

3

Z0

Y1

Z1

1214

SR15

X

Y

SW4

Z

10Y-Y1

11X-X1

9Z-Z1

P_LI

NK_L

FE_S

W

Q260 Q261Q465

42

PCM

2704

POW

ER

45

P_LI

NK_S

W

76

D1

A+9V

33

74AUDIO+4.5V

MUTINGQ73, 83


Q22

MUTINGQ71, 81 J1050

PHONES

HEADPHONEAMPIC3

RIPPLEFILTER

Q82A+9V

D181

: DIGITAL OUT

(AZ5D)

(AZ5D)

(AZ5D)

(Page 28)

(Page 28)

(Page 27)

(Page 27)

(Page 28)

(Page 27)

(Page 30)

(Page 30)

(Page 31)

3030

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-4. BLOCK DIAGRAM – AMP SECTION –

HFL, FR, SL, SR, C, SW

FR

FL 112

LIN

2 RINDOUT

11BCK

LRCK

PDW

N

7

A/D CONVERTERIC503

10

SR

SL

15 SCKI

112

LIN

2 RINDOUT

11BCK

LRCKPD

WN

7

A/D CONVERTERIC502

1015 SCKI

C

SW1

12LIN

2 RINDOUT

11BCK

LRCK

PDW

N

7

A/D CONVERTERIC501

1015 SCKI

CLOCKBUFFERIC514

X50112.288MHz

/SD

DIGITAL POWER AMPIC512

PWM_BP OUT_B

OUT_A

STREAM PROCESSORIC506

31 DATA

OVER LOADDETECT

Q721, 722


30 BCK

29 LRCK

36 XFSIIN21 SCDT

SCDTSCK

22 SCSHIFTSCSHIFT

23 SCLATCHLAT1

27 INITINIT

18 NSPMUTE24 OVF FLAGL25 OVF FLAGR

NSP MUTEOVF

X50249.152MHz

SCK

L.P.F.

L.P.F.

OUTL1 11 2

PWM_AP17

13

/RST

4

/OTW

2

OUTL2 9

OUTR1 6

OUTR2 4

XFSOIN 48

FSOCKO 37

XFSOOUT 14

FSOI 38


31 DATA

30 BCK

29 LRCK

36 XFSIIN21 SCDT

SCDTSCK

22 SCSHIFTSCSHIFT

23 SCLATCHLAT3

27 INITINIT

18 NSPMUTE24 OVF FLAGL25 OVF FLAGR

NSP MUTEOVF

OUTL1 11

OUTL2 9

OUTR1 6

OUTR2 4

XFSOIN 48

XFSOOUT 14

FSOI 38


31 DATA

30 BCK

29 LRCK

36 XFSIIN21 SCDT

SCDTSCK

22 SCSHIFTSCSHIFT

23 SCLATCHLAT2

27 INITINIT

18 NSPMUTE24 OVF FLAGL

SCDTSCSHIFT

LAT1

LAT3LAT2

INIT

25 OVF FLAGR

NSP MUTEOVF

OUTR1 6

OUTR2 4

OUTL1 11

OUTL2 9

XFSOIN 48

FSOI 38

CLOCKBUFFERIC515

29, 30

25, 26FRONT L

+–

/SD


PWM_BP OUT_B

OUT_A

OVER LOADDETECT

Q751, 752

L.P.F.

L.P.F.

2

PWM_AP17

13

/RST

4

29, 30

25, 26FRONT R

+–

TM1100SPEAKER

TM1101SPEAKER

/OTW

2

OVER LOADDETECT

Q661, 662

/SD


PWM_A OUT_A

OUT_B

OVER LOADDETECT

Q691, 692

L.P.F.

L.P.F.

4 33

30

OUT_C 25

OUT_D 22

PWM_B6

PWM_C14

PWM_D16

3

/RES

ET_A

B

5

/RES

ET_C

D

15

SURR L

SURR R

+–

L.P.F.

L.P.F.

+–

/OTW

2

/SD


PWM_BP OUT_B

OUT_A

OVER LOADDETECT

Q631, 632

L.P.F.

L.P.F.

2

PWM_AP17

13

/RST

4

29, 30

25, 26CENTER

+–

S.WOOFER+–

/SD


PWM_BP OUT_B

OUT_A

OVER LOADDETECT

Q571, 572

L.P.F.2

PWM_AP17

13

/OTW

2

/RST

4

29, 30

25, 26

/OTW

2

/SD


PWM_BP OUT_B

OUT_A

L.P.F.2

PWM_AP17

13

/OTW

2

/RST

4

29, 30

25, 26

FAN MOTORSWITCH

Q983

M901(FAN)M

M902(FAN)M

PROTECT DETECTQ657

P_ADC_RESET 51

P_SM_DATA 1P_SM_CLK 2P_SM_CS1 58

P_SM_CS3 60P_SM_CS2 59

P_SM_INIT 52NSP MUTE

OVFP_SM_NSP_MUTING 53

P_SM_OVF 57

P_SM_OTW 54P_SW_SD 55

FAN DRIVE 50

P_SM_DRV_RST 56

: AUDIO

SIGNAL PATH

+ FEED BACKG

D771

FAN MOTORDRIVEQ984

D982FAN MOTORCONTROLQ981, 982

FAN M+12V

(AZ5D)

(AZ5D)

(AZ5D)

(Page 29)

(Page 29)

3131

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-5. BLOCK DIAGRAM – PANEL/POWER SUPPLY SECTION –

RESET SIGNALGENARATOR

IC391

RESETSWITCH

Q391

BACKLIGHT 24 D1006 – 1010(BACK LIGHT)

SIRCSREMOTE CONTROL

RECEIVERIC1040

4

15

X4025MHz

X-IN

13

X-OU

T

10

X40132.768kHz

XC-IN

11

XC-O

UT

DVD M+9V

VP B– M+9V

A+9V

A+5V

D+3.3V(FOR AMP SECTION)

FAN M+12V

20AC-CUT

49STBY RELAY

12RESET

EVER+3.3V

D394

D399

D951

D400

LED DRIVEQ1001, 1002

STANDBY LED 100 D1030(STANDBY)73 P_DISP_KEY

74 P_POWER_KEY

94 KEY_2

95 KEY_1

762 ML9208 CLKCP661 ML9208 CSCS

563 ML9208 DATADA

59OSC158OSC0

360 ML9208 RESETRESET

FL1001FLUORESCENT

INDICATOR TUBE

COM

2 –

COM

15AD

1, A

D2,

SEG1

– S

EG35

40, 5

541

– 5

43

– 39

COM

1, C

OM16

DRIV

E1 –

DRI

VE4

84, 8

5, 8

3, 8

6

KEY

IN_1

–KE

Y IN

_3

82, 8

7, 8

1

GRID DRIVEQ1003, 1004


FLUORESCENT INDICATORTUBE DRIVER

IC1001

DVD POWERJ

(AC IN)

ON/OFF

EVER+4V

30.4V30.4V30.4V

UNREG+12V

SWITCHINGREGULATOR

UNREG+7.5VUNREG+7.5V

UNREG+12V

30.4V

D+12VD+12V

RF+3.3V

SW+5V

DIGITALPOWER AMP

B+

FOR FLUORESCENTINDICATOR TUBE

+5VREGULATOR

IC956

REGULATORCONTROL SWITCH

Q951, 952

+3.3VREGULATOR

IC955

+3.3VREGULATOR

IC107

D+3.3V

D397

D953

µ-COM+3.3V

+3.3V

SW+3.3V

A+3.3V

+3.3VREGULATOR

IC105

RF+1.8V+1.8V

REGULATORIC106

+4VREGULATOR

IC953

+9VREGULATOR

IC954

+9VREGULATOR

IC952

+9VREGULATOR

IC951

RECTD10011 – 1004

OSCQ1005

F1F2

T101DC/DC

CONVERTER

+5VREGULATOR

IC516

+3.3VREGULATOR

IC517

+1.8V+1.8V

REGULATORIC518

OSC

C1010, R1012

S1030 – 1034,S1035 – 1039, 1041

TS1TOUCH

SENSOR

(Page 29)

3232

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

• Note for Printed Wiring Boards and Schematic Diagrams

• DMB10 board is multi-layer printed board.However, the patterns of intermediate-layer have not been in-cluded in this diagrams.

• Indication of transistor

• Circuit Boards Location

Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• f : internal component.• C : panel designation.

• A : B+ Line.• B : B– Line.• Voltages and waveforms are dc with respect to ground

under no-signal conditions.no mark : TUNER (FM/AM)( ) : DVD PLAY[ ] : TAPE PLAY (DECK-A)< > : TAPE PLAY (DECK-B)⟨⟨ ⟩⟩ : REC : PC

* : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.J : CD PLAYc : DVD PLAYI : DIGITAL OUTF : AUDIOL : VIDEOa : YE : CHROMAr : COMPONENT VIDEOf : TUNER (FM/AM)j : TAPE PLAY (DECK-A)d : TAPE PLAY (DECK-B)G : RECh : VIDEO/SAT OUTk : VIDEO/SAT INO : USBN : MIC INPUT

• AbbreviationAUS : Australian modelE2 : 120V AC area in E modelE3 : 240V AC area in E modelE12 : 220-240V AC area in E modelE13 : 220-230V AC area in E model (Russian model)E15 : Iranian modelEA : Saudi Arabia modelKR : Korean modelMY : Malaysia modelPH : Philippines modelSP : Singapore modelTH : Thai model

Note on Printed Wiring Board:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• x : parts mounted on the conductor side.• W : indicates side identified with part number.• f : internal component.• : Pattern from the side which enables seeing.(The other layers' patterns are not indicated.)

Caution:Pattern face side: Parts on the pattern face side seen from(Side B) the pattern face are indicated.Parts face side: Parts on the parts face side seen from(Side A) the parts face are indicated.

Caution:Pattern face side: Parts on the pattern face side seen from(Conductor Side) the pattern face are indicated.Parts face side: Parts on the parts face side seen from(Component Side) the parts face are indicated.

Note: The components identified by mark 0 or dotted linewith mark ! are critical for safety.Replace only with part number specified.

C

B

These are omitted.

E

Q

B

These are omitted.

C E

Q

TUNER UNIT

MS-214 board

VIDEO board

DMB10 board

SP OUT board

S-MASTER board

MIC board

SIRCS board

EJECT board

KEY board

FL board

MAIN board

SWITCHING REGULATOR

3333

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-6. PRINTED WIRING BOARD – DMB10 BOARD (SIDE A) – • See page 32 for Circuit Boards Location. : Uses unleaded solder.

New part of EEPROM (IC103) on the DMB10 board can not be used.Therefore, if the mounted DMB10 board is replaced, exchange newEEPROM with that used before the replacement.

• SemiconductorLocation

Ref. No. LocationD1001 B-4D3501 C-2D3502 C-2

IC101 D-6IC102 D-4IC103 C-4IC104 C-5IC106 B-4IC201 B-6

Q103 E-4Q3801 C-3

R103

R198

C308

CN103

R360

7

C3802

L360

2

FB115

FB114FB113

FB112

CN20

2

R365

3

R227

IC201

R319

Q103

R116

C226

R117

C225

C224

IC102

R136

IC106

R142

IC104IC103

R110

7

R3805

R144

C223

C222 C221

R153R155

C220

C219

FL10

1

C218

C215

FL107

C210 R208

C208

CN10

5CN

106

CN201

CN401

R209C206

C205

R210

R214

FB40

1

FB40

2

FB40

3

FB404

FB405

FB40

6

R215

R216

R219 R2

24

R228

FL40

3

FL402

C190

R233

R234

C180 C179

R161

R107

R101

R243

R152

7

RB107

C217

C102

C105

C402

C108

RB108

RB11

3

R189

C307

C305

R190

R1557

C302

R192

C153

C152

R1101

C117

R1102

R110

5

R1108

R1109R3

651

C145 C142

C138C137C135

R112

9

C133C132

R116

8

C119

C118

C116

C112

R195

C306

C101

R197

C167

C170

C181

C187

CN101

RB11

2

C189

C177

R154

5

R2501

C2501

R250

2

C403

C129

R152

C378

3

C378

2

C3781

C3774

C377

3

C3772 C3771

C370

7

R378

2R3

781

R4706

R4705

C3784

R3773

R3774

R377

5

R3776

R377

7

C3804

R3772

R3771

R376

8R3

767

R3766

R376

5

R3764

R3763

R375

8R3

757

R377

8

R3783

R3756

R3784

R378

5

R3786

R375

5

R3754

R3753

C3764

R378

7

C376

3

C376

2

C3761

C3754

R378

8

C375

3

C3752 C3751

C370

5

R376

2R3

761

R375

2

R3751

R374

8R3

747

R3746

Q380

1

R374

5

R3744

R3743

R373

8R3

737

R3736R3

735 R3734

R3733

C3744

C374

3

C374

2

C3741

C3734C3

733

C3732

C373

1

C370

3

D3502D3501

CN30

2

C150

C3724

C372

3

C372

2

C3721

C3714

R3804

R3803

R374

2R3

741

C371

3

C3712

C371

1

R373

2R3731

C370

1

C3609

C3608

C3606

C3605

C360

3

R372

8R3

727

R3726

R3603

R372

5

R3724

R3711

R371

2

R3723

R372

2

R372

1

R371

8 R3713

R3714

R371

5

R371

7

R3716

C178

R3801

R380

2

FL40

1

C3801

R154

9

R1550

R1553

D1001

X101

IC101

R193

R191

C3803

C3805

CN30

1

112

36

37

25

24

48

13

129192

64

65

1

256

128193

1-864-397- 11

DMB10 BOARD (SIDE A)

(AZ5D)

(AZ5D)(AZ5D)

(AZ5D)

(AZ5D)

(AZ2D)

(AZ5D)

(AZ5D)

MS-214BOARDCN001

C

MAINBOARDCN203

A

E

OPTICAL PICK-UPBLOCK

(KHM-310CAB)

(FOR CHECK)

FORCHECK

MAIN BOARDNO953

(Page 40)

B

1 5

VIDEOBOARDCN1201

(Page 53)

D

MAIN BOARDCN201 (AZ5D)CN202 (AZ2D)

E

A

B

C

D

E

F

1 2 3 4 5 6 7

E

(Page 40)

(Page 40)

(Page 39)

3434

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-7. PRINTED WIRING BOARD – DMB10 BOARD (SIDE B) – • See page 32 for Circuit Boards Location. : Uses unleaded solder.


Ref. No. LocationD3601 B-5D3602 B-5

IC105 B-2IC107 E-4IC301 B-4IC3601 B-5IC3711 B-5IC3731 B-4IC3751 C-4IC3771 C-5

Q101 E-3Q102 E-3Q2001 E-1

C360

4

R451

3

R143

R3501

R1552

R500

8R5

009

R501

4

R501

6R5

017

L3601

C114

C115

C120

C121C122C123

C124C125

C126

FB111

C130

R109

C139

C140

C143

C146

C147

C148 C149

C151

C154

C156

C159

C161

C163

R3652

R105

R106

R123

R360

5

C171C172

C173

R110R118R120R121

R187

R127

C193

C195

R134

R135

C301

R164

R169

R113

3

R204

R205

R146

R151

FL10

4

R206

R207R212

R213

FL10

6

FL105

R220 R221

R222

IC301

R223

R225

IC105

R226

R230

R231 R232

R236

R237

R238

Q102

R246R247

R133

R1110

R239

R196

R115

0

IC107

R1151R1152

R1530

R1531

RB104RB111

Q101

RB105 RB106

C214

C213

C212

R108

C211

R154

0

R111

R112R113

R114

R115

C209

R126

R124

C203

Q2001

C191

R141

C188

R160

C184

C182

R113

4

R1126R1161 R1125

R1124R1123R1122R1121

C176

C175

C174

R314

R110

4

R1120

R110

3

C164

R1504

C106

R1503

C109

R150

2

C113

C127

C128

C131

C136

R104

C144

C155

C158

C160

C162

C370

8

R4704R4703R4702R4701

R1542

C192

RB103

IC3751

C370

6

IC3731

FL108

R3606

R361

1C141

R3621

C370

4

IC3711

IC3601

R321

C3601

R138

C362

1

C3702

C361

1

C3610

C360

7

C360

2

R3601

R3602

IC3771

R1526

R1524

R360

9

R3789

R377

9

R3769

R375

9

R3749

R373

9

R3729

R3719

R1546

C196

D3601D360

2

C233

R1547

R1548R155

1

R1554

S

1124813

37

3625

13

54

24

DMB10 BOARD (SIDE B)

1-864-397- 11

(AZ5

D)(A

Z2D)

(AZ2

D: E

2/AZ

5D: E

2)

AZ2D: SP, MY, KR, PH/AZ5D: SP, MY, TH

AZ2D: E3, E12, E13, E15, EA, AUS/AZ5D: E3, E12, E15, EA, AUS

(AZ5D)

(AZ5D)

(AZ5D)

(AZ2D)

11

20

10

1

(AZ2D)

1C

2C

2E

1E

1B1D2S2G

1S2D1G

2B1

DG

3

5 4

A

B

C

D

E

F

1 2 3 4 5

3535

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-8. SCHEMATIC DIAGRAM – DMB10 BOARD (1/4) – • See page 60 for IC Block Diagrams.


(Page 37)

(Page 37)

(Page 36)

(Page 36)

(Page 37)

(Page 44)

(Page 37)

(Page 37)

(Page 38)

(Page 36)

(Page 37)

(Page 37)

(Page 37)

(Page 36)

(Page 36)

(Page 37 )

RB105

RB106

R1150

R1151

R1152

FB111

FB112

FB113

FB114

CN101

R111

R116

R117

R114

R110 C105

C106

R112 R113 R118 R120R115

R108

R104

R1

06

C180

R1133

C188C182C187C189R169

R1134

C184

C193 C195

R193

R191

C167

R121 R124

R126

CN105

CN103

R109 C112

C190

C191C179

IC104

R105

C102

C101

R101

IC107

C192

D1001

IC105

Q102

R107

R1546

C108

C109

C181

R5008

R5009

R5010

R5017

R5016

R5014

Q103

CN106

R1545R1502

FB115

IC103

FL108

R1110

FL107

C178

IC101

FL101

R187

Q101

R1129 C113

IC106

47

47

3.3k

3.3k

3.3k

24P

100

1k

47k

100k

47k 476.3V

0.01

22 22 22 2222

1M

0

10

k

0.1

0

0.220.22474V0.33

10k0

0.01

0.22 0.22

1k

1k

0.01

22 47k

0

6P

5P

0 476.3V

476.3V

0.10.1

HY57V641620HGTP-HDR

10k

0.01

0.01

100

TK11133CSCL-G

0.01

RB501V-40TE-17

TK11133CSCL-G

QST8TR

10k

3.3k

0.001

0.001

0.1

0

0

0

0

0

0

RT1N241C-TP-1

13P

00

BR24L64F-WE2

2.7k

474V

0

UM6K1N-TN

100k 0.01

PQ018EZ01ZP

A1

A2

A3

A5

A4

A6

A7

A8

A11

A13

A14

A15

A1

6

A1

7

A1

9

A2

2

A1

8

A2

1

A2

0

A2

6

A2

3

A2

4

A2

5

A28

A30

A29

A31

A32

A33

A27

REG01

SW+5V

SW+3.3V

GND

RF+3.3V

TRK-

TRK+

FCS+

FCS-

IOP

MSW

V2REFO

SCL

SDA

REG02

MREQ

MIC

KRMOD

OCSW1

RF1.8

FCS+

TRK-

TRK+

FCS-

RA4

RA5

RA6

RA7

RA8

RA9

RA11

DRCKE

DRCLK

DQM1

RD0

RD1

RD2

RD3

RD4

RD5

RD6

RD7

DQM0

RWE

CAS

RAS

RCS

BA0

BA1

RA10

RA0

RA1

RA2

RA3

RD8

RD9

RD10

RD11

RD12

RD13

RD14

RD15

VOE

VOF

VOC

VOD

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A18

A19

A20

A21

XROMCS

HD0

HD1

HD2

HD3

HD4

HD5

HD6

HD7

A0

A1

A17

TRK-

TRK+

FCS+

FCS-

DVD_LD

CD_LD

DVD_LD

CD_LD

XRD

VOB

VOA

FE

TE

PI

XWR

KR

MO

D

KRMOD

MIC

MIC

MR

EQ

MREQ

SD

A

SDA

SC

L

SCL

OC

SW

1

OCSW1

*

TXD

RXD

GND

+3.3V

RFMON

V2REFO

RF

GND

FE

TE

PI

A0

A1

A2

GND

VCC

SCL

SDA

A15

A14

A13

A12

A11

A10

A9

A8

A19

WE

RESET

N.C.

N.C.

RY/BY

A18

A17

A7

A6

A5

A4

A3

A2

A1

A16

BYTE

VSS

DQ7

DQ14

DQ6

DQ13

DQ5

DQ12

DQ4

VCC

DQ11

DQ3

DQ10

DQ2

DQ9

DQ1

DQ8

DQ0

OE

VSS

CE

A0

RF

VOB/B

VOC/C

VOD/D

VOA/A

VOF/F+H

VC

VCC

VOE/E+G

NC

TRK-

FCS-

TRK+

FCS+

PD

NC

SS

NC

SYSRST

XIFCS

IFBSY

SIO

S0O

SCO

GND (LD)

LD (650)

LD (780)

VR (650)

VR (780)

GND (PDIC)

(LO:DVD.HI:CD)MSW

3.3V_MNT

MREQ

MIC

VOICE (N.C)

KRMOD

CONT

GND

NOISE

VIN

VOUT

NOISE

GND

CONT

VOUT

VIN

(1/4)

+3.3V REGULATOR

VIN

NC

VOUT

CONT

GND

+1.8V REGULATOR

+3.3V REGULATOR

-1-2

INVERTER

(FOR CHECK)

-2 -1

Q101-1

Q101-2

CD ON

SWITCH

DVD ON

SWITCH

Q102-1

AUTOMATIC POWER

CONTROL(FOR CD)

AUTOMATIC POWER

Q102-1

CONTROL(FOR DVD)

VSS

A4

A5

A6

A7

A8

A9

A11

NC

CLK

UDQM

NC

VSS

DQ8

VDDQ

DQ9

DQ10

VSSQ

DQ11

DQ12

VDDQ

DQ13

DQ14

VSSQ

DQ15

VSS

VDD

A3

A2

A1

A0

A10

BA1

BA0

/CS

LDQM

DQ7

VSSQ

DQ6

DQ5

VDDQ

DQ4

DQ3

VSSQ

DQ2

DQ1

VDDQ

DQ0

VDD

SD-RAM

DQ15

A20

(AZ2D)

(AZ5D)

AZ5D:E2

AZ2D:E2/

E13,E15,

EA,AUS/

AZ5D:E3,E12,

E15,EA,AUS

AZ2D:SP,

MY,KR,PH/

OCSW1

D-GND

WP

(FOR CHECK)

EEPROM

FLASH ROM

*IC101

S29JL032H70-SBS2-0503UC(AZ2D:E2)

AZ2D:E3,E12

MY,TH

AZ5D:SP,

CKE /RAS

/CAS

/WE

VDD

S29JL032H70-SBS2-0503CE(AZ2D:E3,E12,E13,E15,EA,AUS)

S29JL032H70-SBS2-0503GA(AZ2D:SP,MY,KR,PH)

S29JL032H70-SBS1-0503UC(AZ5D:E2)

S29JL032H70-SBS1-0503CE(AZ5D:E3,E12,E15,EA,AUS)

S29JL032H70-SBS1-0503GA(AZ5D:SP,MY,PH)

3636

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-9. SCHEMATIC DIAGRAM – DMB10 BOARD (2/4) –

R208

C213

R206

R209

R204

R205

R207 C203

C206 R215

C205 R214

R216

R219

C210

R224

R212 C214

C212

R230

R226

C2

11

R221

R233 C215

R234

R231 R232

C219

C221

C222

R247

R228

R227

R222

C209

C218 C220

C223

IC201

R238

R239

R2501

R246

Q2001

C2501

R236

R2502

FL401

FB401

FB402

FB403

FB404

FB405

FB406FL403

CN401

C402 C403

C217

R210

R223

R225

R220C233

R213

C208

R237

CN202

CN201

C224

C225

R243

C226

FL402

33k

0.01

10k

33k

1.2k

10k

2.7k 0.01

220p 12k

220p 15k

12k

27k

0.01

10k

10k

0.001

0.01

82k

56k

0.0

33

56k

33k

0.01

10k

15k 18k

0.01

0.1

0.1

1k

0

0

33k

0.033

1016V

1016V

0.1

FAN8036L

4.7k

4.7k

4.7k

4.7k

2SK1828TE85L

0.001

1k

1k

5P

4716V

476.3V

4716V

47k

100k

100k

10k0.0047

6.8k

0.01

1k

7P

6P

0.01

0.001

100

0.001

A12

REG02

REG01

FWD

REV

MUTE123

MUTE

TSD_M

SW+3.3V

OCSW

CKSW

LIMITSW

FCS-

FCS+

TRK+

TRK-

IOP

IOPMON

SW+5V

VREFO

RF+3.3V

SPFG

TRG-SW

OCSW1

SW+3.3V

SW+5V

GND

GND

TRK-

TRK+

FCS+

SP+

SP-

SL+

SL-

TRK-

TRK+

FCS+

FCS-

SP-

SP+

SL-

SL+

FOO

TRO

FMO

DMO

TROPENPWM

FCS-

OCSW1

CKSW1

GND

LDM-

LDM+

SP-

SP+

LIMIT

(GND)LIMIT

SL-

SL+

NC

TRG_SW

(2/4)

SWITCH

S

SW+5V

SW+3.3V

D-GND

M+9V

M-GND

SPINDLE/SLED/LOADING MOTOR DRIVE

FOCUS/TRACKING COIL DRIVE,

(Page 37)

(Page 35)

(Page 35)

(Page 37)

(Page 44)

(Page 35)

(Page 38)

(Page 35)

(Page 37)

(Page 37)

(Page 35)

(Page 39)

3737

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-10. SCHEMATIC DIAGRAM – DMB10 BOARD (3/4) – • See page 59 for Waveforms. • See page 67 for IC Pin Function Description.

R1

53

0

R1

53

1R

15

57

R134

R135

R1

44

R1

51

R1

52

R1

53

R1

55

R1

60

R1

61

R1107

R1108

R1109

R133

C1

63

C176

C120

C121

C122

C123

C124

C133 C147 C148

C1

38

C1

42

C1

54

R1

41

R1

42

C151

R1

16

8C1

30

R1

36

C1

32

C1

35

C1

37

C1

39

C1

40

C1

41

C1

43

C1

45

C1

46

C1

49

C1

50

C1

52

C1

53

R1

55

0

R1

54

9

R1

54

8

R1

54

0

R1

54

7

C1

56

R1

55

1 C1

59

C1

61

C170

C171

C172

C173

C174

C175RB104

RB103

R196

C125

C126

C128

R1

38

C127

C1

31

C1

36

C1

44

C1

55

C1

58

C1

62

C1

64

C129

RB112

C177

C160

R164

R123

C1

19

C1

16

C1

18

C1

15

C1

17

C1

14

RB108

RB107

RB111

C196

X101

R143

R1552

R1527

R1

03

R1

52

6

R1

52

4

R1542

R195

R192

R190

R189

R197

R1125

R1124

R1123

R1122

R1121

R1120

R1

50

4

R1503

FL106

FL104

R1105

R1102

R1103 R1104

R1553 R1101

R1161 R1126

R1554

R321

R4701

R4702

R4703

R4704

R4705

R4706

IC102

R146

RB113

FL105

R127

R1543

CN301

001

00

3.3k

3.3k

0

47

0

47

47

47

10

0

0

10k

0

3.3k

0.0

1

0.01

1

1

1

1

1

0.1 0.047 0.047

0.0

01

0.1

0.1

75

0k

10

0k

0.001

47

00.1

15

k

0.1

0.0

33

0.1

22

p

0.1

0.1

0.1

1 0.1

0.1

10

16

V 12

p

12

p 4.7

k

4.7

k

4.7

k

4.7

k

4.7

k 0.0

1

4.7

k 0.0

1

0.0

1

0.01

0.01

0.01

0.01

0.01

0.010

0

0

0.1

0.1

0.0015

10

0k

0.01

2.2

0.0

1

0.0

1

0.0

1

0.0

1

0.0

1

0.0

1

1016V

22

476.3V

0.01

100

0

10

16

V

0.1

10

16

V

0.1

10

16

V

0.1

22

22

0

0.0047

27MHz

100

10k

0

10

k

0 0

10k

150

150

150

150

150

0

0

0

0

0

0

0

0

10k

150

10k 10k

0 2.2k

0 10k

4.7k

0

0

0

0

0

0

0

CXD9804R

47

22

100

10k

13PA1

A2

A3

A4

A5

A6

A7

A8

A11

A12

A13

A14

A15

A1

6

A1

7

A1

8

A1

9

A2

0

A2

1

A2

2

A2

3

A2

4

A2

5

A2

6

A28

A29

A30

A31

A32

A33

A27

MSW

FWD

REV

MUTE123

MUTE

CKSW

OCSW

LIMITSW

AL

RC

K

AS

DA

TA

0

AS

DA

TA

1

AS

DA

TA

2

AS

DA

TA

4

XR

ST

SP

DIF

RF1.8

VREFO

SPFG

IOPMON

V2REFO

TSD_M

SP

DA

TA

TR

G-S

W

KR

MO

D

MIC

MR

EQ

AB

CK

AC

LK

RA4

RA5

RA6

RA7

RA8

RA9

RA11

RA0

RA1

RA2

RA3

RA10

BA0

BA1

DRCKE

DRCLK

RCS

RAS

CAS

RWE

DQM1

RD8

RD9

RD10

RD11

RD12R

D0

RD

1

RD

2

RD

3

RD

4

RD

5

RD

6

RD

7

DQ

M0

VOA

VOB

VOC

VOD

VOE

VOF

DMO

FMO

TROPENPWM

TRO

FOO

A2

A3

A4

A5

A6

A7

A8

A18

A19

A0

A1

A9

A1

0

A11

A12

A1

3

A14

A1

5

A1

6

A17

A2

0

A2

1

HD

0

HD

1

HD

2

HD

3

HD

4

HD

5

HD

6

HD

7

XW

R

XR

OM

CS

XR

D

RD13

RD15

RD14

TE

FE

PI

(3/4)

(AZ2D)

(AZ2D)

(AZ5D)

RGBSEL

WIDE

D-GND

D-GND

D-GND

D-GND

V

C

Y

Y/G

Cb/B

Cr/R

RF AMP,SERVO DSP,MPEG DECODER

DSEL(Page 35)

(Page 35)

(Page 35)

(Page 36)

(Page 35)

(Page 36)

(Page 35)(Page 35)

(Page 35)

(Page 36)

(Page 36)

(Page 35)

(Page 54)

(Page 35)(Page 38)

3838

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-11. SCHEMATIC DIAGRAM – DMB10 BOARD (4/4) – • See page 60 for IC Block Diagrams.

C308R3805

R3804 R3803

R3802R3801

R3789

R3788

R3787R3786

R3785R3784

R3783

R3782

R3781

R3777

R3776

R3775

R3774

R3773

R3772

R3771

R3769

R3767R3766

R3764R3762

R3758R3757

R3756

R3755

R3754

R3753

R3752

R3751

R3749

R3748

R3747R3746

R3745R3744

R3743

R3742

R3741

R3738R3737

R3736

R3735

R3734

R3733

R3732

R3731

R3729

R3727R3726

R3725R3724R3722

R3718R3717

R3716

R3715

R3714

R3713

R3712

R3711

R3653

R3652

R3621

R3611

R3609

R3607

R3606

R3605

R3603

R3602

R3601

R3501

R319

R314

L3602L3601

IC3771

IC3751

IC3731

IC3711

IC3601

IC301

D3602

D3601

D3502

D3501

C3784C3783

C3782C3781

C3774C3773

C3772

C3771

C3764C3763

C3762C3761

C3754C3753

C3752

C3751

C3744C3743

C3742C3741

C3734C3733

C3732

C3731

C3724C3723

C3722C3721

C3714C3713

C3712

C3711

C3708C3707

C3706C3705

C3704C3703

C3702C3701

C3610

C3609

C3608

C3607

C3606

C3603

C3602C3601

C305

C302

CN302

C3803

R3778

R3768R3763R3761

R3728R3723R3721

C3605

C306

C307

C3801

C3804

C3805

R3765

C3

62

1

C3

61

1

C301R3651

C3802

Q3801

R3779

R3759

R3739

R3719

0.11k

18k 10k

00

1k

4.7k

1k1k

4.7k3.9k

3.9k

1.5k

1.5k

1k

1k

4.7k

3.9k

3.9k

1.5k

1.5k

1k

1k1k

3.9k1.5k

4.7k1k

1k

4.7k

3.9k

3.9k

1.5k

1.5k

1k

4.7k

1k1k

4.7k3.9k

3.9k

1.5k

1.5k

4.7k1k

1k

4.7k

3.9k

3.9k

1.5k

1.5k

1k

1k1k

4.7k3.9k1.5k

4.7k1k

1k

4.7k

3.9k

3.9k

1.5k

1.5k

0

0

100

100

0

0

0

0

10k

100

100

0

0

100

NJM3414AV(TE2)

NJM3414AV(TE2)

NJM3414AV(TE2)

NJM3414AV(TE2)

PCM1803DBR

AK4358VQ-L

1SS355TE-17

1SS355TE-17

1SS355TE-17

1SS355TE-17

330p330p

0.00220.0018

330p330p

0.0022

0.0018

330p330p

0.00220.0018

330p330p

0.0022

0.0018

330p330p

0.00220.0018

330p330p

0.0022

0.0018

330p330p

0.00220.0018

330p330p

0.0022

0.0018

0.10.1

0.10.1

0.10.1

0.10.1

0.1

10 16V

10 16V

0.1

0.1

0.1

0.110

0.47

0.47

1004V

4.7k

4.7k3.9k1.5k

4.7k3.9k1.5k

476.3V

1006.3V

1006.3V

1006.3V

476.3V

474V

4.7k

0.0

01

0.0

01

0.010

10

2SC2712-YG

1k

1k

1k

1k

XRST

ASDATA4

ALRCK

ASDATA2

ASDATA1

ASDATA0

SDA

SCL

GND

SPDATA

SPDIF

SW+5V

ABCK

ACLK

SW+3.3V

LO

UT1+

LO

UT1-

AR

T+

AR

T-

ALT-

ALT+

ROUT3-

ROUT3+

LOUT3-

LOUT3+

ROUT2-

ROUT2+

LOUT2-

LOUT2+

ROUT1-

ROUT1+

ART-

ART+

ALT+

ALT-

ROUT3-

ROUT3+

LOUT3+

LOUT3-

LOUT2+

LOUT2-

ROUT1-

ROUT1+

LOUT1+

LOUT1-

RT

LT

SW

FR

FL

SR

SL

RT

LT

SW

FC

SR

SL

FR

FL

FC

ROUT2-

ROUT2+D-GND

D-GND

SPDIF

Rt

Lt

SW

FC

SR

SL

FR

FL

L-IN

R-IN

(4/4)

A/D CONVERTER

(AZ5D)

D/A CONVERTER

CENTER VOLTAGE GENERATOR

(AZ5D)

MIX AMP

MIX AMP

MIX AMP

MIX AMP

VDD

VSS

VDD

VSS

VDD

VSS

VDD

VSS

17P(AZ2D)

A-GND

A-GND

A-GND

A-GND

A-GND

A-GND

A-GND

19P(AZ5D)(AZ2D)

(AZ5D)

A+5V

10µH

10µH(Page 36)

(Page 37)

(Page 35)

(Page 41)

3939

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-12. PRINTED WIRING BOARD – MS-214 BOARD –• See page 32 for Circuit Boards Location. : Uses unleaded solder.

M001(LOADING)

CN001

1-86

2-78

0-

S001

S002S001

(DISC IN/OUT)

S002(CHUCKING)

S003(TRIGGER)

S003

7 16 2

MS-214 BOARD

(11)

11

M

CDMB10BOARDCN202

A

B

C

1 2

(Page 33)

7PCN001

1TRGSW

2NC

3LDM+

4LDM-

5GND

6CKSW1

7OCSW1

M001

A

4

B

MS-214 BOARD

C

52

DMB10BOARD

(2/4)CN202

1 3

(LOADING)

(DISC IN/OUT)S001 S002

(CHUCKING)S003

(TRIGGER)

C

(Page 36)

7-13. SCHEMATIC DIAGRAM – MS-214 BOARD –

4040

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

Ref. No. LocationRef. No. Location

D1 J-5D71 G-7D72 F-7D181 F-7D182 F-7D183 F-7D261 F-3D262 F-3D321 B-7D322 B-6D391 G-4D392 G-4D393 G-4D394 G-4D395 F-6D396 F-7D397 F-7D398 F-7D399 E-4D400 G-7D951 I-6D953 J-11D954 J-12D955 J-12D981 J-11D982 J-10D983 J-10D984 J-11

IC1 I-5IC3 F-14IC101 D-12IC231 J-3IC261 E-9IC391 G-4IC401 G-6IC951 H-10IC952 J-10IC953 I-10IC954 H-13IC955 H-13IC956 H-14

Q1 J-6Q11 J-5Q12 J-5Q13 J-6Q22 G-7Q30 E-7Q31 F-10Q32 G-10Q33 F-9Q34 F-8Q35 F-8Q36 F-8Q51 J-7Q71 F-15Q73 G-14Q81 E-15Q82 F-14Q83 F-14

• Semiconductor Location

Q101 E-12Q103 D-14Q104 E-14Q140 B-11Q141 J-7Q151 D-11Q153 B-11Q154 E-14Q171 J-7Q191 J-7Q201 D-7Q251 D-7Q260 E-10Q261 E-9Q262 D-5Q263 D-5Q270 E-8Q271 E-8Q272 D-7Q273 D-6Q274 D-6Q275 D-8Q276 D-6Q277 E-8Q301 C-14Q302 E-13Q303 B-14Q311 D-14Q312 D-14Q313 D-14Q314 B-15Q315 C-15Q316 E-15Q317 D-15Q318 D-15Q321 B-7Q322 B-7Q323 B-6Q324 B-6Q326 B-6Q327 B-6Q328 B-7Q329 B-7Q341 E-11Q342 E-11Q343 E-11Q351 C-14Q352 C-14Q353 B-14Q361 B-11Q362 B-11Q363 B-10Q391 G-5Q464 E-4Q465 F-6Q951 H-14Q952 H-14Q981 J-11Q982 J-10Q983 J-9Q984 J-11

JW10

2

JW10

8

JW10

9

JW11

0

JW11

1

JW14

0

JW14

1

JW17

6

JW18

7

JW194

JW19

5

JW19

6

JW19

7

JW19

8

JW20

0

JW20

1

JW20

5

JW209

JW210

JW21

4

JW21

5

JW21

6

JW21

8

JW21

9

JW22

0

JW22

1

JW226

JW228JW229

JW23

1

JW23

2

JW23

3

JW23

4

JW23

5JW

236

JW23

7

JW23

8

JW239

JW240

JW241

JW242

JW24

5

JW24

6

JW24

7

JW24

8

JW24

9

JW25

0

JW25

1

JW25

3

JW25

4

JW25

5

JW25

6

JW25

7

JW25

8

JW26

0

JW262

JW264

JW265

JW266

JW26

7

JW268

JW27

7

JW27

8

JW290

JW291

JW294

JW296

JW297

JW298

JW29

9

JW30

0

JW308

JW309

JW310

JW31

3

JW314

JW316

JW32

0

JW32

2

JW32

3

JW32

4

JW32

5

JW32

7

JW32

8

JW32

9

JW33

0

JW33

1

JW33

2

JW33

3

JW33

4

JW33

5

JW33

6

JW33

7

JW33

8

JW34

2

JW34

3

JW34

5

JW360

JW361

JW362 JW363

JW364

JW36

5 JW37

4

JW37

5

JW39

2

JW394

JW395

JW396

JW397

JW398

JW399 JW400

JW401

JW402

JW403

JW404

JW405 JW406

JW407

JW40

8

JW40

9

JW41

0JW

413

JW414 JW415

JW421

JW423

JW426

JW427

JW435

JW43

8

JW43

9

JW446

JW447

JW45

1

JW45

2

JW461

JW471

JW47

6

JW47

7JW

478

JW480

JW481

JW482

JW483

JW484

JW485

JW486

JW487

JW488

JW48

9

JW49

0JW

491

JW49

3

JW494 JW495

JW496 JW498

JW500

JW501

JW50

3

JW50

4

JW51

0

JW51

2

JW51

3

JW515JW516

JW51

8

JW520

JW20

2

JW227

JW223

JW225

JW25

9

JW517

JW514

JW24

4

JW292

JW293

JW281

JW286

JW524

JW52

7

JW52

8

JW212

JW533

JW213

JW272

JW47

0

JW535

JW531

JW532

JW529

JW38

7

JW38

8

JW420

JW424

JW422

JW428

JW430

JW433 JW434

JW417

JW416

JW418

JW431

JW43

2

JW536

JW37

3

JW411

IC231

IC231

JW393

JW319

JW523

JW521

JW390

JW389

JW38

6

JW39

1

JW49

2

JW20

3

JW181

JW182

NO953

JW95

1

NO955

JW183

JW541

JW16

5

JW16

4JW

163

JW429

JW31

2

JW17

1

JW15

6

JW16

2

JW14

8

JW14

7

JW14

6

JW14

5

JW14

4

JW15

0

JW14

9

JW15

3

JW12

6

JW16

6

JW14

2

JW13

5

JW12

5

JW13

1

JW13

0

JW12

9

JW128

JW119

JW11

8

JW11

7

JW107

JW16

9

JW13

9

JW13

8

JW23

0

JW24

3

JW303

JW304

JW30

5

JW30

6

JW30

7

JW31

1

JW37

1

JW37

2

JW37

0

JW52

2

JW38

4

JW38

5

JW37

9

JW38

0

JW38

2

JW38

1

JW37

8

JW37

7

JW38

3

JW534

JW47

4

JW47

3

JW46

8JW

469

JW46

7

JW463

JW45

4

JW457

JW45

9

JW45

8

JW45

5

JW450

JW449

JW448

JW444

JW445

JW443

JW359

JW358

JW350

JW351

JW352

JW353

JW355

JW356

JW357

JW276

JW275

JW274

JW45

3

JW36

8

JW36

9

JW37

6

JW30

2

JW30

1JW

366 JW

367

JW273

JW271

JW269

CN20

2

JW21

7

JW206 JW222

JW10

4

JW105

JW10

1

EP903

JW11

4

JW11

3 JW11

5

JW282

JW279 JW289

JW285

JW287

JW28

8

JW284JW280

JW283

JW224JW207

JW464

JW46

5

JW462

JW154

JW19

0

JW19

2

JW208JW204

JW525

JW211

JW479

JW348

JW349

JW440

JW45

6

JW442

JW441

JW13

6

JW13

7

JW17

2

JW17

3

JW17

4

JW17

5

JW15

7

JW15

8

JW15

9

JW16

0

JW16

1

JW12

2

JW12

3

JW12

1 JW12

4JW

132

JW13

3

JW13

4

JW15

2

JW17

9

JW11

6

JW12

7

JW542

JW543

JW544

JW54

5

JW54

6

JW497

JW315

JW466

JW460

JW90

3

JW54

7

JW54

8

JW54

9

JW55

0

JW551

JW552JW553

JW55

4

JW10

3

JW27

0

JW52

6

JW35

4

JW53

9

JW12

0

JW537

JW425

D956

C14C231

C983

JW507

JW508JW519

JW419

JW412

JW557

JW558

C130

JW18

6

JW17

8

JW540

JW499

JW50

2

JW55

5JW

326

JW32

1

JW14

3

JW15

1

JW17

0

JW15

5

JW16

8

JW16

7JW106

JW11

2

JW26

1

JW189

JW19

3

JW317 JW318

JW475

JW347

CN111CN112CN113

CN304

CN30

3

C312

C957

C956

C955

C953

C952

C982

C959

C391

C93

C992

C950

IC956IC955IC954

IC95

3IC

952

IC95

1

CN10

2

CN954

CN95

2

C139

CN20

1

C361C363C364

C990

C79

C89

C77

C87

C85

C94

C101

C133

C4

Q327 Q324 Q329 Q322

C30EP

902

EP90

1

C314

C991

C33C34

C129

C35C36

C54

CN1

J101

CN302

CN301

C304 C354

C313

C390

C204

C254

C202

C252

C122

C127

C126

C116

C117

C167C166

C152

C154

C192

C159

C165

C179

C125

C102C103

C134

C104

C189

C392

C109

C115

C169

C119

C118

L301

T301BIAS OSC

C315

C352

C163

Q317Q318

L311

C171

C121

C162

C178

C164

C155

C177

C113

C114

C142

C135

C124

C183

C112

C272

C393

C276

C277

C417

Q82

C273C274C275

C302

CN103

C264

C15

C271

C132

C140

C29

C19

D953

C265

C266

C267

C270

Q983

D955

C105

CN95

1

C106

C156

CN203

C73

C235

C172

C176

C980

X11

C144

C151

C194

C201

C20

CN20

6

X401

C251

X402

C958

C951

CN401

C498

C462

C74

C75

C311

L351

C362

C241

D954

C168

CN955

CN10

0

C399

FB950

FB98

0

JW53

8

C72

C82

JW344

JW47

2

JW55

9

JW560

JW56

1

JW56

2JW

563

JW56

4

C954

JW26

3

CN101

JW185

JW33

9

JW34

0

JW437

JW51

1

C310

JW505

C32

C31

JW18

4

JW436

JW50

9

JW180

JW25

2

JW19

9

JW188

JW19

1

JW177

JW565

JW566

JW34

1

JW56

7

R246

R296

L231

C10

FB201 R120

R403

FB101

IC261

R359

D951

IC101

JR13

1

FB30

FB50FB80

C340

FB84

FB54

FB34

C150

R197

R198

R147R148

R76

C198

C148 C147

Q951

Q952

R951

Q362

Q363

R361

R362

R363

R364

R365

R366

R367

R368

R369

IC3

C70R75

C90

R85

R77

R87

R80

R90

R50

R60

R78

R88

R98

R371

R372

R373

R374

R375R376R377

R378R379R380

R381

R347

Q326 Q323 Q328 Q321

R327

R328

R329

R324

R462

R152

R325

R326

C197

R330

R331

R332

R321

R322

R323

C324

C322

D321D322

Q984

JR110

R254

Q981Q982D981D9

82D9

83

R981

R982

R983

R984

R985

C981

C984

R131

Q31

Q32

Q33Q34

C196

Q35Q36

R189

R31

R32

R33

R34

R35

R36

R37

R38

R39

R40R4

1

R42

R43R4

4

R45

R46

R47

R309

R48

R307

R356

JR132

IC1

C301

C351

Q351

Q301

R465

Q201Q251

Q311

R201

Q352

Q302

Q312 Q3

13

Q314

Q315

Q303

Q353

R351

R352

R202

R301R3

02

R311

R312

R313

R353

R303

R203

R109

R110

R111

R112

R113

R130

Q103

R161

R162 R163

R159R160

R251

R114

R121

R252

C303 C3

53

C306

C356C307

C358

R306

R357C308 C357

R304 R354

R305

R355C305 C355

R320

R319

R317

R318

R253

Q154Q104

R168

R118

R169

R119

R133

R314 R315

R316

Q316

Q81

Q71

R86

R164

R180

Q153

C131

R122R123

R129

R151R153

R154

R155

R156

R158

R174

R175

R126

R127

R128

R106R107

R108R103

R104 R105

C157C158

C160C161

C174C173

Q101

Q151

Q270R270

R102

R271C107R272

C108C110

C111

Q341 Q342

Q343

R341

R342

R343

R344

R345Q271

R273

R101

R274

R275

Q277

R291

R292 R293

Q275R285

R286R287

Q272

R278

R277

R276

R281

Q273

R280

R279

R284

Q274

R282

R283

R290

Q276

R288 R289

JR130

Q140

JR111

R234

Q11

R188

JR1

Q464

Q12

D984

R10

C253

R255

R132

Q361

R11

Q261

R204

R261

R205

C262

C203 C146

R235

JR120

C18

L1

R21

JR119 JR121 JR122 JR123

R445

R447

Q262

Q263

R262

R263

R264

R265

R266

R267

C53

Q465

C3

C16

R16

R17

R464

JR12

7

R7

Q260

C123

JR124

R1

C51

D261

IC391C1

D262

C2

C52

R53

R3

R23

R22

R444

R173

R171

R172

R8

R245

JR10

8

R20

D1R18

R9

C17

C13

C12

R469

C11

R51

C999

C141

C143

C191

C193

R446

R454 R4

57

Q13

Q171

Q141Q191

Q51

R141R1

42

R143

R144

R145

R146

D397

R191

R192

R193

R194

R195

R486

R196

R485

R187

C100

R56

D398

Q1

R484

R4

R54

C300

D181

R483

R491

R408

D400

D399

R471

JR105

R482

R481

JR112

R458

R455

D183

R463

IC401

R401

R402

R404

R405

R406

R407

R409

C200

JR109

C410

R459

C411

C412

R411R413

R417

C416R419R420

R421 R422

R424 R425

R426

R427

R428

R429R430

R260

R415R416

R480

C499

C400

R498

R494

R495

R493R492

R487

R431

R432

R433

R434

R435

R436

R437R438

R439

R440

R441

D182

R452

R497

R475

R400

R451

R490

C464

R460

R496

R472R473

Q391R4

43

R396

D396

R391

R392

R393

R394

D391

D392

D393

D394

R186

D395

R295

R27

R28

R29

Q30

R72

R73

R74

Q22

JR117

JR116

L241

R57

R58

R59

R82

R83

R92

R93

Q73

Q83

R310

R61

R71

R84

R94

R81R91

D72

D71

R19

R157

R395

C128

E

1

1

30 31

81 80

100

50

51

1

1

1 3

98

2

3

5 4

4

E

E E

E E E E

E

E

E

E

E

E

E E E

E

E

E

E

E

E

E

E

E

E E

E

E

E

E E

E

E

EE

E

E

E E

E

11 3 8

E

EE

E

E

E E E

EE

EEE

EEE E

E

(CHASSIS)

GS

D

E

E

E

E

E

E

E E

EE

E E

E

EE

(CHASSIS)

1-865-425- 11

MAIN BOARD

KEY BOARDCN1030HFL BOARD

CN1001G

TAPE MECHANISMBLOCK (DECK-B)SUPPLIED WITH THEASSEMBLED BLOCK

TS1TOUCH

SENSOR

TAPE MECHANISMBLOCK (DECK-A)SUPPLIED WITH THEASSEMBLED BLOCK

10

11

2

1

HP301(PB)

(DECK-A)

HRPE301(REC/PB/ERASE)

(DECK-B)

DMB10BOARDCN106

A

DMB10BOARDCN302

(Page 33)

E

(FOR CHECK)

(AZ2D)

AZ2D: E2/AZ5D: E2

(AZ5D: EA, AUS)

AZ2D: E2/AZ5D: E2

DVDDIGITAL

OUT

1 24 3

25

40 41

1 80

24

65

64

VIDEO/SATOUT

M901(FAN)

MM902(FAN)

M

VIDEO/SATIN

L L RR

1 213

1

3

1

3

1

3

E

E

C B

(AZ2D)

(AZ5D)

(AZ5D)

1 3

1

2

1 5

14 14 14

P S-MASTERBOARDCN502

N S-MASTERBOARDCN501

M S-MASTERBOARDCN503

(AZ5D)

(AZ5D)

(AZ5D)(AZ2D)

(AZ5D)(AZ5D)

(AZ5D)

(AZ2D)

(AZ2D)(AZ5D)

(AZ5D)

(AZ5D)

12

2021

1 8

SWITCHINGREGULATOR (1/2)

TUNERUNIT

SUPPLIEDWITH THE

ASSEMBLEDBLOCK

FM 75ΩCOAXIAL

ANTENNA

AM

(CHASSIS)

(CHASSIS)(FRONT VIEW)

PC

BDMB10BOARDCN401

K

VIDEOBOARDCN1202

FS-MASTER

BOARDNO501

J

MICBOARDCN1050

C260

1

3

1

8

A

B

C

D

E

F

G

H

I

J

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

K (AZ5D)

E

(Page 33)

(Page 55) (Page 57)

(Page 51)

(Page 46)

(Page 53)

(Page 33)

(Page 46)(Page 46)

(Page 46)

7-14. PRINTED WIRING BOARD – MAIN BOARD – • See page 32 for Circuit Boards Location. : Uses unleaded solder.

4141

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-15. SCHEMATIC DIAGRAM – MAIN BOARD (1/4) – • See page 60 for IC Block Diagrams.

R274R280 R277 R271

R266

R172

R59

R272R275R278R281

R267

R3

R11

R18R19

R21

R53

C241

R296

R293

R292

R290

R289

R287

R286

R284

R283

R264

R261R260

R252R251 R202 R201

C251 C201

L231100µH

C200

C11 C12X11

R7 R8

IC1

C10

R10

C2

C1

R1

C14

R9

C13

L1100µH

C18 R20

C16

R58

R57

C53

C52

C51

R51

C15

C54

C300

R143

R193

C143 R144

R194C193

Q141

R191

R141

C191 R192

R142C141

R145

R146

R196

R195

C144

C194

C192

C142

R54 R4

R56 R6R171

C20

C19

R23 R22R173

C172

C171

C4

Q51 Q1

D1

R295 L

241

100

µH

R246

R245

Q277 Q276 Q275 Q274 Q273 Q272 Q271 Q270

Q201Q251C265

JR1

Q191

Q13

C264

R263

R262

C267

C266

R265

R253

C252

R203

C202

Q262 Q263

C270

R270

C271C272C273C274C275C276C277

R282 R276 R273R279R285R288R291

C235

C253

C254

R255

R254

R235

R234

C262 Q260 Q261

R205

R204

C203

IC261

D261

D262

C204

CN206 CN201

C100

J101

EP903

IC231

Q11

Q12

R16 R17

C17

C231

CN1

C3

Q171

CN202

FB201

100k100k 100k 100k

100k

100k

10k 1k1k1k1k

22k

220

22

1.5k100k

4.7k

220

100010V

100k

1k

100k

1k

100k

1k

100k

1k

100k

22k

10k10k

100k2.2k 100k 2.2k

1050V

1050V

0.1

33p 27p12MHz

1k 1M

PCM2704-DBR

0.1

22

0.047

0.047

22

4716V

1.5k

11 1M

1

10k

10k

1

0.047

0.047

22

47 16V

1050V

0.1

0

0

220p 100k

100k220p

2SC5938

1k

1k

220p 100k

100k220p

1k

1k

1k

1k

10

50V

10

50V

10

50V

10

50V

2.2k 2.2k

1k 1k4.7k

4.750V

4.750V

22k 100k22k

4.750V

4.750V

10 50V

2SC5938 2SC5938

1SS355

100k2SC5938 2SC5938 2SC5938 2SC5938 2SC5938 2SC5938 2SC5938 2SC5938

2SC59382SC59384.750V

0.1

2SC5938

RT1P141C

4.750V

100k

4.7k

1050V

1050V

4.7k

1k

1050V

1k

1050V

RT1P141C RT1P141C

1050V

2.2k

1050V

1050V

1050V

1050V

1050V

1050V

1050V

2.2k 2.2k 2.2k2.2k2.2k2.2k2.2k

10 50V

0.022

10 50V

47k

47k

47k

47k

0.1

RT1N141C RT1P141C

47k

47k

0.022

BU4053BCF

1SS355

1SS355

1050V

9P 19P

0.1

4P

TOTX141L

RT1P141C

RT1N441C

47 47

0.1

100 10V

1

RT1P141C

17P

0

9

7

6

5

34

42

43

45

10

2

3

4

18

12

17

1

26

25

24

23

30

29

28

27

40

39

33

32

31

61

69

70

SL

-IN

LT

-INRT

-IN

FL

-IN

FR

-IN

SL

-OU

T

SR

-OU

T

TO

NE

L

77

48

45

38

37

40

41

39

76

SW

-OU

T

SL

SRCSW

FR

FL

RT

LT

FL

42

SL

-IN

C-O

UT

SW

-IN

SR

-IN

VRSW

SW-IN

TONER

SR-IN

46

FR

SL

SR

C SW

LT

RT

∗

∗

A-G

ND

A-G

ND

D.GND

D.OUT

3.3V

A-G

ND

R-I

N

A-G

ND

L-I

N

A-G

ND

A+5V

FL

FR

SL

SR

SW

A-G

ND

A-G

ND

SP

DIF

D-G

ND

D-G

ND

Lt

Rt

ST C

LK

ST D

IN

ST D

OU

T

ST C

E

TU

NED

L O

UT

A G

ND

R O

UT

A+9V

GND

D+

D-

XTO XTI

SSPNDCK

DT

PSEL

DOUT HID2

HID1DGND

VDD HID0

HOSTD-

D+ VCCP

PGND

ZGND

AGNDRAGNDL

VCCL VCCR

VOUTRVOUTL

VCOM

TEST1

TEST2

VBUS

VBUS

1

2

3

(1/4)

USB D/A CONVERTER

10K(AZ2D:E2/AZ5D:E2)

0(EXCEPT AZ2D:E2/AZ5D:E2)

∗R245,295

AZ2D:E2/

AZ5D:E2

Q11,12

USB CONTROL SWITCH

MUTING

MUTING

MUTING

CONTROL

SWITCH

MUTING

CONTROL

SWITCH

Q1,51

MUTING

Q201,251

MUTING

MUTING

CONTROL

SWITCH

MUTING

CONTROL

SWITCH

(AZ5D)

(AZ5D)

Q270-277

MUTING

AUDIO SELECT

SWTICH

(AZ5D)

L

R

L

R

IN

VIDEO/SAT

OUT

(CHASSIS)

(CHASSIS)

IC231

DIGITAL OPTICAL

TRANSCEIVER

(AZ2D)

AM

ANTENNA

COAXIAL

FM 75Ω

SUPPLIED WITH

THE ASSEMBLED BLOCK

(AZ5D) (AZ2D)

FC

DVD

PC

VIDEO/SAT

Q260,261

INVERTER

TUNER UNIT

DIGITAL

OUT

(Page 38)

(Page 44)

(Page 44)

(Page 43)

(Page 42)

(Page 42)

4242

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-16. SCHEMATIC DIAGRAM – MAIN BOARD (2/4) – • See page 59 for Waveforms.

R341

Q341

R345

R353

R168

R316

R318

R319R314

Q312

R311 R313

R1

01

R159

R180

R161

R164

R163

R113

R114

R110R109

R130

R343

D321

R374

Q321

R323

R331 R330R363

R362

R361

R366R365

L351

L301

R356

R306 R307

R357

R359

R102

L311100µH

R152

R119

R169

Q313

R310

Q352

Q351

Q343

Q342

R344

R347

C357

C358

C361 C363

C364

C322

C101 C1

02

C1

03

C1

04

C1

05

C115

C116

C119

C1

21

C122

C125

C126

C127

C1

28

C1

29

C1

32

C1

33

C1

39

C146

C147

C151

C152

C1

54

C165

C166C169

C189

C197

C307

C308

C313

C314

C315

R326

R325 R324

R189 R187R186

R175

R157

R156

R154

R1

20

R107

R104

Q324

Q151

D183

D182

D181

C324

C198

C183

C161

C160C158

C1

57

C148

C124

C123

C114

C113

CN301

CN302

FB50

FB30

FB80

FB34

FB54

FB84

C301

C351 C352

C302

Q301

Q302

R301

R302

R351

R352

C353

C303C304

C354

R312

C340

C310

R309

Q303

Q353

R303

R304 R354

C305 C355

R305 R355

C356

C306

T301

R332

R327R328

R329

Q323

Q329

Q322

R373

R372

R371

Q327

D322

CN303

R381

R377

R376

R375

CN304

R3

78

R379 R380

Q361 Q362

C155R1

21

C1

31

R131

R129

R132

R151

C134

Q103

IC101

C112

Q101

C109

R103

C106

C1

07

C1

08 C110

R105

C111

R369

R367

R368

R342

R108

C174

C162

R153

C156

R123 C135

R133

C173 R126

R127

C140

R128

CN100

C167

C117

C1

30

C163

C164

C178

C177 R174 C176

C179

Q311

Q315

Q314

R320

Q316

Q317

R317

C311

C312

Q318

R315

Q326

R322 R321

Q328

C362

R364

Q363

C390

R111 R106

R158

R160

HP301

R118

FB101

R147

R148

R198

R197

C196

C118

R112

C168

R162

C150

C159

R155

R188

HRPE301

Q154

Q104

Q153

R122

Q140

10k

2SC3052

10k

1k

1k

10

47

3.3k 47k

RT1N141C

10k 10k

15

k

47k

100

1k

180

330k

330k

180

1k47k

100

22k

1SS355

10k

RT1N141C

1k

2.2k 2.2k22k

100k

4.7k

22k100k

27mH

27mH

2.2k

2.2k 10k

10k

12k

47k

47k

1k

1k

RT1N141C

4.7k

2SC3624A

2SC3624A

RT1N141C

RT1N141C

10k

2.2k

330p

0.01

4.750V

4.750V

4.750V

0.0047

1050V

10

50

V 10

50

V

10

50

V

0.1

1050V

1050V

4716V

1

4.750V

100 10V

100 10V

10010V

10

50

V

0.4

7

0.0

1

0.0

1

10

50

V

0.0068

100p

10 50V

10 50V

10

50

V

1050V

1050V

4716V

1050V

100p

330p

0.01

4716V

0.01100V

0.0047

1k

2.2k 2.2k

47k 470k0

4.7k

470

5.6k

2.2k

10

k

470

2.2k

2SB1116

2SC3052

1SS355

1SS355

1SS355

0.0047

100p

2.250V

0.0022

0.0680.022

0.0

22

100p

10010V

0.1

0.39

0.47

3P

8P

0

0

0

0

0

0

330p

330p 1050V

1050V

2SC3624A

2SC3624A

4.7k

4.7k

4.7k

4.7k

330p

330p10

50V

10 50V

10k

0.1

22 50V

12k

2SC3624A

2SC3624A

1k

33k 33k

0.001 0.001

4.7k 4.7k

100p

100p

47k

2.2k2.2k

47k

RT1N141C

2SB1116

2SB1116

10k

10k

10k

2SB1116

1SS355

7P

10k

47k

22k

10k

8P

4.7

k

4.7k 4.7k

RT1P141C RT1P141C

0.1

2.2

M

22

p

2.2k

15k

27k

15k

1050V

2SC5938

M61537FP

1050V

2SC3052

1050V

2.2k

10 50V

0.0

22

0.0

22

0.068

10k

0.0022

22k

4.7k

100k

4.7k

47k

100p

1050V

2.2k

1050V

1M 150V

10k

100p 2.2k

2.2k

150V

1M

2P

150V

150V

0.0

47

0.47

0.39

0.22

0.47 4.7k 10 50V

1 50V

2SA1235

RT1N141C

RT1P141C

33

RT1N141C

RT1P137L

10k

0.0068

0.01

2SC2001

4.7k

RT1N141C

2.2k 2.2k

RT1N141C

4.7 50V

4.7k

RT1P141C

2250V

1k 5.6k

47k

1k

(PB)(DECK-A)

1k

0

2.2k

2.2k

2.2k

2.2k

0.0068

0.01

15k

0.01

15k

0.1

10 50V

10k

750

(REC/PB/ERASE)(DECK-B)

2SC5938

2SC5938

2SC5938

15k

2SC5938

34

42

43

52

30

29

28

27

40

39

33

31

26

25

24

23

48

47

56

54

53

20

21

8

79

78

32

FR-OUT

FL-OUT

79

75

67

71

72

69

70

44

A3

5

78

A2

2

A2

1

A9

7

80

91

90

RT

-IN

FR

-IN

FL

-IN

LT

-IN

68

TONEL

TONER

VRSW

A3

6

L-PB

L-REC

R-PB

E-HOT

R-REC

L-PB

R-PB

GND

GND

GND

GND

A H

AL

F

A P

LA

Y

A C

AP

M+

A T

RG

M+

M-G

ND

A S

HU

T

B P

LA

Y

R-R

EC

F-R

EC

B H

AL

F

B C

AP

M+

B T

RG

M+

M-G

ND

B S

HU

T

NC

Q311-313

MUTING CONTROL

SWITCH

Q301,302,351,352

MUTING

SWITCH

MUTING CONTROL

Q314,315

MUTING

MUTING

Q316,317

REC BIAS SWITCH

BIAS OSC BIAS

OSC

Q321,322

TRIGGER PLUNGER

DRIVE(DECK-B)

Q326,327

CAPSTAN/REEL

MOTOR DRIVE

(DECK-A)

Q323,324

TRIGGER PLUNGER

CAPSTAN/REEL

MOTOR DRIVE

(DECK-B)

Q328,329

MUTING CONTROL

SWITCH

SWITCH

MUTING

CONTROL

Q140,363

AMS DETECTAMS DETECT

Q341-343

MUTING

FEED BACK

SWITCH

MUTINGDECK A/B SELECT SWITCH,REC/PB,EQ AMP,

INPUT SELECT SWITCH,TONE CONTROL

ELECTRICAL VOLUME,BASS BOOST AMP

FEED BACK

SWITCH

(AZ2D)

(AZ5D)

(2/4)

DECK BLOCK

TAPE MECHANISM

SUPPLIED WITH

THE ASSEMBLED

BLOCK

L-CH

ERASE

R-CH

L-CH

R-CH

(DECK-A)

BLOCK

THE ASSEMBLED

SUPPLIED WITH

DECK BLOCK

TAPE MECHANISM

(DECK-B)

DRIVE(DECK-A)

MUTING

Q104,154

(Page 41)(Page 41)

(Page 44)

(Page 47)

(Page 43)

(Page 44)

4343

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-17. SCHEMATIC DIAGRAM – MAIN BOARD (3/4) – • See page 59 for Waveforms. • See page 72 for IC Pin Function Description.

R490

R491

R486

R483

R484

R485

R487

X4

01

R480

R481

R494

R472

R497

R482

R495

R496

R498

C30

C73

C74C391

C393

C399

C4

16

C417

C464

C498

CN113

D71D392 D393

D394

D395D396 D397

D398

D399

D400

IC391

Q22Q30

R27

R28

R29R72

R73

R74R393

R394

R395

R396

R400

R4

01

R4

02

R403

R4

04

R4

05

R4

06

R4

07

R4

09

R4

11 R

41

3

R415 R416

R4

17

R4

19

R4

20

R4

21

R422

R4

24

R425

R4

26

R4

27

R4

28

R4

29

R4

30

R431

R432

R433

R434

R435

R436

R437

R438

R439

R440

R441

R443

R444

R445

R446

R447

R451

R452

R4

54

R4

55

R4

57

R4

58

R4

62

R4

63

R4

65

R4

69

CN111

CN112

C400

Q465

R475

R464

R4

60

R4

59

R4

71

X402

R391

IC401

R392D391

Q391

C29

D72

C392

C999 EP902

CN401

C462

C412 C410 C411

R473

R493R492

C499

R408

100

100

100

100

100

100

100

32

.76

8K

Hz

100

100

10k

100

100

10k

10

10

1050V

4.750V

4.750V0.1

1050V

3306.3V 0

.1

33006.3V

0.1

1050V

13P

1SS3551SS355 1SS355

1SS355

1SS3551SS355 1SS355

1SS355

1SS355

1SS355

BD4828G

RT1P141CRT1P141C

4.7k

100k

22k4.7k

100k

22k22k

4.7k

220

10k

1001

00

10

0

1M

10

0

10

0

10

0

10

0

10

k

33

0k 0

10k 10k

10

k

10

0

47

k

10

0

100

10

0

100

10

0

10

0

10

0

10

0

10

0

100

100

100

100

100

100

100

100

100

100

100

100

100

47k

100

1M

1M

1M

10

0

10

0

10

0

10

0

10

k

10

0

1k

10

k

11P

5P

0.1

RT1N141C

10k

100

10

0

10

0

10

k

5MHz

10k

M30622MEP-A06FPU0

22k1SS355

2SC3052

1050V

1SS355

0.1

0.1

(CHASSIS)

4P

100 10V

0.1 18p 18p

4.7k

0.1

10k

48

47

56

54

53

52

58

59

68

67

65

64

62

63

66

72

73

69

70

61

23

25

26

27

4

90

57

1 2

56

53

54

55

5 6 73

95

94

52

28

81

A21

A22

A36

A35

59

58

67

68

82

83

33

32

31

34

24

100

84

85

86

79

78

69

60

70

80

87

91

A97

75

63

76

66

66

65

48

51

61

19

77

44

A65

61

41

40

38

39

37

71

72

50

49

45

42

46

94

95

100

5

7

6

3

24

4

81

87

82

86

83

85

84

∗ ∗

∗

IIC-CLK

IIC-DATA

D-GND

D+3.3V

D-GND

STANDBY-LED

KEY-1

KEY-2

D+3.3V

D-GND

DA

CP

CS

RESET

VP

BACK-LIGHT

SIRCS

D-GND

D-GND

D-GND

KEYOUT3

KEYOUT2

KEYOUT1

DRIVE4

DRIVE3

DRIVE2

DRIVE1

LED-GND

LED-GND

LED+9V

EVER+3.3V

D-GND

D+3.3V

RE

SE

T

X-O

UT

VS

S

X-I

N

VC

C

NM

I

XC

-OU

T

SIR

CS

AVCC

VREF

AVSS

VC

C

VS

S

BY

TE

CN

VS

S

XC

-IN

AC

-CU

T

P_

SM

_C

LK

P_

DV

D_

I_M

TK

_S

LO

T_

IN

BA

CK

LIG

HT

P_

I_M

RE

Q

P_

I_K

RM

OD

P_ID_IO_SYSRST

P_

I_D

VD

_X

IFC

S

P_

VID

EO

_M

UT

E

P_

A_

MU

TE

P_O_DVD_SO

P_I_DVD_SI

PI_DVD_SCK

ST TUNED

ST-CE

ST-DOUT

ST-DIN

ST-CLK

P_

HE

AD

PH

ON

E_

IN

P_

MIC

_IN

P_

SM

_O

TW

P_

SM

_C

S1

P_

SM

_C

S3

P_

SM

_IN

T

P_

SM

_S

D

P_

SM

_D

RV

_R

ST

P_

SM

_O

VF

P_

AM

PIC

_C

LK

P_

AM

PIC

_D

AT

A

P_

SM

_C

S2

P_

LIN

E_

MU

TIN

G

TC

AM

S I

N

TC A TRG

TC

A P

LA

Y S

W

KEY IN_2

ML

92

08

CS

ML

92

08

DA

TA

ML

92

08

CL

K

P_VACS

TAPE A SHUT

TAPE B SHUT

TAPE B HALF/REC

SPEC-IN

MODEL-IN

KEY_2

KEY_1

DRIVE1

DRIVE2

DRIVE3

DRIVE4

TC

B T

RG

TC

BIA

S

TC

PB

/RE

C

TC

RE

C M

UT

E

P_TC_AMS_MUTE

TC

LIN

E M

UT

E

TC

B C

AM

PM

L9

20

8 R

ES

ET

P_

LIN

K_

SW

PCM2704 POWER

TC A CAPM

TC

A H

AL

F

STANBYLED

DA

TA

IIC

-

TC

BP

LA

Y S

W

P_RECOUT_MUTING

HP

_M

UT

ING

US

B_

A_

DE

T

FANDRIVE

P_LINK_LFE_SW

P_

PO

WE

R_

KE

Y

P_

DIS

P_

KE

Y

NO USE NO USE

∗R472

0(AZ2D:SP,MY,PH/AZ5D:SP,MY,TH)

330(AZ2D:E3,E15/AZ5D:E3,E15)

680(AZ2D:E12/AZ5D:E12)

1K(AZ2D:EA/AZ5D:EA)

1.5K(AZ2D:AUS/AZ5D:AUS)

4.7K(AZ2D:E2,E13,KR/AZ5D:E2)

150(AZ2D:E13)

1K(AZ2D:E2/AZ5D:E2)

1.5K(AZ2D:KR)

4.7K(EXCEPT AZ2D:E2,E13,KR/AZ5D:E2)

∗R473

0(AZ2D)

150(AZ5D)

(AZ

5D

)

SYSTEM CONTROLLER

RESET SIGNAL

GENERATOR

RESET SWITCH

Q22,30

MUTING CONTROL SWITCH

(3/4)

(FOR CHECK)

TS1

TOUCH

SENSOR

KEY

KEYIN_3

IN_1

P_

SM

_D

AT

A

IIC

-C

LK

STBYRELAY

P_O_DVD_POWER

P_

AD

C_

RE

SE

T

TCC720POWER

P_

SM

_N

SP

_M

UT

ING

P_

O_

DV

D_

BU

SY

∗R492

INVERTER

(Page 58)

(Page 42)(Page 44)

(Page 41)

(Page 56)

4444

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-18. SCHEMATIC DIAGRAM – MAIN BOARD (4/4) –

D953 D954

D981

D982

D983

IC3

Q31

Q32

Q73

Q81

Q83

Q464

Q951

Q952

Q982

R32

R35

R61

R71

R76

R77

R78

R80

R83

R84

R85

R86R87

R90

R92R93

R94

R951

R981

R983

R984

R985

C70

C72

C75C77

C79

C82

C87

C89

C951C952

C953C954

C955C956

C957C958

C959

C983

C990

C991C992

D951

NO953

NO955

CN203

IC954

IC955

IC956

R98

Q82

R88

C982R982 D984C984

Q983

Q984

IC951

IC952

IC953

D956

FB950

FB980

D955

D955

C950

C980

JW903

CN951

CN952

R47 Q36

Q35

Q34

Q33

R44

R41

R38

CN102

M902

M901

CN955

CN954

EP901

CN101

C260

Q981

Q71

C94 C93

JW951

C981

R91

R81

C90

C85R60

R50

R75

R82

C31

C32

C33

C34R40

R37

R34

R31

C35R43

C36R46

R48

R45

R42

R39

R36

R33

CN103

10EDB40 10EDB40

1SS355

UDZS-6.2B

UDZS-6.8B

NJM3414AV

2SC5938

2SC5938

2SC5938

2SC5938

2SC5938

2SK1828

RT1N141C

RT1N141C

2SC3052

100k

100k

47

47

68k

100k

1k

1k

1k

2.2k

10k

68k100k

1k

100k1k

2.2k

10k

4.7k

10k

220k

10k

22p

1050V

1050V

47010V

1050V

1050V

47010V

1050V

150V

10010V

150V

47010V

150V

10010V

150V

100010V

150V

2250V

10006.3V

150V1000

6.3V

1SS355

5P

3P

13P

PQ09RD21

PQ3RD13

PQ05RD11

1k

2SD1616

1k

4.750V47k 1SS3550.01

2SD2525

RT1N141C

TA7809LS

TA7809LS

TA7804LS

10ED

B40

470016V

470016V

8P

3P

100k 2SC5938

2SC5938

2SC5938

2SC5938

100k

100k

100k

7P

(FAN)

(FAN)

2P

3P

(CHASSIS)

21P(AZ5D)19P(AZ2D)

2200p

2SC3052

2SC5938

1050V 1000

10V

0.01

47

47

22p

1050V47k

47k

10k

100k

1050V

1050V

1050V

1050V 2.2k

2.2k

2.2k

2.2k

1050V 2.2k

1050V 2.2k

1k

1k

1k

1k

1k

1k

8P

5

45

8

7

6

9

58

59

62

63

66

1

2

3

4

10

18

12

17

20

21

68

67

65

64

79

78

73

72

FR-OUT

FL-OUT

C-OUT

SR-OUT

SW-OUT

SL-OUT

49

A65

50

FL

-OU

TFR

-OU

T

48

51

52

53

54

55

56

57

58

2

1

59

60

63

65

23

27

33

25

32

31

28

26

34

19

HP-L

HP-R

HP-SW

MIC SIG

MIC GND

MIC+9V

MIC SW

HP-GND

SW+5V

D-GND

M+9V

M-GND

SW+3.3V

OCSW1

XIFCS

MREQ

D-GND

KRMOD

IFBSY

MIC

SCO

SIO

SOO

VOICE(N.C)

V+5V

VMUTE

V-GND

FAN CTRL

SCDT

SD

NSPMUTE

OVF

INIT

/OTW

SCSHIFT

D-GND

D-GND

D-GND

A-GND

A-GND

FR-OUT

FL-OUT

SW-GND

EVER+4V

ON/OFF

A-GND

A-GND

C-OUT

SR-OUT

DBFB FEEDBACK

UNREG+12V

SW-GND

UNREG+12V

SL-OUT

A-GND

SW-OUT

FAN+

FAN-

FAN+

/RST(ENABLE)

SCLATCH(CS1)

SCLATCH(CS2)

SCLATCH(CS3)

P-DOWN(AD POWER)

UNREG+7.5V

UNREG+7.5V

FAN-

FAN+

VC

GN

D

VIN +9V REGULATOR

VO

VC

GN

D

VO

VIN

+3.3V REGULATOR

VC

GN

D

VO

VIN

+5V REGULATOR

Q951,952

REGULATOR CONTROL

SWITCH

SWITCH

MUTING

MUTING

HEADPHONE AMP

RIPPLE FILTER

MUTING

MUTING

FAN MOTOR SWITCH

Q981,982

FAN MOTOR CONTROL

FAN MOTOR DRIVE

+9V REGULATOR

+9V REGULATOR

O IG

O G I

O G I

+4V REGULATOR

(AZ2D)

(AZ5D)

(AZ5D)

(AZ5D)

(4/4)

SYSRST

(AZ5D)

(AZ5D:EA,AUS)

S

3.3V_MNT

Q31-36

MUTING

D-GND

A-GND

A+9V

SWITCHING

REGULATOR

(1/2)

(Page 35)

(Page 54)

(Page 36)

(Page 41)

(Page 41)

(Page 42)

(Page 52)

(Page 42)(Page 43)

(Page 47)

(Page 47)

(Page 47)

4545

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-19. PRINTED WIRING BOARD – S-MASTER BOARD (COMPONENT SIDE) – • See page 32 for Circuit Boards Location. : Uses unleaded solder.


Ref. No. LocationD501 J-14D502 J-14D505 J-6D506 J-6D507 J-5D508 J-6D517 H-10D518 I-14D519 I-14D753 H-12D754 H-12

IC501 J-4IC502 J-8IC503 J-11IC504 I-5IC505 I-8IC506 I-11IC507 G-3IC508 G-4IC509 G-5IC512 G-11IC513 G-12IC514 J-10IC516 E-14IC517 F-14IC518 J-13IC519 G-8

Q572 B-2Q632 B-6Q661 B-7Q691 B-10Q721 B-13Q751 B-13

R682

R684

R743 Q721R742

R744

R773 Q751R772

R774R713

C714

Q691

R712

R714

R788

R789

R580

R572

R581

IC518

C575C572

C573

R577

R574

L572

L571

IC507

FL50

4

R525

R524

R588

R610

R602

R611C605

C602

C603

R607

R604

L602L601

IC508R6

40

X501

R632R631

C631 C632

C633

R637

R634

L632

C641

L631

IC509

R531

R563

R529

R528

R517

X502

R518

R521

R522

R523

R717

R546

R540

R539

R541

R570

C518

R589

R545

R564

R543

R542R5

27

C520

R533

R536

R537

R538

IC519

IC503

D501

C656 D506

D505

C655

D508

D507

L516

R791R554

R553

R561

R556

IC506

R730R722

R731

C725C722

C723

R727R724

L722

C729

L721R7

34

IC512

D753

D754

IC514

R760

R752

R751

R520

C751 C752

C753

R757R754

L752

L751

IC513

C529

R511

R560

R569

R558

R557

R600

C530

R547

R550

R551

R552

IC516

IC517

R627

C628

R512

R515

R514

C533

C532

R516

D517

R617

C629

R763

C759

C758C760C728C730

C731

C761

R764R733 L520

R510

FL50

5

L517

FB702

C659D502

C527

D519

D518L518

C794

C795

R677

R555

R685

L505

FL50

3

L506

IC505

R692

R694R6

64

R662

R695

IC502

C661

C662

C665

C668 C698

C695

C692

R696

R750

R749

C691

R691

R683

R718C684

Q661Q632

C654

R654

R652

R598 R653R597R593

R592R594

R583 R614

C611

C579

C609

R613 R644

C639

R643

C580 C578 C610 C608 C640 C638

R630

R535

R532

R647

R646

R661

R747

R748

R666

C619

IC504

R505

C508

IC501

C510

R599

C581

R584

Q572

C744

C774

C594

FL50

6

1-86

5-42

1-

11

(11)

S-MASTER BOARD (COMPONENT SIDE)

(AZ5D)

(AZ5D)

(AZ5D)

E

E

E

E

E

E

112

36

37

48

25

24

13

112

36

37

48

25

24

13

112

36

37

48

25

1011

120

24

13

1011

120

1011

1

1

3

5

4

20

1

3

1

3

1 2 3 4 5 6 7 8 9 10 11 12 13 14

A

B

C

D

E

F

G

H

I

J

K

4646

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-20. PRINTED WIRING BOARD – S-MASTER BOARD (CONDUCTOR SIDE) – • See page 32 for Circuit Boards Location. : Uses unleaded solder.

C523

C522

C528

C525

C618

C531

C534

C514

C519

C513 C596

C512

C521

C689

C702

C796

C749

C783

EP507

C793

C791C790

C620

CN50

3

L754

L753

L724

L723

C706

C707

C736

C737

C766

C767

EP504

NO507

C734 C704

NO506C600

C674

C677

C676

L694

L693

L664

L663

C696 C697 C667 C666

EP505

CN502C504

C509

C501 C595C502

C511

C599

EP501

EP506

L634

L633

L604

L603

L574

L573

C587

C586

C616

C617

C646

C647

C584

C614

C644

EP503

NO505

CN50

1

Q631

R596

R573

R579

C574

R648

C645

C650

C651

C545

C597

C537 C5

36

C547

C598

R626

R603

R609

C604

D631

R656

D503

R638

R639

C634

R645

C643

C636

R642

C637

C642

R501

C559

R506

C693 C670

D662

D692

R616

C625

C664

D661

R633

C630

D504

C626

R649

C681

C680

C743

D632

D721

C727

C732

R509

C792

C709

C505

C507

C517

R680

C649

R787

D515

Q571

C593

C592

R591

C589

C588

R590

C615

R618 R586R587

C585

C591

C590

R619

R585

D571

C621

C622

R612

D602

C607

C612

C624

C623

D601

R615

R582

D572

C577

C582

C583

R578

C576

C613

R608

C606

R650

C544

C546

C548

C543

D512

R502D511

C556

C558

R504

D514

D513

C515

C550

C557

C560

C561

C688 C687

C549

R693

C673

R665

R663C701

C700

C699 C669

R668

C663

R667

R697

C694

D691

R698

R707 R706 R679

C735

R678

C682C683C710C711

R710C713

Q692 R681

C652

R651

C653

C712

R711

C741

R740

C740

C738

C739C768

C742

R738R739R768

C771 C770

D771

R741

C627

C657

D722

R732

R765

D751

C762

C671

C672

R762

D752 C7

57

C733

R728

C726

C763

R735

R671

R672R723

C724

R746

R753

R729

C754

R759

C756

R783R758

C748C787

C785

C786C784

IC51

5

R786

C781

C747

C562

C563

C569

C782C503

C780

R562

L519

R686

C570

C535

D510

D509

C660

C526C524

D516

R508

R769

R785

R790

R796

R775

Q722

Q752 R7

93

R794 R771

C769

C772

C773R792R6

58

R657

Q657

R795

C764

C765

R770

C679

C708

C678

Q662

C648

C658

NO501

S-MASTER BOARD (CONDUCTOR SIDE)

1-865-421-

11

(11)

(CHASSIS)

(CHASSIS) (CHASSIS)

(CHASSIS)

(CHASSIS)(CHASSIS)

SWITCHINGREGULATOR

(2/2)

SP OUT BOARDCN1100S SP OUT BOARD

CN1101R SP OUT BOARDCN1102T

1EE

E

E

4 1 61 5

MAINBOARDCN952

(Page 40)

M

MAINBOARDCN101

N

(AZ5D)

1 3

1

2

5 4

MAIN BOARDCN100F MAIN BOARD

CN102P(AZ5D)

(AZ5D)

(AZ5D)

1

10

E

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15

A

B

C

D

E

F

G

H

I

J

K

E

E

(Page 40)

(Page 40) (Page 40)

(Page 53)(Page 53)(Page 53)


Ref. No. LocationD503 J-2D504 J-3D509 K-6D510 K-6D511 J-12D512 J-12D513 J-8D514 K-8D515 J-4D516 K-4D571 F-14D572 F-13D601 F-13D602 F-12D631 F-11D632 F-10D661 G-9D662 G-8D691 G-7D692 G-7D721 F-6D722 F-5D751 F-5D752 F-4D771 C-3

IC515 I-4

Q571 B-14Q631 B-10Q657 D-3Q662 B-10Q692 B-7Q722 B-3Q752 B-3

4747

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-21. SCHEMATIC DIAGRAM – S-MASTER BOARD (1/4) – • See page 59 for Waveforms. • See page 64 for IC Block Diagrams.

R515

C793

C790

C791

R509

L520

D516

R616

C528

L50510µH

R686

C531

R514

D508D507

D504 D503

D519

D518

C522

C523

D501 D502

D509

C792

C656

C629

C618

C532 C533

C529

C530

C526

C525

C524

R599R589

R504

IC502

IC501

D514

D513D510

C520

C513

C512

C519C518

FL503

CN502

CN501

CN503 IC516µPC2905T-E1

µPC2933T-E2IC517

X501

IC514

R512FL504

L506

R516

IC503

R511

R508

R570

D515

R506

C655D506D505

D511

C501

C502

D512

R501 R502

C504

C505

C508C509

R505

C595

C507

C510

C511

C517

C596C515

C514

R627

C527

C521

C619

C630

C535C534

NO501

C659

C660

1k

10010V

0.150V

10010V

0

1SS355TE-17

0

10010V

0

1050V

1M

1SS355TE-171SS355TE-17

1SS355TE-17 1SS355TE-17

1SS355TE-17

1SS355TE-17

1 50V

1 50V

1SS355TE-17 1SS355TE-17

1SS355TE-17

0.1

0.1

0.1

10 35V

10p 10p

0.1

0.1

0.1

10 35V

0.1

100

100

0

PCM1802DBR

PCM1802DBR

1SS355TE-17

1SS355TE-171SS355TE-17

0.1

150V

150V

10010V 0.1

7P

21P(AZ5D)19P(AZ2D)

10P(AZ5D)9P(AZ2D)

12.288MHz

TC7WU04F-TE12L

00

PCM1802DBR

100

0

1k

1SS355TE-17

0

0.11SS355TE-171SS355TE-17

1SS355TE-17

10 50V

1 50V

1SS355TE-17

0 0

10 50V

0.1

0.110010V

1k 10 50V

0.1

0.1

10 50V

0.1

1050V0.1

1050V

1k

0.1

1050V

0.1

0.1

0.14.750V

2P

0.1

0.1

1

10

68 9 23 4 57

16

18

11

12

13

14

15

17

LAT3

LAT2

SCDT

SCSHIFT

LAT1

SD

OTW

NSP MUTE

RESET

OVF

INIT

FAN CTRL

SCK

FAN CTRL

SCDT

SD

NSPMUTE

OVF

INIT

/OTW

SCSHIFT

D-GND

D-GND

D-GND

A-GND

A-GND

FR-OUT

FL-OUT

DBFB FEEDBACK

/RST(ENABLE)

SCLATCH(CS1)

P-DOWN(AD POWER)

GND

GND

G+12V

A-GND

30.4V

30.4V

GND

30.4V

D-GND

A+9V

A-GND

A-GND

C-OUT

SR-OUT

SL-OUT

A-GND

SW-OUT

SCLATCH(CS2)

SCLATCH(CS3)

(AZ5D)

+5V REGULATOR

I OG

OGI

+3.3V REGULATOR

CLOCK BUFFER

A/D CONVERTER

VCC

GND

A/D CONVERTER

A/D CONVERTER

(AZ5D)

(AZ5D)

(1/4)

SWITCHING

REGULATOR

(2/2)

1µH

10µH

(Page 44)

(Page 44)

(Page 49)

(Page 42)

(Page 44)

(Page 48)

4848

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-22. SCHEMATIC DIAGRAM – S-MASTER BOARD (2/4) – • See page 59 for Waveforms. • See page 62 for IC Block Diagrams.

C796

L519

R560 R561

R553

R554

R569

C749

C569

R562L516

C783

FB702

IC515

IC518

IC506

R510

R677

R685

R787

R791FL505

FL506

C794

C795

C785

C786 C787

R630

R617

R588

R564

R563

R546

R545

R539

R535

R532

R531

R529

R525

R524

R520

R518

IC505

IC504

C689

C688

C687

C599

C598

C597

C561

C560

C559

C558

C557

C550

C549

C548

C547

C546

C545

C544

C537

R523

R522

R521

R517

R528

R542

R541

R543

R551

R550

R552

C563

R557

R556

R558

R555

EP506

EP507

L518

L517

C562EP505

C628

C556

R536

R537

R538

EP501

C536C543

R533

R540

R527

R547

C747

C748

C780

C781

C782

C570C503

X502

R786

R600

C784

10010V

0 0

0

0

0

10010V

100p

00

2225V

0

MC74VHC1GU04

NJM2870F18

CXD9788AR

0

10k

10k

100

100

0.1

0.01

5p

0.001 10p

10k

10k

1k

0

0

0

0

0

10k

0

0

1k

0

0

10k

1k

CXD9788AR

CXD9788AR

10010V

0.1

0.1

10010V

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

0.1

1k

1k

1k

100

1k

1k

1k

1k

1k

1k

1k

0.1

1k

1k

1k

10k

(CHASSIS) (CHASSIS)

(CHASSIS)

0

0

0.1

(CHASSIS)

0.1

100p

1k

1k

1k

0.1100p

1k

0

100

1k

0.1

0.1

0.1

0.1

0.1

0.10.1

49.152MHz

1M

100

0.01

1

30

20

19

2

3

4

5

6

8

7

9

10

11

12

13

14

29

28

27

26

25

24

23

22

21

36

35

34

33

32

31

51

SCK

INIT

SCK

INIT

SCK

NSP MUTE

SCDT

SCSHIFT

LAT3

OVF

LAT1

SCSHIFT

SCDT

NSP MUTE

LAT2

SCSHIFT

SCDT

NSP MUTE

INIT

I

STREAM PROCESSOR STREAM PROCESSOR

STREAM PROCESSOR

+1.8V REGULATOR

CLOCK BUFFER

VI

VO

CN

T

GN

D

N.B

.

VDD

NC GND

(AZ5D)

(2/4)

(AZ5D)

1µH

(Page 50)

(Page 47)

(Page 49)

4949

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-23. SCHEMATIC DIAGRAM – S-MASTER BOARD (3/4) – • See page 61, 63 for IC Block Diagrams.

Q752

Q751

Q722

Q721

R760

Q657

D722

D721

D751

D752

D517

R757

R762

C620

R735

R732

R727

R768

R775R785 R790 R796

R751

R753

R738

L721

L751

L752

C765

C757

C762

C741

C742

C751

C735

C724

C726

C727

C733

C671

C672

R750R749

R714

R697

R695

R692

R691

R684

R679

Q691 Q661

D692

D691

D662

D661

C702C701

C694

C693

C691

C678

C667

C661

IC519

IC512

IC513

C773

C767

C756

R783

R678

C670

R698

C699

C692

NO506

R663

R693

R729

R730

R752

R758

R759

R746C763

L754

L75310µH

10µH

10µH

10µH

10µH

10µH

10µH

10µH

L724

L723

R662 R647

R661

C663

R666

C662

R748 R747

C664 R667

C666R668C669

C700

C668

C698

C697

C695

C696

R696

C681

R680

C680

R681

C682

C683

C679C677

C676

L663

C674

L664

R710

C711

C710

C713

C712

R711

C709

R707

C707

C706

R706

C708

C704

L694

L693

R712 R713 R682 R683R717 R718

C600

C684C714

R657 C658

R658

R722

R723

C722

R728

R731 C725

R724

C723

R694

R671

R672

R665

R664

R646

C673

C753

R754

C752

D753D754

C754

R765

R764

C761C760

R763

C759C758

C764

R769

C769

C768C766

C770

C771

R770

R771

C772

C657

R739

C739C737

C743

R741

C736C734 C740

R740

C738

C730 C731 R734

C732 C627

C728 C729 R733

L722 R772 R774 R773 R742 R744 R743

C744C774

NO507R789R788

D771R795

R793

R792

R794

EP504

Q662

Q692

C665

2SA1602

2SA1602

2SA1602

2SA1602

0

2SC1623

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

UDZSTE-172.7B

0

0

47016V

0

0

0

4.7k

10k10k 10k 10k

22k

100

4.7k

0.1

0.033

0.033

0.0022

0.0022

47p

0.1

0.01

1

0.033

1

0.1

0.1

00

100k

18

3.3

0

3.3

100k

4.7k

2SA1602 2SA1602

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

10016V 0.1

330p

0.033

1

0.22

47 35V

1

CXD9845M

CXD9775M

CXD9775M

0.0022

1

1

1k

4.7k

0.033

18

330p

1

4P

(CHASSIS)

100

100

100

560

560

0

100

1k1

0

100

3.3

0.033

3.3

1

0 0

330p

18

47 35V18

330p

0.033

0.1

0.1

4735V

0.1

4735V

3.3

2200p

2.7

2200p

2.7

2200p

2200p

0.221

1

220035V

2.7

2200p

2200p

2200p

2200p

2.7

0.22

4.7k

1

1

4.7k

0.22

220035V

100k 100k 100k 100k47k 47k

1050V

2.22.2

100k 2.2

0

0

100

0.1

0

22k 47p

0

0.1

0

0

0

15k

0

100

0.1

0.1

00.1

1SS355TE-171SS355TE-17

0.01

0

3.3

0.220.22

3.3

0.220.22

220035V

4.7k

0.22

0.221

0.0022

0.0022

2.7

2.7

0.0022

0.1

4.7k

0.221

0.0022

2.7

1220035V

0.0022

2.7

0.22

0.22 0.22 3.3

0.033 0.1

0.22 0.22 3.3

100k 100k 100k 100k 100k 100k

1010

5P47k47k

1SS355TE-1722k

22k

22k

3.9k

2SA1602

2SA1602

0.1

16

15

17

18

40

39

38

37

30

29

28

27

36

35

34

33

32

31

49

48

47

46

45

44

43

42

41

FRONT RCH-

FRONT RCH+

FRONT LCH-

FRONT LCH+

DIGITAL POWER AMP

DIGITAL POWER AMP

DIGITAL POWER AMP

Q661,662,691,692

OVER LOAD DETECT

OVER LOAD DETECT

Q721,722,751,752

SURR LCH+

SURR LCH-

SURR RCH+

SURR RCH-

PROTECT

DETECT

(3/4)

(AZ5D)

(Page 48)

(Page 50)

(Page 54)

(Page 54)

(Page 47)

5050

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-24. SCHEMATIC DIAGRAM – S-MASTER BOARD (4/4) – • See page 61 for IC Block Diagrams.

C622

C623

C624

C626R656

R654

R649

R644R634

R626

R619

R604

R598 R597

R587

R586

EP503

R574

R572

Q632

Q631

Q572

Q571

NO505

IC509

IC508

IC507

D632

D631

D602

D601

D572

D571

C641C640

C639C638

C634

C615

C614

C609C608

C605

C585

C584

C579

R573

C572

C574

R579 R578

R580

R581 C575

R577

C573

R602

R603

C602

C604

R609

R610

R611

R607

C603

R608

R631R632

R633

C631

C632

C633

R637

R638 R639

R640

C583

R585

C582

L571

C580 C581 R584

C621

R583C578

C577

L572

R582

C576

R596

C613

C612

R615

L601

C610 C611 R614

C607

L602

R613

R612

C606

C643

R645

C642

L631

R643

C637 R642

L632

C636

C644

L633

L634

C647

C646 R648

C648

C649

C653

C652

R651

R650

C651

C650

C645

C625

C593C589

C592

R591 R590

C590

L604

C617

C616

R618L603

C587

C586

L573

L57410µH

10µH

10µH

10µH

10µH

10µH

C654

R652 R653R593 R592

R594

C594

C588

C591

0.1

0.1

0.1

0.11k

100k

4.7k

3.30

1k

4.7k

0

47k 47k

4.7k

4.7k

(CHASSIS)

0

0

2SA1602

2SA1602

2SA1602

2SA1602

6P

CXD9775M

CXD9775M

CXD9775M

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

P6SMB39AT3

0.220.22

0.220.22

0.01

0.1

220035V

0.220.22

47p

0.1

220035V

0.22

100

0.1

0.01

100 0

560

22k 47p

00.1

0

100

0.1

0.01

100

560

22k

00.1

0

22k560

100

47p

0.1

0.1

0

0 100

0

1

0

0.033

0.22 0.22 3.3

0.1

3.30.22

0.033 0

1

1k

1

0.033

0

0.22 0.22 3.3

0.033

3.3

0

1

1

0

0.033

3.3

0.033 0

1

220035V

1

1 4.7k

0.22

0.22

2200p

2200p

2.7

2.7

2200p

2200p

0.1

0.1

2200p0.22

2200p

2.7 2.7

2200p

1

1

4.7k

1

1

2.2

100k 100k220k 220k

220k

10

0.22

2200p

19

20

26

25

24

23

22

21

40

39

38

37

49

48

47

46

45

44

43

42

41

51S

D

RES

ET

OTW

SD

FA

N C

TR

L

SW-

SW+

C+

C-

DIGITAL POWER AMP

DIGITAL POWER AMP

DIGITAL POWER AMP

Q571,572,631,632

OVER LOAD DETECT

(AZ5D)

(4/4)

(Page 48)

(Page 54)

(Page 49)

5151

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-25. PRINTED WIRING BOARD – MIC BOARD – • See page 32 for Circuit Boards Location. : Uses unleaded solder.

RV1061

C1078

EP1060

JW1066

C1080

RV1060

C1068

C1077

JW10

64

C1069

JW10

65JW10

63

JW1067

JW1062

JW10

61

JW1060

JW1059

C1062

C1060

JW1057

JW10

58 JW1006

C1073 JW1114

JW1113

JW1056

JW1050

J1050

CN1050

EP1050

J1061

C1072

J1060

JW1116

C1083

C1082

C1074

R1065

R107

1 C109

8

IC1060

R1063

C1063

R1066

C106

7

C1066

R1062

R106

0C106

4

C1071C1070

R1069

R1070

R107

3

R1072C1097

C1061

R1061

R106

4

R105

2

R105

0

JR10

51

R105

1

R107

5 C105

3

R1068

R1077

C1079C1085

R108

3

R106

7

C109

0

C1091

C109

2

R108

6

R108

5

C1088 C1089R107

6

IC1061

C109

5

R108

0D1

061

R107

9

R1081

R1082

C1086C1084R1

084

R107

8

C1087

R1074

JR1053

1-865-451-

11

(11)

MIC BOARD

(CHASSIS) (CHASSIS)

PHONES

MIC 1MIC 2

MIC LEVEL

1 8

16 9

MAINBOARDCN103

J

ECHO LEVEL

1 2 3 4 5 6 7 8 9 10 11 12 13

A

B

C

D

E

F

G

(Page 40)

5252

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

D1061

IC1060(1/2)IC1060(2/2)

J1060

J1061

R1050

R1061

R1063R1065

R1066 R1067

R1068R1070

R1071

R1072

R1073

R1074

R1075

R1080

R1081

R1082 R1083

R1084

J1050

C1053

C1060

C1062C1068

C1069

C1070

C1073

C1074

C1077

C1079

C1082C1083

C1084 C1085

C1086

C1087

R1069

R1076

JW1006

R1078

IC1061

R1079 C1092

C1

09

1

JW1

05

0 JR1051

JR1053

CN1050

C1064 R1064

C1063

C1066

C1097C1098

C1072

C1071

EP1060

R1051

R1052

C1061

R1060

R1062

C1095

C1067

RV1060

C1078

C1080

R1077RV1061

C1089

R1085

R1086

C1088

C1090

EP1050

UDZSTE-175.1B

NJM4565MNJM4565M

0

10k

10k1k

47k 100

10k100

10k

10k

100k

0

10k

120k

22k

22k 22k

47k 0.001

0.2250V

0.2250V 0.22

50V

2.250V

100p

2.250V

22010V

150V

0.022

4716V

4716V

0.068 0.0068

0.001

0.1

150k

15k

22k

M65850FP-E

220 0.0068

0.4

7

0.1

8P

(CHASSIS)

(CHASSIS)

0.001 100k

0.01

47p

0.10.1

1035V

47p

0.01

1k

1k

0.1

220p

50k

2.2 50V

150V

15k50k

0.068

22k

22k

0.001

0.47

HP

-R

HP

-L

HP

-SW

HP

-GN

D

MIC

SIG

MIC

GN

D

MIC

+9V

MIC

SW

OP

2O

UT

VC

C

CLO

CK

REF

OP

2IN

LP

F2IN

LP

F2O

UT

GN

D

CC

2

CC

1

OP

1IN

OP

1O

UT

LP

F1O

UT

LP

F1IN

NC

NC

7

8

5

612

3

4

MIC AMP

MIC LEVEL

ECHO LEVEL

DIGITAL ECHO

MIC 1

MIC 2

PHONES

(Page 44)

7-26. SCHEMATIC DIAGRAM – MIC BOARD – • See page 64 for IC Block Diagrams.

5353

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-27. PRINTED WIRING BOARDS – OUTPUT SECTION – • See page 32 for Circuit Boards Location. : Uses unleaded solder.

EP1201

C1201

C1202

C1203

C1206

C1211 C1208C1207

C1212

C1213

C1215

JW1202

C1205

JW12

01

C1214

J1202

J1201

EP1202

C1210

CN1202

CN12

01

C122

5

C122

4C1

223

FB1204

R1207

R121

1R1

209

L1201

R120

2

R120

3

C1204C1209

R1210

C1216

R1208FB12

05

C1221C1222

IC1201

R120

6

FB12

03

C1219

C1220

FB1202 R1205

C1218

R1204

FB12

01

C1217

FB1206

JW1105

JW1106

JW1107

CN11

01

JW1109

JW1110

JW1111

CN11

02

JW1112

R110

1R111

3R1

114

R110

2

L1101

JW1101

CN11

00

JW1102

L1102

R111

5

R110

3R1

104R1

116

L1104

JW1104

JW1103

L1103

JW1108

TM1101

TM1100

C112

0

C111

9

C1140

C1139

C111

7

C111

8C1

116

C111

5

C1138

C1137

C111

3

C111

4

C1148

C1147

C1146

C1145

C1144

C1143

C1142

C1141

VIDEO BOARD

1-865-453-

11

(11)

(CHASSIS)

(CHASSIS)

J1203COMPONENTVIDEO OUT

PR/CR

PB/CB

VIDEO OUT

S VIDEO OUT

Y

CY

GG

MAIN BOARDN0955

K

DMB10BOARDCN301

D13

12

21

1 3

SP OUT BOARD

1-865-452-

11

(11)

S-MASTERBOARDNO506

R

4

1

S-MASTERBOARDNO505

T

6

1

S-MASTERBOARDNO507

S

5

1

+

–

+

–

+

–

+

–

+

–

+

–

SPEAKER

S. WOOFER

FRONT L

FRONT R

CENTER

SURR L

SURR R

(AZ2D: KR)

EXCEPTAZ2D: KR

EXCEPTAZ2D: KR

(AZ5D)

1 2 3 4 5 6 7 8 9 10 11 12 13

A

B

C

D

E

F

G

H

I

J

K

(Page 33)

(Page 40)

(Page 46)

(Page 46)

(Page 46)

5454

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-28. SCHEMATIC DIAGRAM – OUTPUT SECTION –

C1201

C1202

C1203

R1202

R1203

R1210

C1207

C1208

CN1202

L120110µH

C1211

C1212

C1213

R1204

R1205

R1206

R1207

R1208

R1211

FB1201

FB1202

FB1203

FB1204

FB1205

FB1206

IC1201

C1205

C1209

C1210

C1224C1223

C1225

EP1201EP1202

CN1201

C1216

C1220

C1219C1218C1217

C1221

JW1105

JW1106

JW1107

JW1109

JW1108

JW1110

JW1111

JW1112

C1119

C1115

C1113

C1120

C1114

C1116

R1116

R1115

R1114

R1113

L1101

JW1101

R1101

L1102

R1102

JW1102

L1103

R1103

JW1103

C1118 C1117

CN1100

L1104

R1104

JW1104

C1139

C1137

C1141

C1142

C1143

C1144

C1145

C1146

C1147

C1148

CN1102

TM1100

J1203

CN1101

C1138

TM1101

C1204

C1206

C1140

C1222

J1202

R1209

C1215

C1214

J1201

1 50V

1 50V

1 50V

100

10k

10k

150V

150V

3P

1000 6.3V

1000 6.3V

1000 6.3V

75

75

75

75

75

75

0

0

0

0

0

0

MM1623BFBE

22 50V

0.1

100 10V

22p22p

0

(CHASSIS) (CHASSIS)

13P

0.1

0

22p22p22p

22p

100000p

100000p

100000p

100000p

100000p

100000p

10

10

10

10

10

10

10

100000p 100000p

5P

10

0.001

0.001

0.001

0.001

0.001

0.001

0.001

0.001

0.001

0.001

6P

2P

3P

4P

0.001

4P

0.1

1 50V

0.001

0

1P

100

1000 6.3V

1000 6.3V

FRONT RCH-

FRONT RCH+

FRONT LCH-

FRONT LCH+

SURR LCH+

SURR RCH+

SURR LCH-

SURR RCH-

C+

C-

SW+

SW-

Y/G

Y

MUTE1

YC MIX

GND1

BIAS

I/P

CLP

MUTE2GND2

GND2

GND2

GND2

S2

S1

CR IN

CB IN

CY IN

Y IN

CVBS IN

C IN

VCC1

CR OUT

CB OUT

CY OUT

Y OUT

CVBS OUT

C OUT

S-DC OUT

VCC2

RGBSEL

Cr/R

WIDE

Cb/B

D-GND

D-GND

Y

D-GND

C

D-GND

V

DSEL

VMUTE

V+5V

V-GND

PB/CB

PR/CR

COMPONENT

VIDEO OUT

VIDEO OUT

S VIDEO OUT

CENTER

S.WOOFER

SURR R

SURR L

FRONT R

FRONT L

SPEAKER

(AZ5D)

(AZ2D:KR)

EXCEPT

AZ2D:KR

AZ2D:KR

EXCEPT

VIDEO AMP,75Ω DRIVER

(Page 37)

(Page 44)

(Page 49)

(Page 49)

(Page 50)

• See page 59 for Waveforms. • See page 66 for IC Block Diagrams.

5555

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-29. PRINTED WIRING BOARDS – DISPLAY SECTION – • See page 32 for Circuit Boards Location. : Uses unleaded solder.


Ref. No. LocationD1001 B-6D1002 B-6D1003 B-6D1004 B-6D1005 B-6D1006 E-5D1007 E-3D1008 F-5D1009 F-3D1010 G-4

IC1001 B-4IC1040 G-1

Q1001 D-5Q1002 D-6Q1003 C-5Q1004 C-4Q1005 C-6

C1004

JW10

12

JW10

13

JW10

11

JW10

14

JW10

15

L100

1

JW1010

C100

1

JW1009

JW1008

JW1007

CN1001

JW10

04

JW10

03

JW1021

JW1020

JW1019

JW1018

JW1017

JW1016

JW10

30

C1012

C1011

JW10

25

JW1023JW1026

JW1028 JW1027 JW1024 JW1022

JW1029

D1007 D1006

D1008D1009

D1010

JW1001

JW1002

NO1002

JW1117 JW1033

JW1034

R100

3R100

4

D100

5

R1002

C1003

C100

5

C101

3

C101

4D1

002

D100

1

D100

3

D100

4

C1002

Q1005

R1001

R1011

R1009

R1010

R1008C1006

C1007

C1008

C1009

R1012

C1010

Q1003

R100

6

R102

3

Q1004

R100

7

R102

4

Q1002Q1001R101

3

R101

4

R101

6

R101

5

R1020

R1019R1017

R1018

R102

1

R102

2

IC1001

IC1040

NO1103

R1041 R1040

C1040

EE

E E

2

75

7640

38

37

1-865-447-

11

(11)

FL BOARD

SIRCS BOARD

1-86

5-45

0-

11

(11)

13

1

3

1

3

MAIN BOARDCN113

GD1006 – 1010(BACK LIGHT)

189

6

2734

5

T1001DC/DC

CONVERTER

1C 2C

E1B 2B

FL1001FLUORESCENT INDICATOR

TUBE

A

B

C

D

E

F

G

1 2 3 4 5 6

132

6433

(Page 40)

5656

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-30. SCHEMATIC DIAGRAM – DISPLAY SECTION –

D1001

D1002

D1003

D1004

D1005

R1002

R1006

R1007

R1023

D1006 D1007 D1008 D1009 D1010

L1001

Q1005(2/2)

Q1002

R1013 R1016 R1017R1018

R1019 R1020

R1021R1022

IC1001

R1012

FL1001

T1001

NO1103

C1010C1012

CN1001

IC1040

R1008

R1009

R1010

R1011

C1009

C1006

C1007

C1008

C1040

R1014

R1015

Q1001

Q1004

R1040

R1041

NO1002

C1014

Q1003

R1024

C1011

C1003

C1004

C1005

R1004

R1003

C1013

R1001

C1001

C1002

1SS355

1SS355

1SS355

1SS355

UDZSTE-173.9B

10k

22k

22k

10k

SELU5223C-S SELU5223C-S SELU5223C-S SELU5223C-S SELU5223C-S

CPH5504-TL-E

RT1N141C

1.5k 1.5k 1.5k1.5k

1.5k 1.5k

1.5k1.5k

ML9208

3.3k

DC/DC CONVERTER

3P

39p1050V

13P

NJL22H400

1k

1k

1k

1k

100p

0.001

100p

100p

1

1.5k

1.5k

RT1N141C

2SC3052

47

47

3P

0.01

2SC3052

10k

10 16V

0.01

4750V

0.01

100

100

0.01

2.2k

2250V

0.022

123456789

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

1 2 3 4 5 6 7 8 9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

39

40

41

42

43

44

45

46

47

48

49

50

51

52

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

53

38

55

56

57

54

D-GND

SIRCS

D+3.3V

D-GND

DA

CP

CS

RESET

VP

BACK-LIGHT

SIRCS

LED-GND

LED-GND

LED+9V

OSC

EVER+3.3V

REMOTE CONTROL RECEIVER

LED DRIVE LED DRIVE

D1006-1010

(BACK LIGHT)

GRID DRIVE

GRID DRIVE

FLUORESCENT

INDICATER

EVER+3.3V

1

2

3

4

5 6

7

8

9

DRIVER

TUBE

-1

-2

47µH

(Page 43)

• See page 59 for Waveforms. • See page 65 for IC Block Diagrams.

5757

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-31. PRINTED WIRING BOARDS – KEY SECTION – • See page 32 for Circuit Boards Location. : Uses unleaded solder.

S1032

S1031

S1035

JW1032

S1030

D1030

S1034

S1033

S1036

S1037

JW1031

S1038

S1039

CN1030

NO1031

R103

7R1

038

R103

6R1

034

R103

3R1

032

R103

5R1

031

R1030

S1041

NO1041

R103

9

KEY BOARD

1-865-449-

11

(11)

DISPLAY

DIMMER

DSGX

PROGRESSIVE

SOUND FIELD

EQ SELECT

DIRECTION

CD SYNC

z START

S1030 – 1039, 1041

MAINBOARDCN112

H

1

2

12

EJECT BOARD

1-865-448-

11

(11)

(STANDBY)

Z

A

B

C

D

E

F

G

1 2 3 4

(Page 40)

5858

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

7-32. SCHEMATIC DIAGRAM – KEY SECTION –

R1039

R1031 R1032 R1033 R1034

R1035 R1036 R1037 R1038

S1030 S1031 S1032 S1033 S1034

S1035 S1036 S1037 S1038 S1039

S1041

CN1030

D1030

NO1031 NO1041

R1030

10k

1k 2.2k 2.2k 4.7k

1k 2.2k 2.2k 4.7k

5P

SELS5223C-S

2P 2P

1k

DISPLAY

DIMMER DSGX

DIRECTION

PROGRESSIVE

D-GND

STANDBY-LED

KEY-1

KEY-2

D-GND

AD_KEY3

D_GND

SOUND FIELD

EQ SELECT

(STANDBY)

STARTCD SYNC

(Page 43)

5959

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

• Waveforms

– DMB10 Board – – MAIN Board –

1 IC102 6 (DVDRF IP)(DVD play mode)

500 mV/DIV, 200 ns/DIV

1 Vp-p

7 IC102 <x/c (YUV6)(DVD play mode)

500 mV/DIV, 20 µs/DIV

H0.9 Vp-p

20.8 µs4 Vp-p

8 IC102 <xzc (ALRCK)

2 V/DIV, 10 µs/DIV

9 IC102 <xzv (ABCK)

2 V/DIV, 100 ns/DIV

326 ns4 Vp-p

2 IC102 <z.v (YUV1)(DVD play mode)


H

1.1 Vp-p

qa IC102 <xx, (XTALO)

500 mV/DIV, 10 ns/DIV

37 ns1.1 Vp-p

3 IC102 <z.n (YUV2)(DVD play mode)


H

1 Vp-p

4 IC102 <z., (YUV3)(DVD play mode)


H1.3 Vp-p

5 IC102 <x// (YUV4)(DVD play mode)


H

1.1 Vp-p

6 IC102 <x/x (YUV5)(DVD play mode)


H0.9 Vp-p

q; IC102 <xzb (ACLK)

2 V/DIV, 20 ns/DIV

40.6 ns4 Vp-p

wa Q318 (Base)

2 V/DIV, 5 µs/DIV

10.9 µs4.6 Vp-p

ws Q318 (Collector)

5 V/DIV, 5 µs/DIV

10.9 µs15.8 Vp-p

wd IC401 qa (XC-OUT)

1 V/DIV, 10 µs/DIV

30.5 µs2.1 Vp-p

wf IC401 qd (X-OUT)

1 V/DIV, 100 ns/DIV

200 ns3 Vp-p

– S-MASTER Board – – VIDEO Board – – FL Board –

20.8 µs3.6 Vp-p

ea IC501 – 503 q; (LRCK)

2 V/DIV, 10 µs/DIV

es IC501 – 503 qa (BCK)

2 V/DIV, 100 ns/DIV

326 ns4.1 Vp-p

ed IC514 5, 7

1 V/DIV, 50 ns/DIV

82 ns3.8 Vp-p

ef IC505, 506 qf (XFSOOUT),IC515 4

1 V/DIV, 10 ns/DIV

20.4 ns

1.6 Vp-p

ra IC1201 qh (CR OUT)(DVD play mode)


H1.5 Vp-p

rs IC1201 qk (CB OUT)(DVD play mode)


H1.5 Vp-p

rd IC1201 w; (CY OUT)(DVD play mode)

1 V/DIV, 20 µs/DIV

H

2 Vp-p

rf IC1201 wa (Y OUT)(DVD play mode)

1 V/DIV, 20 µs/DIV

H

2 Vp-p

rg IC1201 wd (CVBS OUT)(DVD play mode)

1 V/DIV, 20 µs/DIV

H2.5 Vp-p

rh IC1201 wh (C OUT)(DVD play mode)

1 V/DIV, 20 µs/DIV

H

1.8 Vp-p

ta Q1005 (Base)

2 V/DIV, 5 µs/DIV

11.4 µs3.8 Vp-p

ts Q1005 (Collector)

20 V/DIV, 5 µs/DIV

11.4 µs

33.6 Vp-p

td IC1001 tl (OSC1)

2 V/DIV, 200 ns/DIV

540 ns3.7 Vp-p

6060

HCD-AZ2D/AZ5D

HCD-AZ2D/AZ5D

IC301 AK4358VQ-L

• IC Block Diagrams

– DMB10 Board –

SCF DAC DATT

SCF DAC DATT37LOUT4–38LOUT4+

SCF DAC DATT39ROUT3–40ROUT3+


SCF DAC DATT43ROUT2–44ROUT2+


SCF DAC DATT

SCF DAC DATT

47ROUT1–48ROUT1+

DSD

PCM

AUDIOI/F

8

PDN

5

DZF1

6

CAD0

3

DZF3

4

DZF2

1

LOUT

1–

2

LOUT

1+

9

BICK

10

MCL

K

11

DVDD

12

DVSS

13 SDTI414 SDTI115 SDTI216 SDTI317 LRCK

CONTROLREGISTER 18 I2C

25

DSDL

1

26

DSDR

1

33

ROUT

4+

32

ROUT

4–

27

DSDL

2

28

DSDR

2

29

DSDL

3

30

DSDR

3

19 CCLK/SCL

21 CSN/CAD120 CDTI/SDA

24 DSDR4

22 DCLK23 DSDL4

31

DIF0

7

ACKS

N

36

AVSS

35AV

DD34

VREF

H

IC3601 PCM1803DBR

DELTA-SIGMAMODULATOR

DELTA-SIGMAMODULATOR

VINL 1

VINR 2

VREF1 3VREF2 4

VCCAGND

56

BYPAS 8

TEST 9

LRCK 10

REFERENCE

× 1/64, × 1/128DECIMATION

FILTERWITH

HIGH-PASSFILTER

SERIALINTERFACE

&MODE/FORMAT

CONTROL

MODE120MODE019FMT118FMT017OSR16SCKI15VDD14DGND13DOUT12BCK11

CLOCK & TIMING CONTROL

POWERSUPPLY

PDWN 7

IC105, 107 TK11133CSCL-G

1

6

2 3

5

REG

4

VOLTAGECONTROL

COMP

VIN

GND

VOUT

CONT

ROL

GND

NOIS

EBY

PASS

– MAIN Board –

1

2

3

4

5

6

7

8

B1

B0

C.COM

CO

INH

VEE

VSS

VDD

B.COM

A.COM

A1

A0

A

B

C

C1

9

10

11

12

13

14

15

16

OPEN

OPEN

OPEN

IC261 BU4053BCF-E2

IC1 PCM2704DBR

VOUT

R

15

VCCR

16

VCCP

20

AGND

R

17

PGND

19

VCOM

18

1

XTO

2CK

3

DT

4

PSEL

5

DOUT

7

VDD

10

VBUS

13

VCCL

6

DGND

11

ZGND

12

AGND

L

14

VOUT

L

8

D–

9

D+

EEPROMINTERFACE

5V TO 3.3VVOLTAGE

REGULATORXCVR

USB SIE

D/ACONVERTER

TRACKER(SPACT)

PLL(X8)

S/PDIFENCODER

ANALOG PLL

ISO-OUTENDPOINT

CONTROLENDPOINT

HIDENDPOINT

FIFO

HOST

21

HID0

/MS

22

HID1

/MC

23

HID2

/MD

24

TEST

1

25

TEST

0

26

XTI

28

SSPN

D

27

SPIINTERFACE

POWERMANAGER

USB PROTOCOLCONTROLLER

61

HCD-AZ2D/AZ5D

– S-MASTER Board –

RESET 4

GND 1

GND 3

PWM BP 2

DREG RTN 5

GVDD 6

M3 7

M1 10M2 11

DVDD 12

DREG 8

DGND 9

DGND 14

GND 16

GND 18

PWMRECEIVER

TIMINGCONTROL

CLOCK(TCB)

SD 13

OTW 15

DIGITALREGULATOR

PROTECTIONLOGIC

OT&

UVP

DVDD LOGIC SUPPLY

LOGIC SUPPLY

DGND

PWM AP 17 PWMRECEIVER

DVDD

DGND

DREG

GVDD

DREG

GVDD B35GVDD B36

BST B33

PVDD B32PVDD B31OUT B30OUT B29

GND28

GND34

TIMINGCONTROL

CLOCK(TCB)

GATEDRIVE

HS

GVDD A20GVDD A19

BST A22

PVDD A23PVDD A24OUT A25OUT A26

GND27

GND21

GATEDRIVE

LS

GVDD

GVDD

GATEDRIVE

HS

GATEDRIVE

LS

IC507 – 509 CXD9775MIC512, 513 CXD9775M

62

HCD-AZ2D/AZ5D

12

11

10

9

8

7

6

5

4

3

VSUBC

XVSS

OUTR2

VSSR

OUTR1

VDDR

VSSL

VSSR

OUTL2

OUTL1

VSSL

VDDL

2

1

PWM

CLOCKGENERATOR

(SECONDARY)

CLOCKGENERATOR(PRIMARY)

31

29

25 OVFFLAGL

26 SFLAG

27 INIT

30S g PGAINCONTROL

INIT/MUTE

SAMPLINGRATE

CONVERTER

FILTER &LOW CUT

FILTER

LINERINTERPOLATOR∆ Σ

48XF

SOIN

47

XVDD

HPVD

DL

46 45

HPOU

TL1

HPVS

SL

44 43

HPOU

TL2

HPVD

DR

42 41

HPOU

TR1

HPVS

SR

40

HPOU

TR2

39 37

FSOC

KO

38

FSOI

13

XOVS

S

14

XFSO

OUT

15

XOVD

D

16

DVDD

17

DVSS

18

NSPM

UTE

19

SOFT

MUT

E

20

PGM

UTE

SERIALCONTROLLER

21

SCDT

22

SCSH

IFT

23

SCLA

TCH

24

OVFF

LAGR

28 MCKSEL

32 BFVDD

33 BFVSS

34 TEST

35 DVDD

36 XFSIIN

LRCKBCKDATA

IC504 – 506 CXD9788AR

5

VIN

4

VOUT

2

GND

3

NOIS

EBY

PASS

1

CONT

ROL

BANDGAPREFERENCE

THERMALPROTECTION

IC518 NJM2870F38 (TE2)

63

HCD-AZ2D/AZ5D

/OTW 2

GVDD_B 1

PROTECTIONLOGIC

GATEDRIVE

GVDD_A36

BST_A35

PVDD_A34

OUT_A33

GND32

GATEDRIVE

OVER CURRENTFAULT

OVER CURRENTFAULT

/SD 3

PWM_A 4

PWM_B 6

/RESET_AB 5

/RESET_CD 15

PWM_C 14

M1 13M2 12

GND 11

GND 8GND 9

VREG 10

OC_ZDJ 7

PROTECTION&

RESET LOGIC

OLPOTP

CB3C

TIMINGCONTROL

STUCKDETECT

STUCKDETECT

STUCKDETECT

REGULATOR

STUCKDETECT

/HIZ_LS

/OCH/OCL

/RESET

/HIZ_HS

/UVP

PROTECTIONLOGIC

GVDD_C

PWM_D 16

VDD 17

18

GATEDRIVE

BST_C27

PVDD_C26

OUT_C25

GND24

GATEDRIVE

OVER CURRENTFAULT

OVER CURRENTFAULT

TIMINGCONTROL

/HIZ_LS

/OCH/OCL

/RESET

/HIZ_HS

/UVP

PROTECTIONLOGIC

GATEDRIVE

BST_B28

PVDD_B29

OUT_B30

GND31

GATEDRIVE

OVER CURRENTFAULT

OVER CURRENTFAULT

TIMINGCONTROLTIMING

CONTROL

/HIZ_LS

/OCH/OCL

/RESET

/HIZ_HS

/UVP

PROTECTIONLOGIC

GATEDRIVE

BST_D20

GVDD_D19

PVDD_D21

OUT_D22

GND23

GATEDRIVE

OVER CURRENTFAULT

OVER CURRENTFAULT

TIMINGCONTROLTIMING

CONTROL

/HIZ_LS

/OCH/OCL

/RESET

/HIZ_HS

/UVP

PROGRAMMABLECURRENT SENSE

TEMPERATUREWARNING/ERROR

2

4/HIZ_HS

4/HIZ_LS

4/OCH

4/OCL

GVDD_DGVDD_CGVDD_BGVDD_A

VREG

4/RESET

VREG

UNDERVOLTAGE

PROTECTION

POWER-UPRESET

/UVP

GVDD_A

GVDD_D

GVDD_B

GVDD_C

VREG

IC519 CXD9845M

64

HCD-AZ2D/AZ5D

IC501 – 503 PCM1802DBR

SINGLE-END/DIFFERENTIALCONVERTER

5TH ORDERDELTA-SIGMAMODULATOR

VINL 1

SINGLE-END/DIFFERENTIALCONVERTER

VINR 2

VREF1 3

VREF2 4

5TH ORDERDELTA-SIGMAMODULATOR

REFERENCE

x16 1/64(x1/128)

DECIMATIONFILTERWITH

DC CUTFILTER

SERIALINTERFACE

&MODE/FORMAT

CONTROL

MODE120MODE019FMT118FMT017

DOUT12BCK11

OSR16SCKI15VDD14DGND13

CLOCK & TIMING CONTROLPDWN 7BYPAS 8

VCC 5AGND 6

FSYNC 9LRCK 10

POWERSUPPLY

OSCILLATOR

1/2 VCC

AUTORESET

LPF1

MAINCONTROL

A/D

20KBITSRAM

LPF2D/A

2 3 4 5 6 7 8

9101115 14 13 12

CLOCK

RESETMO

MID1 DO0

DO1

VCC

16

NC CLOC

K

REF

OP2I

N

OP2O

UT

LPF2

IN

LPF2

OUT

LPF1

IN

1

NC

LPF1

OUT

OP1O

UT

OP1I

N

CC1

CC2

GND

– MIC Board –

IC1061 M65850FP-E1

65

HCD-AZ2D/AZ5D

– FL Board –

IC1001 ML9208-03MBZ03B

64 VDD

56 VFL57 GND

1P12P2

63 DA62 CP61 CS

55 COM16

59 OSC158 OSC0

54 COM1553 COM1452 COM1351 COM1250 COM1149 COM1048 COM947 COM846 COM745 COM644 COM543 COM442 COM341 COM240 COM1

39383736353433 SEG29

SEG30SEG31SEG32SEG33SEG34SEG35

60 RESET

8 BIT SHIFTREGISTER

COMMANDDECODERPORT

DRIVER

3AD1

4AD2

ADDRIVER

5SEG16SEG27SEG38SEG49SEG510SEG611SEG712SEG813SEG914SEG1015SEG1116SEG1217SEG1318SEG1419SEG1520SEG1621SEG1722SEG1823SEG1924SEG2025SEG2126SEG2227SEG2328SEG2429SEG2530SEG2631SEG2732SEG28

SEGMENTDRIVER

ADRAM16W × 2B

CGRAM248W × 35B

DCRAM16W × 8B

ADDRESSSELECTOR

READADDRESSCOUNTER

WRITEADDRESSCOUNTER

CGRAM8W × 35B

CONTROLCIRCUIT

TIMINGGENERATOR1

OSCILLATOR

TIMINGGENERATOR2

DIGITCONTROL

DUTYCONTROL

GRIDDRIVER

66

HCD-AZ2D/AZ5D

– VIDEO Board –

IC1201 MM1623BFBE

1VCC1

2C IN

3MUTE 1

4CVBS IN

28 VCC2

23 CVBS OUT

25 S1

150kΩBIAS

12CB IN

150kΩBIAS

CLAMP

6dB

6dB

6Y IN

7GND

8BIAS

CLAMP

BIAS

6dB

9I/P

10CY IN

11CLP

13MUTE2

5YC MIX

+ 6dB–6dB

6dB

27 S-DC OUT

24 S2

LOW-PASSFILTER

21 Y OUT

22 GND2

6.75MHz75Ω

DRIVER

LOW-PASSFILTER

6.75MHz75Ω

DRIVER

20 CY OUT

75ΩDRIVER

S-DC OUTS1/S2

26 C OUTLOW-PASSFILTER

6.75MHz75Ω

DRIVER

CLAMP 150kΩBIAS

LOW-PASSFILTER

6.75MHz

LOW-PASSFILTER

13.5MHz

18 CB OUT

19 GND2

17 GND2

15 GND2

75ΩDRIVERLOW-PASS

FILTER

6.75MHz

LOW-PASSFILTER

13.5MHz

14CR IN

150kΩBIAS

16 CR OUT

75ΩDRIVERLOW-PASS

FILTER

6.75MHz

LOW-PASSFILTER

13.5MHz

6dB

6dB

67

HCD-AZ2D/AZ5D

• IC Pin Function Description

DMB10 BOARD IC102 CXD9804R (RF AMP, SERVO DSP, MPEG DECODER)

Pin No. Pin Name I/O Description

1 AGND – Ground terminal

2 DVDA I AC coupled input path A

3 DVDB I AC coupled input path B

4 DVDC I AC coupled input path C

5 DVDD I AC coupled input path D

6 DVDRFIP I AC coupled DVD RF signal input from the optical pick-up block

7 DVDRFIN I AC coupled DVD RF signal input terminal Not used

8 MA I DC coupled main-beam RF signal input A

9 MB I DC coupled main-beam RF signal input B

10 MC I DC coupled main-beam RF signal input C

11 MD I DC coupled main-beam RF signal input D

12 SA I DC coupled sub-beam RF signal input A Not used

13 SB I DC coupled sub-beam RF signal input B Not used

14 SC I DC coupled sub-beam RF signal input C Not used

15 SD I DC coupled sub-beam RF signal input D Not used

16 CDFON I CD focusing error negative input terminal Not used

17 CDFOP I CD focusing error positive input terminal Not used

18 TNI I 3 beam satellite PD signal negative input from the optical pick-up block

19 TPI I 3 beam satellite PD signal positive input from the optical pick-up block

20, 21 MDI1, MDI2 I Laser power monitor input from the optical pick-up block

22 LDO2 O Laser diode drive signal output to the optical pick-up block (for DVD)

23 LDO1 O Laser diode drive signal output to the optical pick-up block (for CD)

24 SVDD3 – Power supply terminal (+3.3V)

25 CSO O Central servo signal output terminal Not used

26 RFLVL O RFRP low pass output terminal Not used

27 SGND – Ground terminal

28 V2REFO O Reference voltage (+2.8V) output terminal Not used

29 V20 O Reference voltage (+2V) output to the optical pick-up block

30 VREFO O Reference voltage (+1.4V) output terminal

31 FEO O Focus error monitor output terminal Not used

32 TEO O Tracking error monitor output terminal Not used

33 TEZISLV O Slice level of tracking error signal output terminal Not used

34 OPOUT O Output from the internal operational amplifier Not used

35, 36 OPIN I Input to the internal operational amplifier Not used

37 DMO O Spindle motor control signal output to the motor driver

38 FMO O Sled motor control signal output to the motor driver

39 TROPENPWM O Loading motor control signal output to the motor driver

40 IOPMON I Power monitor terminal

41 TRO O Tracking coil control signal output to the coil driver

42 FOO O Focus coil control signal output to the coil driver

43 USBVSS – Ground terminal

44 USBP I/O USB communication data input/output terminal Not used

45 USBM I/O USB communication data input/output terminal Not used

46 USBVDD3 – Power supply terminal (+3.3V)

47 SPFG I Spindle motor hall sensor input from the motor driver

48 to 50 AN0 to AN2 I/O Not used

51 NAMUTE – Muting control signal output terminal Not used

52 DVDD18 – Power supply terminal (+1.8V)

68

HCD-AZ2D/AZ5D


53 to 61IOA2 to IOA8,

O Address signal output to the flash ROMIOA18, IOA19

62 DVSS – Ground terminal

63 APLLCAP – Connection terminal for an external capacitor

64 APLLVSS – Ground terminal

65 VDD3 – Power supply terminal (+3.3V)

66 IOWR O Write enable signal output to the flash ROM

67 to 72 IOA16 to IOA11 O Address signal output to the flash ROM


74 to 76 IOA10, IOA9,IOA20 O Address signal output to the flash ROM

77 IOCS O Chip select signal output to the flash ROM

78 IOA1 O Address signal output to the flash ROM

79 IOOE O Output enable signal output to the flash ROM


81 to 84 AD0 to AD3 I/O Data/address signal input/output terminal with the flash ROM


86 to 88 AD4 to AD6 I/O Data/address signal input/output terminal with the flash ROM

89 IOA21 O Address signal output to the flash ROM

90 ALE O Address latch enable signal output terminal Not used

91 AD7 I/O Data/address signal input/output terminal with the flash ROM

92, 93 IOA17, IOA0 O Address signal output to the flash ROM


95 UWR O Write enable signal output terminal Not used

96 URD O Data read enable signal output terminal Not used


98 IFSDO O Serial data output to the system controller

99 IFCK I Serial data transfer clock signal input from the system controller

100 XIFCS I Chip select signal input from the system controller

101 IFSDI I Serial data input from the system controller

102 SCL O Serial data transfer clock signal output to the EEPROM and D/A converter

103 SDA I/O Two-way data bus with the EEPROM and D/A converter

104 TRG-SW I Trigger detection switch input terminal

105 IFBSY I Busy signal input from the system controller

106 RXD IReceive data input terminal for UART communication when data writing to

flash memory

107 TXD OTransmit data output terminal for UART communication when data writing to

flash memory


109 ICE I ICE mode enable signal input terminal Not used

110 PRST I Reset signal input from the system controller “L”: reset

111 IR I IR control signal input terminal Not used

112 INT0 O Interrupt request signal output terminal Not used

113 DQM0 O Data mask signal output to the SD-RAM

114 MREQ O Muting request signal output to the system controller

115 RD7 I/O Two-way data bus with the SD-RAM


117, 118 RD6, RD5 I/O Two-way data bus with the SD-RAM


120, 121 RD4, RD3 I/O Two-way data bus with the SD-RAM


69

HCD-AZ2D/AZ5D


123 to 125 RD2 to RD0 I/O Two-way data bus with the SD-RAM



128 to 133 RD14 to RD9 I/O Two-way data bus with the SD-RAM



136 GPIO – Not used

137 DQM1 O Data mask signal output to the SD-RAM

138 RWE O Write enable signal output to the SD-RAM

139 CAS O Column address strobe signal output to the SD-RAM

140 RAS O Row address strobe signal output to the SD-RAM


142 RCS O Chip select signal output to the SD-RAM

143 BA0 O Bank address signal output to the SD-RAM


145 BA1 O Bank address signal output to the SD-RAM

146, 147 RA10, RA0 O Address signal output to the SD-RAM


149 to 151 RA1 to RA3 O Address signal output to the SD-RAM


153 RVREF – Not used

154 RCLKB – Not used


156 RCLK O Serial data transfer clock signal output to the SD-RAM

157 CKE O Clock enable signal output to the SD-RAM

158 to 160 RA11, RA9, RA8 O Address signal output to the SD-RAM


162 RA7 O Address signal output to the SD-RAM


164 to 166 RA6 to RA4 O Address signal output to the SD-RAM


168 DISC/X – Not used

169 RGB – Not used

170 XSMRST – Not used

171 WIDE O Wide control signal output to the video amplifier

172 NT – Not used


174 EUR – Not used


176 LIMSW I Limit detection switch input terminal

177 OCKSW I Disc slot in/out detection switch input terminal

178 VCLK – Not used

179 CKSW I Chucking detection switch input terminal

180 IO3 – Not used

181 TSDM O Thermal shut down signal output to the motor/coil driver


183 MUTE O Muting signal output to the motor/coil driver

184 MUTE123 O Muting signal output to the motor/coil driver

185 REV O Loading motor drive signal output to the motor driver (reverse direction)

186 FWD O Loading motor drive signal output to the motor driver (forward direction)

70

HCD-AZ2D/AZ5D


187 MSW O DVD/CD selection signal output terminal

188 DSEL O Interlace/progressive selection signal output to the video amplifier

189 DAVCC – Power supply terminal (+3.3V)

190 VREF – For bandgap reference voltage terminal

191 FS – Full scale adjustment terminal

192 YUV0 O Video data output terminal Not used

193 DAVSS – Ground terminal

194 YUV1 O Y signal output to the video amplifier

195 DAVDD – Power supply terminal (+3.3V)

196 YUV2 O Chroma signal output to the video amplifier


198 YUV3 O Video signal output to the video amplifier

199 DAVDD – Power supply terminal (+3.3V)

200 YUV4 O Chroma signal output to the video amplifier


202, 203 YUV5, YUV6 O Component video signal output to the video amplifier


205 MIC I Microphone detection signal input terminal “H”: microphone in

206 VOICE – Not used

207 KRMOD O Karaoke mode selection signal output to the system controller

208 SMSCK – Not used

209 SPDATA I SPDIF digital audio data input from the A/D converter (HCD-AZ5D only)

210 SMSDO – Not used

211 XSMCS – Not used


213 ALRCK O L/R sampling clock signal output to the D/A converter and A/D converter

214 ABCK O Bit clock signal output to the D/A converter and A/D converter

215 ACLK O Master clock signal output to the D/A converter and A/D converter


217 to 219 ASDATA0 to ASDATA2 O Audio serial data output to the D/A converter

220 XRST O Reset signal output to the D/A converter “L”: reset


222 ASDATA4 O Audio serial data output to the D/A converter


224 DWIDE – Not used

225 SPDIF O SPDIF digital audio signal output terminal (HCD-AZ2D only)

226 RFGND18 – Ground terminal

227 RFVDD18 – Power supply terminal (+1.8V)

228 XTALO O System clock output terminal (27 MHz)

229 XTALI I System clock input terminal (27 MHz)

230 JITFO O Output terminal of the RF jitter meter

231 JITFN I Input terminal of the RF jitter meter

232 PLLVSS – Ground terminal

233 IDAC – Not used

234 PLLVDD3 – Power supply terminal (+3.3V)

235 LPFON O Data PLL loop filter output terminal

236 LPFIP I Data PLL loop filter input terminal

237 LPFIN I Data PLL loop filter input terminal

238 LPFOP O Data PLL loop filter output terminal

239 VDD3 – Power supply terminal (+3.3V)

71

HCD-AZ2D/AZ5D


240 VCM – Not used

241 VSS – Ground terminal

242 VREFP – For reference voltage terminal

243 VREFN – For reference voltage terminal

244 RFVDD3 – Power supply terminal (+3.3V)

245 RFRPDC O RF ripple detect output terminal

246 RFRPAC I RF ripple detect input terminal

247 HRFZC I High frequency RF ripple zero crossing terminal

248 CRTPLP O Defect level filter capacitor connecting terminal

249 RFGND – Ground terminal

250 CEQP – Not used

251 CEQN – Not used

252 OSP O RF offset cancellation capacitor connecting terminal

253 OSN O RF offset cancellation capacitor connecting terminal

254 RFGC O RF AGC loop capacitor connecting for DVD-ROM

255 IREF I Reference current input terminal

256 AVDD3 – Power supply terminal (+3.3V)

72

HCD-AZ2D/AZ5D

MAIN BOARD IC401 M30622MEP-A06FPU0 (SYSTEM CONTROLLER)


1 P_SM_DATA O Serial data output to the stream processor

2 P_SM_CLK O Serial data transfer clock signal output to the stream processor

3 ML9208 RESET O Reset signal output to the fluorescent indicator tube driver “L”: reset

4 SIRCS I Remote control signal input from the remote control receiver

5 ML9208 DATA O Serial data output to the fluorescent indicator tube driver

6 ML9208 CS O Chip select signal output to the fluorescent indicator tube driver

7 ML9208 CLK O Serial data transfer clock signal output to the fluorescent indicator tube driver

8 BYTE I External data bus line byte selection signal input terminal Fixed at “L” in this set

9 CN VSS – Ground terminal

10 XC-IN I Sub system clock input terminal (32.768 kHz)

11 XC-OUT O Sub system clock output terminal (32.768 kHz)

12 RESET ISystem reset signal input terminal “L”: reset For several hundreds msec. after the

power supply rises, “L” is input, then it change to “H”

13 X-OUT O Main system clock output terminal (5 MHz)


15 X-IN I Main system clock input terminal (5 MHz)

16 VCC – Power supply terminal (+3.3V)

17 NMI I Non-maskable interrupt input terminal Fixed at “H” in this set

18 USB_A_DET I USB memory detection signal input terminal Not used

19P_DVD_I_ I

Disc slot in/out detection switch input terminalMTK_SLOT_IN

20 AC-CUT I AC cut on/off detection signal input terminal “L”: AC cut on

21 TC A HALF IDeck-A cassette detection signal input from the tape mechanism deck block “L”:

cassette in

22 TC A PLAY SW IDeck-A playback detection signal input from the tape mechanism deck block “L”

playback

23 P_VIDEO_MUTE O Video muting on/off control signal output to the video amplifier “H”: muting on

24 BACKLIGHT O LED drive signal output for back light “H”: LED on

25 P_I_MREQ I Muting request signal input from the servo DSP

26 P_I_DVD_XIFCS I Chip select signal input from the servo DSP

27 P_I_KRMOD I Karaoke mode selection signal input from the servo DSP

28 P_O_DVD_BUSY O Busy signal output to the servo DSP

29 IIC-CLK O IIC data transfer clock signal output terminal Not used

30 IIC-DATA O IIC data output terminal Not used

31 P_O_DVD_SO O Serial data output to the servo DSP

32 P_I_DVD_SI I Serial data input from the servo DSP

33 PI_DVD_SCK O Serial data transfer clock signal output to the servo DSP

34 P_ID_IO_SYSRST O Reset signal output to the servo DSP “L”: reset

35 TC A CAPM ODeck-A side capstan/reel motor drive signal output terminal “L”: FWD/stop, “H”:

REV

36 TC A TRG O Deck-A side trigger plunger drive signal output terminal “H”: plunger on

37 TUNED I Tuning detection signal input from the tuner unit “L”: tuned

38 ST-DOUT O PLL serial data output to the tuner unit

39 ST-CLK O PLL serial data transfer clock signal output to the tuner unit

40 ST-DIN I PLL serial data input from the tuner unit

41 ST-CE O PLL serial chip enable signal output to the tuner unit

42 P_LINK_LFE_SW O Audio signal (for sub woofer) selection signal output terminal (HCD-AZ5D only)

43 NO USE O Not used

44 P_TC_AMS_MUTE O Automatic music sensor muting on/off control signal output terminal “L”: muting on

73

HCD-AZ2D/AZ5D


45 PCM2704 POWER O USB D/A converter power on/off control signal output terminal “H”: power on

46 P_RECOUT_MUTING I Recout muting on/off control signal output terminal “L”: muting on

47 TCC720 POWER O USB memory power on/off control signal output terminal “H”: power on”

48 P_O_DVD_POWER ODVD section power on/off control signal output terminal “H”: power onDigital out

muting on/off control signal output terminal “L”: muting on (HCD-AZ2D only)

49 STBY RELAY O Relay drive signal output for the main power “H”: power on

50 FAN DRIVE O Fan motor drive signal output terminal “L”: motor on

51 P_ADC_RESET O Power down signal output to the A/D converter “L”: power down

52 P_SM_INIT O Initialize signal output to the stream processor

53 P_SM_NSP_MUTING O NSP muting on/off control signal output to the stream processor “L”: muting on

54 P_SM_OTW IOver temperature warning signal input from the digital power amplifier “L”: over

temperature

55 P_SM_SD I Shut down signal input from the digital power amplifier “L”: shut down

56 P_SM_DRV_RST O Reset signal output to the digital power amplifier “L”: reset

57 P_SM_OVF I Over flow flag input from the stream processor “L”: over flow

58 P_SM_CS1 O Chip select signal output to the stream processor (for front L-ch and R-ch)

59 P_SM_CS2 OChip select signal output to the stream processor (for center and sub woofer)

(HCD-Z5D only)

60 P_SM_CS3 OChip select signal output to the stream processor (for surround L-ch and R-ch)

(HCD-AZ5D only)

61 HP_MUTING O Headphone muting on/off control signal output terminal “L”: muting on

62 VCC – Power supply terminal (+3.3V)

63 P_HEADPHONE _IN I Headphone detection signal input terminal “H”: headphone in


65 P_MIC_IN I Microphone detection signal input terminal “H”: microphone in

66 P_LINE_MUTING O Line muting on/off control signal output terminal “L”: muting on

67 TC BIAS O Recording bias on/off control signal output terminal “H”: bias on

68 TC PB/REC O Recording/playback selection signal output terminal “L”: recording, “H”: playback

69 TC REC MUTE O Recording muting on/off control signal output terminal “L”: muting on

70 TC LINE MUTE O Playback muting on/off control signal output terminal “H”: muting on”

71 P_AMPIC_DATA O Serial data output to the electrical volume

72 P_AMPIC_CLK O Serial data transfer clock signal output to the electrical volume

73 P_DISP_KEY I Key wake up signal input terminal

74 P_POWER_KEY I Key wake up signal input terminal

75 TC AMS IN IAutomatic music sensor detection signal input terminal “L”: music is present,

“H”: music is not present

76 P_LINK_SW OAudio signal (for surround L-ch and R-ch) selection signal output terminal

(HCD-AZ5D only)

77 P_A_MUTE O CD/DVD analog muting on/off control signal output terminal “L”: muting on

78 TC B CAPM ODeck-B side capstan/reel motor drive signal output terminal “L”: FWD/stop,

“H”: REV

79 TC B TRG O Deck-B side trigger plunger drive signal output terminal “H”: plunger on

80 TC B PLAY SW IDeck-B playback detection signal input from the tape mechanism deck block

“L” playback

81, 82 KEY IN_3,KEY IN_1 I Touch sensor key input terminal

83 to 86 DRIVE1 to DRIVE 4 O Touch sensor key drive signal output terminal

87 KEY IN_2 I Touch sensor key input terminal

88 NO USE I Not used

89 P_VACS I Sound level signal for VACS input from the electrical volume

90 TAPE B SHUT I Deck-B tape reel rotating detection signal input from the tape mechanism deck block

74

HCD-AZ2D/AZ5D


91 TAPE B HALF/REC I

Deck-B cassette detection signal input from the tape mechanism deck block

“L”: cassette inRecording-proof (forward and reverse direction) detection signal input

from the tape mechanism deck block “L”: recording possible

92 SPEC-IN I Destination setting input terminal (A/D input)

93 MODEL-IN I Model setting input terminal (A/D input)

94, 95 KEY_2, KEY_1 I Key input terminal (A/D input)

96 AVSS – Ground terminal (analog system)

97 TAPE A SHUT I Deck-A tape reel rotating detection signal input from the tape mechanism deck block

98 VREF I Reference voltage (+3.3V) input terminal (analog system)

99 AVCC – Power supply terminal (+3.3V) (analog system)

100 STANDBY LED O LED drive signal output of the standby indicator “H”: LED on

75


EXPLODED VIEWS

• Items marked “*” are not stocked since theyare seldom required for routine service. Somedelay should be anticipated when orderingthese items.

• The mechanical parts with no referencenumber in the exploded views are not supplied.

• Accessories are given in the last of theelectrical parts list.

NOTE:• -XX and -X mean standardized parts, so they

may have some difference from the originalone.

• Color Indication of Appearance PartsExample:KNOB, BALANCE (WHITE) . . . (RED)

↑ ↑Parts Color Cabinet's Color

The components identified by mark0 or dotted line with mark 0 arecritical for safety.Replace only with part numberspecified.

• AbbreviationAUS : Australian modelE2 : 120V AC area in E modelE3 : 240V AC area in E modelE12 : 220-240V AC area in E model

E13 : 220-230V AC area in E model (Russian model)E15 : Iranian modelEA : Saudi Arabia modelKR : Korean model

MY : Malaysia modelPH : Philippines modelSP : Singapore modelTH : Thai model

Ref. No. Part No. Description Remark

8-1. SIDE PANEL SECTION

1

2

3

3

front panel section

top panel (TC) section

MAIN boardsection

not supplied

not supplied

#1

#1

#1

#1

#1

#1

#1

#1

#1

1 2-349-682-01 PANEL (A), SIDE2 2-349-683-01 PANEL (B), SIDE

Ref. No. Part No. Description Remark

3 4-227-843-31 SCREW (TP), FLAT HEAD#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

76

HCD-AZ2D/AZ5D

8-2. FRONT PANEL SECTION

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

51

60(including touch sensor (TS1))

52

61

53

62

54

63

55

64

56

65

57

66

58

67

59

59

59

59

59

59

59

5959

5959

59

59

59

59

59

59

59

68

69

not supplied

not supplied

not supplied

notsupplied

not supplied

not supplied

not supplied

not supplied

not supplied

not supplied(touch sensor (TS1))

not supplied(touch sensor (TS1)

included in 60)

not supplied(KEY board)

not supplied(SIRCS board)

not supplied(EJECTboard)

#2

#1

not supplied

not supplied

not supplied

not supplied

51 2-349-646-01 PLATE (TC), INDICATION52 2-349-645-01 PANEL (LID)53 2-349-647-01 LID (TC-B)54 4-238-631-01 TAPE SPRING55 2-349-654-01 LID (MIC)

56 4-231-841-01 SPRING (HEART CAM-B)57 4-231-825-01 CAM (B), HEART58 4-224-104-41 DAMPER59 3-087-053-01 +BVTP 2.6 (3CR)60 X-2025-505-1 FRONT PANEL ASSY (D)

(AZ5D: E3, E12, E15, EA, SP, MY, AUS)

60 X-2048-633-1 FRONT PANEL ASSY (2D) (AZ2D)60 X-2055-470-1 FRONT PANEL ASSY (AZ5D: TH)60 X-2059-332-1 FRONT PANEL ASSY (AZ5D: E2)

61 1-769-977-11 WIRE (FLAT TYPE) (13 CORE)62 1-828-320-11 WIRE (FLAT TYPE) (11 CORE)

63 1-469-829-11 CORE, FERRITE64 A-1091-269-A FL BOARD, COMPLETE (EXCEPT AZ5D: TH)64 A-1114-866-A FL BOARD, COMPLETE (AZ5D: TH)65 1-828-936-11 WIRE (FLAT TYPE) (5 CORE)66 1-790-378-11 WIRE (FLAT TYPE) (8 CORE)

67 1-797-175-11 DECK, MECH (CMAL1Z254A) (DECK-B)68 A-1091-273-A MIC BOARD, COMPLETE (EXCEPT AZ5D: TH)68 A-1114-870-A MIC BOARD, COMPLETE (AZ5D: TH)69 4-245-464-02 DAMPER#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

#2 7-685-853-04 SCREW +BVTT 2X6 (S)

77

HCD-AZ2D/AZ5D

8-3. TOP PANEL (TC) SECTION


101

102

103

104

105

105

105

106

105

105

105 105

107

108109 not supplied

not supplied

not supplied

not supplied

101 1-828-947-11 WIRE (FLAT TYPE) (7 CORE)102 4-238-631-01 TAPE SPRING103 2-349-658-01 LID (TC-A)104 2-349-657-01 PANEL (TC), TOP (AZ5D)104 2-349-657-11 PANEL (TC), TOP (AZ2D)

105 3-087-053-01 +BVTP 2.6 (3CR)106 1-797-174-11 DECK, MECH (CMAL5Z230) (DECK-A)107 4-231-824-01 CAM (A), HEART108 4-224-104-41 DAMPER109 4-231-836-01 SPRING (HEART CAM-A)

78

HCD-AZ2D/AZ5D

8-4. MAIN BOARD SECTION


151

152

153

154

155

(AZ2D)

(AZ5D)

156

157

not supplied

#1

#1

#1

#1

#1

#1

#1

#1

#1

#1

#3

chassis section

DMB10 boardsection

M901

151 1-773-125-11 WIRE (FLAT TYPE) (19 CORE) (AZ2D)151 1-773-160-11 WIRE (FLAT TYPE) (21 CORE) (AZ5D)152 1-828-002-11 WIRE (FLAT TYPE) (17 CORE) (AZ2D)152 1-828-361-11 WIRE (FLAT TYPE) (19 CORE) (AZ5D)153 1-400-640-11 CORE, FERRITE

154 1-828-333-11 WIRE (FLAT TYPE) (13 CORE)155 1-828-953-11 WIRE (FLAT TYPE) (9 CORE)156 A-1091-182-A MAIN BOARD, COMPLETE (AZ2D: SP, MY)156 A-1091-183-A MAIN BOARD, COMPLETE (AZ2D: E2)156 A-1091-184-A MAIN BOARD, COMPLETE (AZ2D: E13)

156 A-1091-185-A MAIN BOARD, COMPLETE (AZ5D: SP, MY)156 A-1091-186-A MAIN BOARD, COMPLETE (AZ5D: E2)156 A-1092-100-A MAIN BOARD, COMPLETE (AZ2D: AUS)156 A-1092-101-A MAIN BOARD, COMPLETE (AZ2D: EA)156 A-1092-102-A MAIN BOARD, COMPLETE (AZ2D: KR)

156 A-1092-103-A MAIN BOARD, COMPLETE (AZ5D: AUS)156 A-1092-104-A MAIN BOARD, COMPLETE (AZ5D: EA)156 A-1114-671-A MAIN BOARD, COMPLETE (AZ2D: PH)156 A-1114-680-A MAIN BOARD, COMPLETE (AZ2D: E15)156 A-1114-696-A MAIN BOARD, COMPLETE (AZ2D: E3)

156 A-1114-703-A MAIN BOARD, COMPLETE (AZ2D: E12)156 A-1114-711-A MAIN BOARD, COMPLETE (AZ5D: E15)156 A-1114-719-A MAIN BOARD, COMPLETE (AZ5D: E3)156 A-1114-745-A MAIN BOARD, COMPLETE (AZ5D: E12)156 A-1114-860-A MAIN BOARD, COMPLETE (AZ5D: TH)

157 1-693-670-11 TUNER UNIT (TM-10KR) (AZ2D: KR)157 1-693-671-11 TUNER UNIT (TM-10E) (EXCEPT AZ2D: KR)M901 1-787-099-11 FAN, DC#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3#3 7-685-871-01 SCREW +BVTT 3X6 (S)

79

HCD-AZ2D/AZ5D

8-5. DMB10 BOARD SECTION


201

202

203

204205

not supplied

#1#1

#1

CDM86-DVBU101

not supplied(VIDEO board)

201 4-247-752-01 FOOT, RUBBER202 A-1091-196-A DMB10 BOARD, COMPLETE (AZ5D: SP, MY)202 A-1091-367-A DMB10 BOARD, COMPLETE (AZ2D: SP, MY)202 A-1091-368-A DMB10 BOARD, COMPLETE (AZ2D: E2)202 A-1091-369-A DMB10 BOARD, COMPLETE (AZ2D: E13)

202 A-1091-370-A DMB10 BOARD, COMPLETE (AZ5D: E2)202 A-1092-116-A DMB10 BOARD, COMPLETE (AZ2D: AUS)202 A-1092-117-A DMB10 BOARD, COMPLETE (AZ2D: EA)202 A-1092-118-A DMB10 BOARD, COMPLETE (AZ2D: KR)202 A-1092-119-A DMB10 BOARD, COMPLETE (AZ5D: AUS)

202 A-1092-120-A DMB10 BOARD, COMPLETE (AZ5D: EA)202 A-1114-673-A DMB10 BOARD, COMPLETE (AZ2D: PH)

202 A-1114-682-A DMB10 BOARD, COMPLETE (AZ2D: E15)202 A-1114-698-A DMB10 BOARD, COMPLETE (AZ2D: E3)202 A-1114-705-A DMB10 BOARD, COMPLETE (AZ2D: E12)

202 A-1114-713-A DMB10 BOARD, COMPLETE (AZ5D: E15)202 A-1114-721-A DMB10 BOARD, COMPLETE (AZ5D: E3)202 A-1114-747-A DMB10 BOARD, COMPLETE (AZ5D: E12)202 A-1114-910-A DMB10 BOARD, COMPLETE (AZ5D: TH)203 1-828-304-11 WIRE (FLAT TYPE) (7 CORE)

204 1-400-640-11 CORE, FERRITE205 1-828-329-11 WIRE (FLAT TYPE) (13 CORE)#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

80

HCD-AZ2D/AZ5D

8-6. CHASSIS SECTION


251

258

252

252

252

(AZ5D)

(AZ5D)

(AZ5D)

(AZ5D)

(AZ2D)

252

253

254

255

256

257

not supplied

#5

#1

#1

#1

#1

#1

#1

#1

M902

#4

#1

#1

not supplied

not supplied

not supplied(SP OUT board)

not supplied

not supplied

notsupplied

not supplied

not supplied

251 A-1091-194-A S-MASTER BOARD, COMPLETE (AZ2D)251 A-1091-195-A S-MASTER BOARD, COMPLETE

(AZ5D: E2, E3, E12, E15, EA, SP, MY, AUS)251 A-1114-873-A S-MASTER BOARD, COMPLETE (AZ5D: TH)252 3-077-331-21 +BV 3 (3-CR)253 1-828-947-11 WIRE (FLAT TYPE) (7 CORE) (AZ5D)

0254 1-769-079-23 CORD, POWER (AZ2D: KR)0254 1-777-071-53 CORD, POWER (AZ2D: E12, E13, EA, SP, MY,

PH/AZ5D: E12, EA, SP, MY)0254 1-783-203-13 CORD, POWER (AZ2D: AUS/AZ5D: AUS)0254 1-824-642-11 CORD, POWER (WITH CONNECTOR)

(AZ5D: TH)0254 1-827-226-11 CORD, POWER

(AZ2D: E2, E3, E15/AZ5D: E2, E3, E15)

255 3-703-244-00 BUSHING (2104), CORD(EXCEPT AZ2D: E2, E3, E15/AZ5D: E2, E3, E15)

* 255 3-703-571-12 BUSHING (S) (4516), CORD(AZ2D: E2, E3, E15/AZ5D: E2, E3, E15)

256 1-500-497-11 FILTER, CLAMP (FERRITE CORE)0257 1-468-896-11 REGULATOR, SWITCHING

(AZ2D: E12, KR, AUS)0257 1-468-897-11 REGULATOR, SWITCHING

(AZ2D: E2, E3, E13, E15, EA, SP, MY, PH)

0257 1-468-898-11 REGULATOR, SWITCHING(AZ5D: E12, TH, AUS)

0257 1-468-899-11 REGULATOR, SWITCHING(AZ5D: E2, E3, E15, EA, SP, MY)

258 1-500-386-11 FILTER, CLAMP (FERRITE CORE)M902 1-787-331-21 FAN, D.C. (AZ5D)#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

#4 7-685-650-79 SCREW +BVTP 3X16 TYPE2 IT-3#5 7-685-647-79 SCREW +BVTP 3X10 TYPE2 TT (B)

81

HCD-AZ2D/AZ5D

8-7. DVD MECHANISM DECK SECTION-1(CDM86-DVBU101)

353

356

353359

352

354

357(including sled motor, spindle motor)

354

352

358

not supplied

not supplied

not supplied(spindle motor)

not supplied(sled motor)

not supplied

DVD mechanism deck section-2

355

351

351 4-245-639-01 LEVER (CL UP2)352 3-087-599-01 INSULATOR SCREW353 3-088-752-01 FLOATING SCREW (+PTPWH M2.6)354 2-634-618-01 INSULATOR355 2-023-068-01 TAPPING +B 2.6X8


356 A-1114-646-A MD (AU) ASSY0357 8-820-291-02 OPTICAL PICK-UP BLOCK KHM-310CAB/C2RP

(Including sled motor, spindle motor)358 1-828-771-11 WIRE (FLAT TYPE) (24 CORE)359 2-023-066-01 TAPPING +B 2X6

82

HCD-AZ2D/AZ5D


DVD mechanism section-3

410

402

410 410

409

408

401407

406

405

404

403

DVD mechanism section-4

not supplied(MS-214 board)

M001

#6

401 3-088-752-01 FLOATING SCREW (+PTPWH M2.6)402 2-023-648-01 TAPPING +B 2X10403 4-245-653-01 BELT (MOT)404 4-245-662-02 PULLEY (GEAR)405 4-245-646-01 GEAR (IDL-F)

406 4-245-644-01 GEAR (IDL-D)


407 4-245-645-01 GEAR (IDL-E)408 4-246-203-01 LEVER (RELEASE)409 4-245-630-01 LEVER (SW)410 2-023-068-01 TAPPING +B 2.6X8

M001 X-4955-496-1 MOTOR (PULLEY) ASSY (LOADING)#6 7-623-921-01 WASHER 1.7, NYLON

83

HCD-AZ2D/AZ5D


451

451

452

452

453

454

457

458459

460

461

not supplied

453

463

464

467

not supplied

466

not supplied

455

465

455

456456

462

451 4-245-627-01 WASHER (6-2.7-0.4)452 4-245-637-11 ROLLER, RUBBER453 4-245-649-01 GEAR (IDL-I)454 4-245-657-11 LEVER (LOADING-R)455 4-245-647-01 GEAR (IDL-G)

456 4-245-648-01 GEAR (IDL-H)457 4-245-655-01 CHASSIS (TOP)458 4-245-631-11 SPT-T (LOADING-R)459 4-245-650-01 GEAR (IDL-J)

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark460 4-245-651-11 GEAR (IDL-L)

461 4-245-640-01 GEAR (CAP)462 4-245-632-11 SPR-T (LOADING-L)463 4-245-656-11 LEVER (LOADING-L)464 3-088-752-01 FLOATING SCREW (+PTPWH M2.6)465 4-245-636-01 SPR-T CL DOWN

466 4-245-658-11 LEVER (DISC STOP)467 4-245-659-11 LEVER (DISC SENSOR)

84

HCD-AZ2D/AZ5D


not supplied

not supplied

501

502

515

505

503

507

508

509

504

506511

512

513

514

509

510

501 4-245-643-01 GEAR (IDL-C)502 X-4955-483-1 LEVER (GEAR LOADING) ASSY503 2-515-536-01 SPRING (DIR), TENSION COIL504 4-245-642-01 GEAR (IDL-B)505 4-245-814-01 LEVER (DIR FIRST)

506 2-515-534-01 SPRING (DIR BACK), TENSION COIL507 4-245-660-11 LEVER (DIR)508 4-245-641-01 GEAR (IDL-A)


509 4-245-640-01 GEAR (CAP)510 4-245-628-01 LEVER (BU LOCK)

511 4-248-206-01 WASHER (3-1-0.4)512 4-245-624-01 LEVER, CLOSE513 4-245-635-01 SPR-E LEVER CLOSE514 4-245-629-01 GEAR (BU LOCK)515 4-245-644-01 GEAR (IDL-D)

85


ELECTRICAL PARTS LIST


NOTE:• Due to standardization, replacements in the

parts list may be different from the partsspecified in the diagrams or the componentsused on the set.

• -XX and -X mean standardized parts, so theymay have some difference from the originalone.

• RESISTORSAll resistors are in ohms.METAL: Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F: nonflammable

• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.

• SEMICONDUCTORSIn each case, u: µ, for example:uA... : µA... uPA... : µPA...uPB... : µPB... uPC... : µPC...uPD... : µPD...

• CAPACITORSuF: µF

• COILSuH: µH

The components identified by mark0 or dotted line with mark 0 arecritical for safety.Replace only with part numberspecified.

When indicating parts by referencenumber, please include the board.

• AbbreviationAUS : Australian modelE2 : 120V AC area in E modelE3 : 240V AC area in E model

E12 : 220-240V AC area in E modelE13 : 220-230V AC area in E model (Russian model)E15 : Iranian model

EA : Saudi Arabia modelKR : Korean modelMY : Malaysia model

PH : Philippines modelSP : Singapore modelTH : Thai model

A-1091-196-A DMB10 BOARD, COMPLETE (AZ5D: SP, MY)A-1091-367-A DMB10 BOARD, COMPLETE (AZ2D: SP, MY)A-1091-368-A DMB10 BOARD, COMPLETE (AZ2D: E2)A-1091-369-A DMB10 BOARD, COMPLETE (AZ2D: E13)A-1091-370-A DMB10 BOARD, COMPLETE (AZ5D: E2)

A-1092-116-A DMB10 BOARD, COMPLETE (AZ2D: AUS)A-1092-117-A DMB10 BOARD, COMPLETE (AZ2D: EA)A-1092-118-A DMB10 BOARD, COMPLETE (AZ2D: KR)A-1092-119-A DMB10 BOARD, COMPLETE (AZ5D: AUS)A-1092-120-A DMB10 BOARD, COMPLETE (AZ5D: EA)

A-1114-673-A DMB10 BOARD, COMPLETE (AZ2D: PH)A-1114-682-A DMB10 BOARD, COMPLETE (AZ2D: E15)A-1114-698-A DMB10 BOARD, COMPLETE (AZ2D: E3)A-1114-705-A DMB10 BOARD, COMPLETE (AZ2D: E12)A-1114-713-A DMB10 BOARD, COMPLETE (AZ5D: E15)

A-1114-721-A DMB10 BOARD, COMPLETE (AZ5D: E3)A-1114-747-A DMB10 BOARD, COMPLETE (AZ5D: E12)A-1114-910-A DMB10 BOARD, COMPLETE (AZ5D: TH)

************

< CAPACITOR >

C101 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC102 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC105 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC106 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC108 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C109 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC112 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC113 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC114 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC115 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C116 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC117 1-124-779-00 ELECT CHIP 10uF 20% 16VC118 1-124-779-00 ELECT CHIP 10uF 20% 16VC119 1-124-779-00 ELECT CHIP 10uF 20% 16VC120 1-165-908-11 CERAMIC CHIP 1uF 10% 10V

C121 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC122 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC123 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC124 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC125 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C126 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC127 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC128 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V

C129 1-124-779-00 ELECT CHIP 10uF 20% 16VC130 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C131 1-125-838-11 CERAMIC CHIP 2.2uF 10% 6.3VC132 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC133 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC135 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC136 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C137 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC138 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC139 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC140 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC141 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C142 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC143 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC144 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC145 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC146 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C147 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC148 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC149 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC150 1-124-779-00 ELECT CHIP 10uF 20% 16VC151 1-115-416-11 CERAMIC CHIP 0.001uF 5% 25V

C152 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC153 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC154 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC155 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC156 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C158 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC159 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC160 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC161 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC162 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V



C177 1-126-205-11 ELECT CHIP 47uF 20% 6.3V

DMB10


86

HCD-AZ2D/AZ5D

C178 1-126-208-21 ELECT CHIP 47uF 20% 4VC179 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC180 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC181 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C182 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC184 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC187 1-126-208-21 ELECT CHIP 47uF 20% 4VC188 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC189 1-128-934-11 CERAMIC CHIP 0.33uF 20% 10V

C190 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC191 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC192 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC193 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC195 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16V

C196 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC203 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC205 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC206 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC208 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V


C214 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC215 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC217 1-126-204-11 ELECT CHIP 47uF 20% 16VC218 1-124-779-00 ELECT CHIP 10uF 20% 16VC219 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C220 1-124-779-00 ELECT CHIP 10uF 20% 16VC221 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC222 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC223 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC224 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V


C305 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC306 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC307 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC308 1-107-725-11 CERAMIC CHIP 0.1uF 10% 16VC402 1-126-204-11 ELECT CHIP 47uF 20% 16V

C403 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC2501 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC3601 1-117-370-11 CERAMIC CHIP 10uF 10V

(AZ5D)C3602 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V


(AZ5D)

C3604 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V(AZ5D)

C3605 1-126-205-11 ELECT CHIP 47uF 20% 6.3V(AZ5D)



C3608 1-124-779-00 ELECT CHIP 10uF 20% 16V(AZ5D)

C3609 1-124-779-00 ELECT CHIP 10uF 20% 16V(AZ5D)




C3701 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C3702 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3703 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V




(AZ5D)

C3707 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3708 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC3711 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3712 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3713 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C3714 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3721 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3722 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3723 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3724 1-162-961-11 CERAMIC CHIP 330PF 10% 50V



C3733 1-162-961-11 CERAMIC CHIP 330PF 10% 50V(AZ5D)













DMB10


87

HCD-AZ2D/AZ5D


C3771 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3772 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3773 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3774 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C3781 1-162-977-11 CERAMIC CHIP 0.0018uF 10% 50VC3782 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC3783 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3784 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC3801 1-126-206-11 ELECT CHIP 100uF 20% 6.3V

C3802 1-117-370-11 CERAMIC CHIP 10uF 10VC3803 1-126-209-11 ELECT CHIP 100uF 20% 4VC3804 1-126-205-11 ELECT CHIP 47uF 20% 6.3VC3805 1-126-208-21 ELECT CHIP 47uF 20% 4V

< CONNECTOR >

CN101 1-815-763-32 CONNECTOR, FFC/FPC 24PCN103 1-784-365-21 CONNECTOR, FFC/FPC 5P

* CN105 1-770-470-21 PIN, CONNECTOR (PC BOARD) 6PCN106 1-793-989-21 FFC/CONNECTOR, FPC (LIF (NON-ZIF)) 13P

* CN201 1-770-470-21 PIN, CONNECTOR (PC BOARD) 6P

CN202 1-784-366-21 CONNECTOR, FFC/FPC 7PCN301 1-793-989-21 FFC/CONNECTOR, FPC (LIF (NON-ZIF)) 13PCN302 1-778-691-11 CONNECTOR, FFC/FPC 19P (AZ5D)CN302 1-784-376-11 CONNECTOR, FFC/FPC 17P (AZ2D)CN401 1-779-993-11 PIN, CONNECTOR (PWB) 5P

< DIODE >

D1001 8-719-058-24 DIODE RB501V-40TE-17D3501 8-719-988-61 DIODE 1SS355TE-17D3502 8-719-988-61 DIODE 1SS355TE-17D3601 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)D3602 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)

< FERRITE BEAD >

FB111 1-414-226-21 INDUCTOR, FERRITE BEADFB112 1-414-226-21 INDUCTOR, FERRITE BEADFB113 1-414-226-21 INDUCTOR, FERRITE BEADFB114 1-414-226-21 INDUCTOR, FERRITE BEADFB115 1-414-226-21 INDUCTOR, FERRITE BEAD

FB401 1-469-324-21 FERRITE, EMI (SMD) (2012)FB402 1-469-324-21 FERRITE, EMI (SMD) (2012)FB403 1-469-324-21 FERRITE, EMI (SMD) (2012)FB404 1-469-324-21 FERRITE, EMI (SMD) (2012)FB405 1-469-324-21 FERRITE, EMI (SMD) (2012)

FB406 1-469-324-21 FERRITE, EMI (SMD) (2012)

< FILTER >

FL101 1-234-177-21 FILTER, CHIP EMIFL104 1-234-177-21 FILTER, CHIP EMIFL105 1-234-177-21 FILTER, CHIP EMIFL106 1-234-177-21 FILTER, CHIP EMIFL107 1-234-177-21 FILTER, CHIP EMI

FL108 1-234-177-21 FILTER, CHIP EMIFL401 1-234-177-21 FILTER, CHIP EMIFL402 1-233-893-21 FILTER, CHIP EMIFL403 1-234-177-21 FILTER, CHIP EMI

< IC >

IC101 6-805-728-01 IC S29JL032H70-SBS1-0503UC (AZ5D: E2)IC101 6-805-729-01 IC S29JL032H70-SBS1-0503CE

(AZ5D: E3, E12, E15, EA, AUS)IC101 6-805-730-01 IC S29JL032H70-SBS1-0503GA

(AZ5D: SP, MY, TH)IC101 6-805-733-01 IC S29JL032H70-SBS2-0503UC (AZ2D: E2)IC101 6-805-734-01 IC S29JL032H70-SBS2-0503CE

(AZ2D: E3, E12, E13, E15, EA, AUS)

IC101 6-805-735-01 IC S29JL032H70-SBS2-0503GA(AZ2D: SP, MY, KR, PH)

IC102 6-706-727-01 IC CXD9804RIC103 (Not supplied) IC BR24L64F-WE2IC104 6-706-390-11 IC HY57V641620HGTP-HDRIC105 6-702-302-01 IC TK11133CSCL-G

IC106 8-759-667-18 IC PQ018EZ01ZPHIC107 6-702-302-01 IC TK11133CSCL-GIC201 6-704-524-01 IC FAN8036LIC301 6-704-222-01 IC AK4358VQ-LIC3601 6-707-608-01 IC PCM1803DBR (AZ5D)

IC3711 8-759-359-49 IC NJM3414AV (TE2)IC3731 8-759-359-49 IC NJM3414AV (TE2) (AZ5D)IC3751 8-759-359-49 IC NJM3414AV (TE2) (AZ5D)IC3771 8-759-359-49 IC NJM3414AV (TE2)

< COIL >

L3601 1-469-555-21 INDUCTOR 10uH (AZ5D)L3602 1-469-555-21 INDUCTOR 10uH (AZ5D)

< TRANSISTOR >

Q101 6-550-008-01 FET UM6K1N-TNQ102 6-550-653-01 TRANSISTOR QST8TRQ103 8-729-027-52 TRANSISTOR DTC124EKA-T146Q2001 8-729-025-28 FET 2SK1828Q3801 8-729-230-49 TRANSISTOR 2SC2712-YG

< RESISTOR >

R101 1-216-809-11 METAL CHIP 100 5% 1/10WR103 1-216-833-11 METAL CHIP 10K 5% 1/10WR104 1-216-864-11 SHORT CHIP 0R105 1-216-833-11 METAL CHIP 10K 5% 1/10WR106 1-216-833-11 METAL CHIP 10K 5% 1/10W

R107 1-216-833-11 METAL CHIP 10K 5% 1/10WR108 1-216-857-11 METAL CHIP 1M 5% 1/10WR109 1-216-864-11 SHORT CHIP 0R110 1-216-841-11 METAL CHIP 47K 5% 1/10WR111 1-216-809-11 METAL CHIP 100 5% 1/10W

R112 1-211-977-11 METAL CHIP 22 0.5% 1/10WR113 1-211-977-11 METAL CHIP 22 0.5% 1/10WR114 1-216-845-11 METAL CHIP 100K 5% 1/10WR115 1-211-977-11 METAL CHIP 22 0.5% 1/10WR116 1-216-821-11 METAL CHIP 1K 5% 1/10W

R117 1-216-841-11 METAL CHIP 47K 5% 1/10WR118 1-216-801-11 METAL CHIP 22 5% 1/10WR120 1-216-801-11 METAL CHIP 22 5% 1/10WR121 1-216-801-11 METAL CHIP 22 5% 1/10WR123 1-216-864-11 SHORT CHIP 0

DMB10



88

HCD-AZ2D/AZ5D

R124 1-216-841-11 METAL CHIP 47K 5% 1/10WR126 1-216-864-11 SHORT CHIP 0R127 1-216-809-11 METAL CHIP 100 5% 1/10WR133 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR134 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R135 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR136 1-216-835-11 METAL CHIP 15K 5% 1/10WR138 1-216-845-11 METAL CHIP 100K 5% 1/10WR141 1-218-916-11 METAL CHIP 750K 0.5% 1/10WR142 1-216-845-11 METAL CHIP 100K 5% 1/10W

R143 1-216-809-11 METAL CHIP 100 5% 1/10W(AZ2D)

R144 1-216-864-11 SHORT CHIP 0R146 1-216-805-11 METAL CHIP 47 5% 1/10WR151 1-216-805-11 METAL CHIP 47 5% 1/10WR152 1-216-864-11 SHORT CHIP 0

R153 1-216-805-11 METAL CHIP 47 5% 1/10WR155 1-216-805-11 METAL CHIP 47 5% 1/10WR160 1-216-805-11 METAL CHIP 47 5% 1/10WR161 1-216-809-11 METAL CHIP 100 5% 1/10WR164 1-216-809-11 METAL CHIP 100 5% 1/10W

R169 1-216-833-11 METAL CHIP 10K 5% 1/10WR187 1-216-864-11 SHORT CHIP 0R189 1-218-827-11 METAL CHIP 150 0.5% 1/10WR190 1-218-827-11 METAL CHIP 150 0.5% 1/10WR191 1-216-821-11 METAL CHIP 1K 5% 1/10W

R192 1-218-827-11 METAL CHIP 150 0.5% 1/10WR193 1-216-821-11 METAL CHIP 1K 5% 1/10WR195 1-218-827-11 METAL CHIP 150 0.5% 1/10WR196 1-216-864-11 SHORT CHIP 0R197 1-218-827-11 METAL CHIP 150 0.5% 1/10W

R204 1-216-822-11 METAL CHIP 1.2K 5% 1/10WR205 1-216-833-11 METAL CHIP 10K 5% 1/10WR206 1-216-833-11 METAL CHIP 10K 5% 1/10WR207 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR208 1-216-839-11 METAL CHIP 33K 5% 1/10W

R209 1-216-839-11 METAL CHIP 33K 5% 1/10WR210 1-216-841-11 METAL CHIP 47K 5% 1/10WR212 1-216-833-11 METAL CHIP 10K 5% 1/10WR213 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10WR214 1-216-835-11 METAL CHIP 15K 5% 1/10W

R215 1-216-834-11 METAL CHIP 12K 5% 1/10WR216 1-216-834-11 METAL CHIP 12K 5% 1/10WR219 1-216-838-11 METAL CHIP 27K 5% 1/10WR220 1-216-833-11 METAL CHIP 10K 5% 1/10WR221 1-218-889-11 METAL CHIP 56K 0.5% 1/10W

R222 1-216-839-11 METAL CHIP 33K 5% 1/10WR223 1-218-895-11 METAL CHIP 100K 0.5% 1/10WR224 1-216-833-11 METAL CHIP 10K 5% 1/10WR225 1-218-895-11 METAL CHIP 100K 0.5% 1/10WR226 1-218-889-11 METAL CHIP 56K 0.5% 1/10W

R227 1-216-864-11 SHORT CHIP 0R228 1-216-864-11 SHORT CHIP 0R230 1-218-893-11 METAL CHIP 82K 0.5% 1/10WR231 1-218-875-11 METAL CHIP 15K 0.5% 1/10WR232 1-218-877-11 METAL CHIP 18K 0.5% 1/10W

R233 1-218-883-11 METAL CHIP 33K 0.5% 1/10WR234 1-216-833-11 METAL CHIP 10K 5% 1/10W

R236 1-216-821-11 METAL CHIP 1K 5% 1/10WR237 1-216-821-11 METAL CHIP 1K 5% 1/10WR238 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R239 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR243 1-216-809-11 METAL CHIP 100 5% 1/10WR246 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR247 1-216-821-11 METAL CHIP 1K 5% 1/10WR314 1-216-809-11 METAL CHIP 100 5% 1/10W

R319 1-216-864-11 SHORT CHIP 0R321 1-216-864-11 SHORT CHIP 0R1101 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1102 1-218-827-11 METAL CHIP 150 0.5% 1/10WR1103 1-216-833-11 METAL CHIP 10K 5% 1/10W

R1104 1-216-833-11 METAL CHIP 10K 5% 1/10WR1105 1-216-833-11 METAL CHIP 10K 5% 1/10WR1107 1-216-864-11 SHORT CHIP 0R1108 1-216-833-11 METAL CHIP 10K 5% 1/10WR1109 1-216-864-11 SHORT CHIP 0

R1110 1-216-826-11 METAL CHIP 2.7K 5% 1/10WR1120 1-216-864-11 SHORT CHIP 0R1121 1-216-864-11 SHORT CHIP 0R1122 1-216-864-11 SHORT CHIP 0R1123 1-216-864-11 SHORT CHIP 0

R1124 1-216-864-11 SHORT CHIP 0R1125 1-216-864-11 SHORT CHIP 0R1126 1-216-833-11 METAL CHIP 10K 5% 1/10WR1129 1-216-845-11 METAL CHIP 100K 5% 1/10WR1133 1-216-864-11 SHORT CHIP 0

R1134 1-216-864-11 SHORT CHIP 0R1150 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1151 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1152 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1161 1-216-864-11 SHORT CHIP 0

R1168 1-216-817-11 METAL CHIP 470 5% 1/10WR1502 1-216-864-11 SHORT CHIP 0R1503 1-216-864-11 SHORT CHIP 0R1504 1-216-864-11 SHORT CHIP 0R1524 1-216-864-11 SHORT CHIP 0

R1526 1-216-864-11 SHORT CHIP 0R1527 1-216-864-11 SHORT CHIP 0 (AZ5D)R1530 1-216-864-11 SHORT CHIP 0R1531 1-216-864-11 SHORT CHIP 0R1540 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1542 1-216-833-11 METAL CHIP 10K 5% 1/10WR1543 1-216-833-11 METAL CHIP 10K 5% 1/10WR1545 1-216-864-11 SHORT CHIP 0R1546 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1547 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1548 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1549 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1550 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1551 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1552 1-216-833-11 METAL CHIP 10K 5% 1/10W

(AZ2D)

R1553 1-216-864-11 SHORT CHIP 0R1554 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR1557 1-216-809-11 METAL CHIP 100 5% 1/10WR2501 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

DMB10


89

HCD-AZ2D/AZ5D

R2502 1-216-821-11 METAL CHIP 1K 5% 1/10W

R3501 1-216-864-11 SHORT CHIP 0 (AZ2D)R3601 1-216-809-11 METAL CHIP 100 5% 1/10W

(AZ5D)R3602 1-216-809-11 METAL CHIP 100 5% 1/10W

(AZ5D)R3603 1-216-833-11 METAL CHIP 10K 5% 1/10W

(AZ5D)R3605 1-216-864-11 SHORT CHIP 0 (AZ5D)

R3606 1-216-864-11 SHORT CHIP 0 (AZ5D)R3607 1-216-864-11 SHORT CHIP 0 (AZ5D)R3609 1-216-864-11 SHORT CHIP 0 (AZ5D)R3611 1-216-809-11 METAL CHIP 100 5% 1/10W

(AZ5D)R3621 1-216-809-11 METAL CHIP 100 5% 1/10W

(AZ5D)

R3651 1-216-864-11 SHORT CHIP 0R3652 1-216-864-11 SHORT CHIP 0R3653 1-216-864-11 SHORT CHIP 0R3711 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3712 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R3713 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3714 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3715 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3716 1-216-821-11 METAL CHIP 1K 5% 1/10WR3717 1-216-821-11 METAL CHIP 1K 5% 1/10W

R3718 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3719 1-216-821-11 METAL CHIP 1K 5% 1/10WR3721 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3722 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3723 1-216-828-11 METAL CHIP 3.9K 5% 1/10W

R3724 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR3725 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR3726 1-216-821-11 METAL CHIP 1K 5% 1/10WR3727 1-216-821-11 METAL CHIP 1K 5% 1/10WR3728 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R3729 1-216-821-11 METAL CHIP 1K 5% 1/10WR3731 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

(AZ5D)R3732 1-216-823-11 METAL CHIP 1.5K 5% 1/10W



(AZ5D)

R3735 1-216-829-11 METAL CHIP 4.7K 5% 1/10W(AZ5D)

R3736 1-216-821-11 METAL CHIP 1K 5% 1/10W(AZ5D)































R3771 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3772 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3773 1-216-828-11 METAL CHIP 3.9K 5% 1/10W


R3779 1-216-821-11 METAL CHIP 1K 5% 1/10WR3781 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3782 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR3783 1-216-828-11 METAL CHIP 3.9K 5% 1/10W

DMB10


90

HCD-AZ2D/AZ5D

R3784 1-216-828-11 METAL CHIP 3.9K 5% 1/10W


R3801 1-216-864-11 SHORT CHIP 0R3802 1-216-864-11 SHORT CHIP 0R3803 1-216-833-11 METAL CHIP 10K 5% 1/10WR3804 1-216-836-11 METAL CHIP 18K 5% 1/10WR3805 1-216-821-11 METAL CHIP 1K 5% 1/10W

R4701 1-216-864-11 SHORT CHIP 0R4702 1-216-864-11 SHORT CHIP 0R4703 1-216-864-11 SHORT CHIP 0R4704 1-216-864-11 SHORT CHIP 0R4705 1-216-864-11 SHORT CHIP 0

R4706 1-216-864-11 SHORT CHIP 0R5008 1-216-864-11 SHORT CHIP 0 (AZ2D)R5009 1-216-864-11 SHORT CHIP 0 (AZ5D)R5010 1-216-864-11 SHORT CHIP 0R5014 1-216-864-11 SHORT CHIP 0 (AZ2D: E2/AZ5D: E2)

R5016 1-216-864-11 SHORT CHIP 0(AZ2D: E3, E12, E13, E15, EA, AUS/AZ5D: E3, E12, E15, EA, AUS)

R5017 1-216-864-11 SHORT CHIP 0(AZ2D: SP, MY, KR, PH/AZ5D: SP, MY, TH)

< COMPOSITION CIRCUIT BLOCK >

RB103 1-234-795-21 RES, NETWORK 0X4 (2010)RB104 1-234-795-21 RES, NETWORK 0X4 (2010)RB105 1-234-371-21 RES, NETWORK 47 (1005X4)RB106 1-234-371-21 RES, NETWORK 47 (1005X4)RB107 1-234-370-21 RES, NETWORK 22 (1005X4)

RB108 1-234-370-21 RES, NETWORK 22 (1005X4) 22 (1005X4)RB111 1-234-795-21 RES, NETWORK 0X4 (2010)RB112 1-234-370-21 RES, NETWORK 22 (1005X4) 22 (1005X4)RB113 1-234-370-21 RES, NETWORK 22 (1005X4) 22 (1005X4)

< VIBRATOR >

X101 1-781-867-21 VIBRATOR, CRYSTAL (27MHz)*************************************************************

EJECT BOARD***********

< RESISTOR >

R1039 1-216-833-11 METAL CHIP 10K 5% 1/10W

< SWITCH >

S1041 1-762-875-21 SWITCH, KEYBOARD (Z)*************************************************************

A-1091-269-A FL BOARD, COMPLETE (EXCEPT AZ5D: TH)A-1114-866-A FL BOARD, COMPLETE (AZ5D: TH)

********

< CAPACITOR >

C1001 1-126-514-11 ELECT 22uF 20% 16VC1002 1-107-727-61 CERAMIC CHIP 0.022uF 10% 16V

C1003 1-162-974-11 CERAMIC CHIP 0.01uF 50VC1004 1-119-943-11 ELECT 47uF 20% 50VC1005 1-162-974-11 CERAMIC CHIP 0.01uF 50V

C1006 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC1007 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC1008 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC1009 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC1010 1-162-922-11 CERAMIC CHIP 39PF 5% 50V

C1011 1-126-964-11 ELECT 10uF 20% 50VC1012 1-126-964-11 ELECT 10uF 20% 50VC1013 1-162-974-11 CERAMIC CHIP 0.01uF 50VC1014 1-162-974-11 CERAMIC CHIP 0.01uF 50V

< CONNECTOR >

CN1001 1-784-735-11 CONNECTOR, FFC 13P

< DIODE >

D1001 8-719-988-61 DIODE 1SS355TE-17D1002 8-719-988-61 DIODE 1SS355TE-17D1003 8-719-988-61 DIODE 1SS355TE-17D1004 8-719-988-61 DIODE 1SS355TE-17D1005 8-719-083-58 DIODE UDZSTE-173.9B

D1006 6-500-809-01 LED SELU5223C-STP15 (BACK LIGHT)D1007 6-500-809-01 LED SELU5223C-STP15 (BACK LIGHT)D1008 6-500-809-01 LED SELU5223C-STP15 (BACK LIGHT)D1009 6-500-809-01 LED SELU5223C-STP15 (BACK LIGHT)D1010 6-500-809-01 LED SELU5223C-STP15 (BACK LIGHT)

< FLUORESCENT INDICATOR >

FL1001 1-519-789-11 INDICATOR TUBE, FLUORESCENT

< IC >

IC1001 6-705-899-01 IC ML9208-03MBZ03B

< COIL >

L1001 1-410-671-31 INDUCTOR 47uH

< TRANSISTOR >

Q1001 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1002 8-729-027-43 TRANSISTOR DTC114EKA-T146Q1003 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q1004 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q1005 6-550-065-01 TRANSISTOR CPH5504-TL-E

< RESISTOR >

R1001 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1002 1-216-833-11 METAL CHIP 10K 5% 1/10WR1003 1-216-809-11 METAL CHIP 100 5% 1/10WR1004 1-216-809-11 METAL CHIP 100 5% 1/10WR1006 1-216-837-11 METAL CHIP 22K 5% 1/10W

R1007 1-216-837-11 METAL CHIP 22K 5% 1/10WR1008 1-216-821-11 METAL CHIP 1K 5% 1/10WR1009 1-216-821-11 METAL CHIP 1K 5% 1/10WR1010 1-216-821-11 METAL CHIP 1K 5% 1/10WR1011 1-216-821-11 METAL CHIP 1K 5% 1/10W

R1012 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR1013 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

DMB10 EJECT FL


91

HCD-AZ2D/AZ5D

R1014 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1015 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1016 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R1017 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1018 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1019 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1020 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1021 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R1022 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR1023 1-216-833-11 METAL CHIP 10K 5% 1/10WR1024 1-216-833-11 METAL CHIP 10K 5% 1/10W

< TRANSFORMER >

T1001 1-443-576-11 TRANSFORMER, DC/DC CONVERTER*************************************************************

KEY BOARD*********

< CONNECTOR >

CN1030 1-784-727-11 CONNECTOR, FFC 5P

< LED >

D1030 8-719-071-44 LED SELS5223C-TP15 (STANDBY)

< RESISTOR >

R1030 1-216-821-11 METAL CHIP 1K 5% 1/10WR1031 1-216-821-11 METAL CHIP 1K 5% 1/10WR1032 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1033 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1034 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R1035 1-216-821-11 METAL CHIP 1K 5% 1/10WR1036 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1037 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR1038 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

< SWITCH >

S1030 1-762-875-21 SWITCH, KEYBOARD (?/1)S1031 1-762-875-21 SWITCH, KEYBOARD (DIMMER)S1032 1-762-875-21 SWITCH, KEYBOARD (PROGRESSIVE)S1033 1-762-875-21 SWITCH, KEYBOARD (DSGX)S1034 1-762-875-21 SWITCH, KEYBOARD (SOUND FILED)

S1035 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)S1036 1-762-875-21 SWITCH, KEYBOARD (EQ SELECT)S1037 1-762-875-21 SWITCH, KEYBOARD (DIRECTION)S1038 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)S1039 1-762-875-21 SWITCH, KEYBOARD (z START)

*************************************************************

A-1091-182-A MAIN BOARD, COMPLETE (AZ2D: SP, MY)A-1091-183-A MAIN BOARD, COMPLETE (AZ2D: E2)A-1091-184-A MAIN BOARD, COMPLETE (AZ2D: E13)A-1091-185-A MAIN BOARD, COMPLETE (AZ5D: SP, MY)A-1091-186-A MAIN BOARD, COMPLETE (AZ5D: E2)

A-1092-100-A MAIN BOARD, COMPLETE (AZ2D: AUS)A-1092-101-A MAIN BOARD, COMPLETE (AZ2D: EA)A-1092-102-A MAIN BOARD, COMPLETE (AZ2D: KR)A-1092-103-A MAIN BOARD, COMPLETE (AZ5D: AUS)A-1092-104-A MAIN BOARD, COMPLETE (AZ5D: EA)

A-1114-671-A MAIN BOARD, COMPLETE (AZ2D: PH)A-1114-680-A MAIN BOARD, COMPLETE (AZ2D: E15)A-1114-696-A MAIN BOARD, COMPLETE (AZ2D: E3)A-1114-703-A MAIN BOARD, COMPLETE (AZ2D: E12)A-1114-711-A MAIN BOARD, COMPLETE (AZ5D: E15)

A-1114-719-A MAIN BOARD, COMPLETE (AZ5D: E3)A-1114-745-A MAIN BOARD, COMPLETE (AZ5D: E12)A-1114-860-A MAIN BOARD, COMPLETE (AZ5D: TH)

**********

7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3

< CAPACITOR >

C1 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC2 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16VC3 1-115-156-11 CERAMIC CHIP 1uF 10VC4 1-126-964-11 ELECT 10uF 20% 50VC10 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C11 1-162-921-11 CERAMIC CHIP 33PF 5% 50VC12 1-162-920-11 CERAMIC CHIP 27PF 5% 50VC13 1-115-156-11 CERAMIC CHIP 1uF 10VC14 1-126-947-11 ELECT 47uF 20% 35VC15 1-126-947-11 ELECT 47uF 20% 35V

C16 1-115-156-11 CERAMIC CHIP 1uF 10VC17 1-164-156-11 CERAMIC CHIP 0.1uF 25VC18 1-115-156-11 CERAMIC CHIP 1uF 10VC19 1-126-963-11 ELECT 4.7uF 20% 50VC20 1-126-963-11 ELECT 4.7uF 20% 50V

C29 1-126-964-11 ELECT 10uF 20% 50VC30 1-126-964-11 ELECT 10uF 20% 50VC31 1-124-261-00 ELECT 10uF 20% 50VC32 1-124-261-00 ELECT 10uF 20% 50VC33 1-126-964-11 ELECT 10uF 20% 50V

(AZ5D)

C34 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C35 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C36 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)


C53 1-115-156-11 CERAMIC CHIP 1uF 10VC54 1-126-964-11 ELECT 10uF 20% 50VC70 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC72 1-126-964-11 ELECT 10uF 20% 50VC73 1-126-963-11 ELECT 4.7uF 20% 50V

C74 1-126-963-11 ELECT 4.7uF 20% 50VC75 1-126-964-11 ELECT 10uF 20% 50VC77 1-126-935-11 ELECT 470uF 20% 16VC79 1-126-964-11 ELECT 10uF 20% 50VC82 1-126-964-11 ELECT 10uF 20% 50V

C85 1-126-964-11 ELECT 10uF 20% 50VC87 1-126-935-11 ELECT 470uF 20% 16VC89 1-126-964-11 ELECT 10uF 20% 50VC90 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC93 1-126-926-11 ELECT 1000uF 20% 10V

C94 1-126-964-11 ELECT 10uF 20% 50V

MAINFL KEY


92

HCD-AZ2D/AZ5D

C100 1-164-156-11 CERAMIC CHIP 0.1uF 25VC101 1-126-964-11 ELECT 10uF 20% 50VC102 1-126-964-11 ELECT 10uF 20% 50VC103 1-126-964-11 ELECT 10uF 20% 50V

C104 1-126-964-11 ELECT 10uF 20% 50VC105 1-136-497-81 FILM 0.1uF 5% 50VC106 1-126-964-11 ELECT 10uF 20% 50VC107 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC108 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V

C109 1-126-964-11 ELECT 10uF 20% 50VC110 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC111 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC112 1-126-964-11 ELECT 10uF 20% 50VC113 1-137-194-81 FILM 0.47uF 5% 50V

C114 1-137-193-11 FILM 0.39uF 5% 50VC115 1-126-964-11 ELECT 10uF 20% 50VC116 1-126-964-11 ELECT 10uF 20% 50VC117 1-126-960-11 ELECT 1uF 20% 50VC118 1-137-150-11 FILM 0.01uF 5% 100V

C119 1-126-947-11 ELECT 47uF 20% 35VC121 1-136-177-00 FILM 1uF 5% 50VC122 1-126-963-11 ELECT 4.7uF 20% 50VC123 1-163-077-00 CERAMIC CHIP 0.1uF 50VC124 1-104-665-11 ELECT 100uF 20% 25V

C125 1-104-665-11 ELECT 100uF 20% 25VC126 1-104-665-11 ELECT 100uF 20% 25VC127 1-104-665-11 ELECT 100uF 20% 25VC128 1-126-964-11 ELECT 10uF 20% 50VC129 1-137-194-81 FILM 0.47uF 5% 50V

C130 1-137-374-11 MYLAR 0.047uF 5% 50V(AZ2D)

C131 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC132 1-137-150-11 FILM 0.01uF 5% 100VC133 1-137-150-11 FILM 0.01uF 5% 100VC134 1-126-964-11 ELECT 10uF 20% 50V

C135 1-126-960-11 ELECT 1uF 20% 50VC139 1-126-964-11 ELECT 10uF 20% 50VC140 1-126-960-11 ELECT 1uF 20% 50VC141 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC142 1-126-964-11 ELECT 10uF 20% 50V

C143 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC144 1-126-964-11 ELECT 10uF 20% 50VC146 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25VC147 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC148 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C150 1-163-077-00 CERAMIC CHIP 0.1uF 50VC151 1-126-964-11 ELECT 10uF 20% 50VC152 1-126-964-11 ELECT 10uF 20% 50VC154 1-126-964-11 ELECT 10uF 20% 50VC155 1-136-497-81 FILM 0.1uF 5% 50V

C156 1-126-964-11 ELECT 10uF 20% 50VC157 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC158 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC159 1-126-964-11 ELECT 10uF 20% 50VC160 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16V

C161 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC162 1-126-964-11 ELECT 10uF 20% 50VC163 1-137-194-81 FILM 0.47uF 5% 50V

C164 1-137-193-11 FILM 0.39uF 5% 50VC165 1-126-964-11 ELECT 10uF 20% 50V

C166 1-126-964-11 ELECT 10uF 20% 50VC167 1-126-960-11 ELECT 1uF 20% 50VC168 1-137-150-11 FILM 0.01uF 5% 100VC169 1-126-947-11 ELECT 47uF 20% 35VC171 1-126-963-11 ELECT 4.7uF 20% 50V

C172 1-126-963-11 ELECT 4.7uF 20% 50VC173 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC174 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC176 1-126-964-11 ELECT 10uF 20% 50V

(AZ5D)C177 1-137-194-81 FILM 0.47uF 5% 50V

(AZ5D)

C178 1-136-169-00 FILM 0.22uF 5% 50V(AZ5D)

C179 1-126-960-11 ELECT 1uF 20% 50V(AZ5D)

C183 1-126-961-11 ELECT 2.2uF 20% 50VC189 1-126-964-11 ELECT 10uF 20% 50VC191 1-162-960-11 CERAMIC CHIP 220PF 10% 50V

C192 1-126-964-11 ELECT 10uF 20% 50VC193 1-162-960-11 CERAMIC CHIP 220PF 10% 50VC194 1-126-964-11 ELECT 10uF 20% 50VC196 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25VC197 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C198 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC200 1-164-156-11 CERAMIC CHIP 0.1uF 25VC201 1-126-964-11 ELECT 10uF 20% 50V

(AZ5D)C202 1-126-964-11 ELECT 10uF 20% 50V


(AZ5D)

C204 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C231 1-104-665-11 ELECT 100uF 20% 25V(AZ2D)

C235 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C241 1-126-926-11 ELECT 1000uF 20% 10VC251 1-126-964-11 ELECT 10uF 20% 50V

(AZ5D)

C252 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)


C254 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C260 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V(AZ5D: EA, AUS)

C262 1-164-156-11 CERAMIC CHIP 0.1uF 25V(AZ5D)

C264 1-126-963-11 ELECT 4.7uF 20% 50V(AZ5D)

C265 1-126-963-11 ELECT 4.7uF 20% 50V(AZ5D)

C266 1-126-964-11 ELECT 10uF 20% 50VC267 1-126-964-11 ELECT 10uF 20% 50VC270 1-126-964-11 ELECT 10uF 20% 50V

MAIN


93

HCD-AZ2D/AZ5D

C271 1-126-964-11 ELECT 10uF 20% 50VC272 1-126-964-11 ELECT 10uF 20% 50VC273 1-126-964-11 ELECT 10uF 20% 50VC274 1-126-964-11 ELECT 10uF 20% 50V

(AZ5D)C275 1-126-964-11 ELECT 10uF 20% 50V

(AZ5D)

C276 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C277 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C300 1-164-156-11 CERAMIC CHIP 0.1uF 25VC301 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC302 1-126-964-11 ELECT 10uF 20% 50V

C303 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC304 1-126-964-11 ELECT 10uF 20% 50VC305 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC306 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC307 1-162-961-11 CERAMIC CHIP 330PF 10% 50V

C308 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC310 1-126-965-11 ELECT 22uF 20% 50VC311 1-130-481-00 MYLAR 0.0068uF 5% 50VC312 1-137-150-11 FILM 0.01uF 5% 100VC313 1-124-589-11 ELECT 47uF 20% 16V

C314 1-137-150-11 FILM 0.01uF 5% 100VC315 1-136-287-11 FILM 0.0047uF 5% 100VC322 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC324 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50VC340 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C351 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC352 1-126-964-11 ELECT 10uF 20% 50VC353 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC354 1-126-964-11 ELECT 10uF 20% 50VC355 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C356 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC357 1-162-961-11 CERAMIC CHIP 330PF 10% 50VC358 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC361 1-126-163-11 ELECT 4.7uF 20% 50VC362 1-126-163-11 ELECT 4.7uF 20% 50V

C363 1-126-163-11 ELECT 4.7uF 20% 50VC364 1-126-163-11 ELECT 4.7uF 20% 50VC390 1-126-965-11 ELECT 22uF 20% 50VC391 1-136-497-11 FILM 0.1uF 5% 50VC392 1-136-497-11 FILM 0.1uF 5% 50V

C393 1-126-964-11 ELECT 10uF 20% 50VC399 1-126-924-11 ELECT 330uF 20% 10VC400 1-164-156-11 CERAMIC CHIP 0.1uF 25VC410 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC411 1-162-918-11 CERAMIC CHIP 18PF 5% 50V

C412 1-164-156-11 CERAMIC CHIP 0.1uF 25VC416 1-164-156-11 CERAMIC CHIP 0.1uF 25VC417 1-126-917-11 ELECT 3300uF 20% 6.3VC462 1-104-665-11 ELECT 100uF 20% 25VC464 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C498 1-126-964-11 ELECT 10uF 20% 50VC499 1-164-156-11 CERAMIC CHIP 0.1uF 25VC950 1-126-937-11 ELECT 4700uF 20% 16VC951 1-126-960-11 ELECT 1uF 20% 50VC952 1-104-665-11 ELECT 100uF 20% 25V

C953 1-126-960-11 ELECT 1uF 20% 50VC954 1-126-935-11 ELECT 470uF 20% 16VC955 1-126-960-11 ELECT 1uF 20% 50VC956 1-104-665-11 ELECT 100uF 20% 25VC957 1-126-960-11 ELECT 1uF 20% 50V

C958 1-126-926-11 ELECT 1000uF 20% 10VC959 1-126-960-11 ELECT 1uF 20% 50VC980 1-126-937-11 ELECT 4700uF 20% 16VC981 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC982 1-126-963-11 ELECT 4.7uF 20% 50V

C983 1-126-965-11 ELECT 22uF 20% 50VC984 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC990 1-126-916-11 ELECT 1000uF 20% 6.3VC991 1-126-960-11 ELECT 1uF 20% 50VC992 1-126-916-11 ELECT 1000uF 20% 6.3V

C999 1-164-156-11 CERAMIC CHIP 0.1uF 25V

< CONNECTOR >

CN1 1-815-194-11 CONNECTOR, USB (B) (PC)CN100 1-564-505-11 PLUG, CONNECTOR 2PCN101 1-784-780-11 CONNECTOR, FFC 19P (AZ2D)CN101 1-568-838-11 CONNECTOR FFC 21P (AZ5D)CN102 1-568-826-11 CONNECTOR FFC 7P (AZ5D)

CN103 1-785-320-11 PIN, CONNECTOR (STRAIGHT) 8PCN111 1-779-279-11 CONNECTOR, FFC (LIF (NON-ZIF)) 11PCN112 1-784-766-11 CONNECTOR, FFC 5PCN113 1-784-774-11 CONNECTOR, FFC 13PCN201 1-794-483-11 CONNECTOR, FFC (LIF (NON-ZIF)) 19P (AZ5D)

CN202 1-815-620-11 CONNECTOR, FFC (LIF (NON-ZIF)) 17P (AZ2D)CN203 1-779-281-11 CONNECTOR, FFC (LIF (NON-ZIF)) 13PCN206 1-568-828-11 CONNECTOR FFC 9P

* CN301 1-564-719-11 PIN, CONNECTOR (SMALL TYPE) 3P* CN302 1-564-724-11 PIN, CONNECTOR (SMALL TYPE) 8P

CN303 1-568-826-11 CONNECTOR FFC 7PCN304 1-691-040-31 CONNECTOR FFC 8PCN401 1-785-316-11 PIN, CONNECTOR (STRAIGHT) 4PCN951 1-691-770-11 PLUG (MICRO CONNECTOR) 8PCN952 1-691-765-11 PLUG (MICRO CONNECTOR) 3P

CN954 1-564-506-11 PLUG, CONNECTOR 3PCN955 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P (AZ5D)

< DIODE >

D1 8-719-988-61 DIODE 1SS355TE-17D71 8-719-988-61 DIODE 1SS355TE-17D72 8-719-988-61 DIODE 1SS355TE-17D181 8-719-988-61 DIODE 1SS355TE-17D182 8-719-988-61 DIODE 1SS355TE-17



MAIN


94

HCD-AZ2D/AZ5D


D951 8-719-988-61 DIODE 1SS355TE-17D953 6-500-522-21 DIODE 10EDB40-TB3D954 6-500-522-21 DIODE 10EDB40-TB3D955 6-500-522-21 DIODE 10EDB40-TB3 (AZ2D)D981 8-719-988-61 DIODE 1SS355TE-17

D982 8-719-069-56 DIODE UDZSTE-176.2BD983 8-719-978-33 DIODE DTZ-TT11-6.8BD984 8-719-988-61 DIODE 1SS355TE-17

< EARTH TERMINAL >

EP901 1-537-738-21 TERMINAL, GROUNDEP902 1-537-738-21 TERMINAL, GROUND

< JUMPER RESISTOR >

FB30 1-216-864-11 SHORT CHIP 0FB34 1-216-864-11 SHORT CHIP 0FB50 1-216-864-11 SHORT CHIP 0FB54 1-216-864-11 SHORT CHIP 0FB80 1-216-864-11 SHORT CHIP 0

FB84 1-216-864-11 SHORT CHIP 0FB101 1-216-864-11 SHORT CHIP 0FB201 1-216-864-11 SHORT CHIP 0 (AZ2D)

< IC >

IC1 6-705-055-01 IC PCM2704DBRIC3 8-759-359-49 IC NJM3414AV (TE2)IC101 6-705-667-01 IC M61537FP-RF0GIC231 8-749-019-25 IC TOTX141 (DVD DIGITAL OUT ) (AZ2D)IC261 8-759-677-02 IC BU4053BCF-E2 (AZ5D)

IC391 6-707-920-01 IC BD4828G-TRIC401 6-805-076-01 IC M30622MEP-A06FPU0IC951 6-703-550-01 IC TA7809LSIC952 6-703-550-01 IC TA7809LSIC953 6-703-546-01 IC TA7804LS

IC954 8-759-653-07 IC PQ09RD21J00HIC955 6-707-921-01 IC PQ3RD13IC956 8-759-471-81 IC PQ05RD11J00H

< JACK >

J101 1-794-212-11 JACK, PIN 4P (VIDEO SAT IN, VIDEO SAT OUT)

< CAPACITOR/JUMPER RESISTOR >

JR1 1-163-077-00 CERAMIC CHIP 0.1uF 50VJR105 1-216-864-11 SHORT CHIP 0JR108 1-216-296-11 SHORT CHIP 0JR109 1-216-296-11 SHORT CHIP 0JR110 1-216-296-11 SHORT CHIP 0

JR111 1-216-296-11 SHORT CHIP 0JR112 1-216-296-11 SHORT CHIP 0JR116 1-216-296-11 SHORT CHIP 0JR117 1-216-296-11 SHORT CHIP 0JR119 1-216-296-11 SHORT CHIP 0

JR120 1-216-296-11 SHORT CHIP 0JR121 1-216-296-11 SHORT CHIP 0JR122 1-216-296-11 SHORT CHIP 0JR123 1-216-296-11 SHORT CHIP 0JR124 1-216-864-11 SHORT CHIP 0

JR127 1-216-296-11 SHORT CHIP 0JR130 1-216-296-11 SHORT CHIP 0JR131 1-216-864-11 SHORT CHIP 0JR132 1-216-296-11 SHORT CHIP 0

< COIL >

L1 1-412-064-11 INDUCTOR 100uHL231 1-412-064-11 INDUCTOR 100uH (AZ2D)L241 1-412-064-11 INDUCTOR 100uHL301 1-410-780-11 INDUCTOR 27mHL311 1-414-189-31 INDUCTOR 100uH

L351 1-410-780-11 INDUCTOR 27mH

< TRANSISTOR >

Q1 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ11 8-729-027-23 TRANSISTOR DTA114EKA-T146Q12 8-729-027-59 TRANSISTOR DTC144EKA-T146Q13 8-729-027-23 TRANSISTOR DTA114EKA-T146Q22 8-729-027-23 TRANSISTOR DTA114EKA-T146

Q30 8-729-027-23 TRANSISTOR DTA114EKA-T146Q31 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ32 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ33 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)Q34 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)

Q35 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)Q36 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)Q51 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ71 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ73 6-550-889-01 TRANSISTOR 2SC5938-T112-1B

Q81 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ82 8-729-142-48 TRANSISTOR 2SD1616-TP-LKQ83 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ101 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q103 6-550-889-01 TRANSISTOR 2SC5938-T112-1B

Q104 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ140 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ141 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ151 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q153 6-550-889-01 TRANSISTOR 2SC5938-T112-1B

Q154 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ171 8-729-027-23 TRANSISTOR DTA114EKA-T146Q191 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ201 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)Q251 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)

Q260 8-729-027-43 TRANSISTOR DTC114EKA-T146 (AZ5D)Q261 8-729-027-43 TRANSISTOR DTC114EKA-T146 (AZ5D)Q262 8-729-027-23 TRANSISTOR DTA114EKA-T146 (AZ5D)Q263 8-729-027-23 TRANSISTOR DTA114EKA-T146Q270 6-550-889-01 TRANSISTOR 2SC5938-T112-1B

Q271 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ272 6-550-889-01 TRANSISTOR 2SC5938-T112-1BQ273 6-550-889-01 TRANSISTOR 2SC5938-T112-1B

MAIN


95

HCD-AZ2D/AZ5D

Q274 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)Q275 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)

Q276 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)Q277 6-550-889-01 TRANSISTOR 2SC5938-T112-1B (AZ5D)Q301 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16Q302 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16Q303 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16

Q311 8-729-600-22 TRANSISTOR 2SA1235-FQ312 8-729-027-43 TRANSISTOR DTC114EKA-T146Q313 8-729-027-43 TRANSISTOR DTC114EKA-T146Q314 8-729-027-23 TRANSISTOR DTA114EKA-T146Q315 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q316 8-729-027-43 TRANSISTOR DTC114EKA-T146Q317 8-729-040-20 TRANSISTOR RT1P137L-TPQ318 8-729-011-92 TRANSISTOR 2SC2001TP-K1K2Q321 8-729-027-43 TRANSISTOR DTC114EKA-T146Q322 8-729-140-04 TRANSISTOR 2SB1116A-L

Q323 8-729-027-43 TRANSISTOR DTC114EKA-T146Q324 8-729-140-04 TRANSISTOR 2SB1116A-LQ326 8-729-027-43 TRANSISTOR DTC114EKA-T146Q327 8-729-140-04 TRANSISTOR 2SB1116A-LQ328 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q329 8-729-140-04 TRANSISTOR 2SB1116A-LQ341 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q342 8-729-027-43 TRANSISTOR DTC114EKA-T146Q343 8-729-027-43 TRANSISTOR DTC114EKA-T146Q351 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16

Q352 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16Q353 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16Q361 8-729-027-23 TRANSISTOR DTA114EKA-T146Q362 8-729-027-23 TRANSISTOR DTA114EKA-T146Q363 8-729-027-23 TRANSISTOR DTA114EKA-T146

Q391 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q464 8-729-025-28 FET 2SK1828Q465 8-729-027-43 TRANSISTOR DTC114EKA-T146Q951 8-729-027-43 TRANSISTOR DTC114EKA-T146Q952 8-729-027-43 TRANSISTOR DTC114EKA-T146

Q981 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q982 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q983 8-729-026-68 TRANSISTOR 2SD2525 (TP)Q984 8-729-027-43 TRANSISTOR DTC114EKA-T146

< RESISTOR >

R1 1-216-801-11 METAL CHIP 22 5% 1/10WR3 1-216-813-11 METAL CHIP 220 5% 1/10WR4 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR6 1-216-821-11 METAL CHIP 1K 5% 1/10WR7 1-216-821-11 METAL CHIP 1K 5% 1/10W

R8 1-216-270-00 RES-CHIP 1M 5% 1/8WR9 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR10 1-216-801-11 METAL CHIP 22 5% 1/10WR11 1-216-801-11 METAL CHIP 22 5% 1/10WR16 1-216-166-00 RES-CHIP 47 5% 1/8W

R17 1-216-166-00 RES-CHIP 47 5% 1/8WR18 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR19 1-216-845-11 METAL CHIP 100K 5% 1/10WR20 1-216-857-11 METAL CHIP 1M 5% 1/10WR21 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R22 1-216-845-11 METAL CHIP 100K 5% 1/10WR23 1-216-837-11 METAL CHIP 22K 5% 1/10WR27 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR28 1-216-845-11 METAL CHIP 100K 5% 1/10WR29 1-216-837-11 METAL CHIP 22K 5% 1/10W






(AZ5D)









R50 1-216-841-11 METAL CHIP 47K 5% 1/10WR51 1-216-801-11 METAL CHIP 22 5% 1/10W

R53 1-216-813-11 METAL CHIP 220 5% 1/10WR54 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR56 1-216-821-11 METAL CHIP 1K 5% 1/10WR57 1-216-833-11 METAL CHIP 10K 5% 1/10WR58 1-216-833-11 METAL CHIP 10K 5% 1/10W

R59 1-216-833-11 METAL CHIP 10K 5% 1/10WR60 1-216-841-11 METAL CHIP 47K 5% 1/10WR61 1-216-166-00 RES-CHIP 47 5% 1/8WR71 1-216-166-00 RES-CHIP 47 5% 1/8WR72 1-216-829-11 METAL CHIP 4.7K 5% 1/10W


R78 1-216-821-11 METAL CHIP 1K 5% 1/10WR80 1-216-821-11 METAL CHIP 1K 5% 1/10WR81 1-216-166-00 RES-CHIP 47 5% 1/8WR82 1-216-845-11 METAL CHIP 100K 5% 1/10WR83 1-216-821-11 METAL CHIP 1K 5% 1/10W

R84 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR85 1-216-833-11 METAL CHIP 10K 5% 1/10W

MAIN


96

HCD-AZ2D/AZ5D

R86 1-216-843-11 METAL CHIP 68K 5% 1/10WR87 1-216-845-11 METAL CHIP 100K 5% 1/10WR88 1-216-821-11 METAL CHIP 1K 5% 1/10W

R90 1-216-821-11 METAL CHIP 1K 5% 1/10WR91 1-216-166-00 RES-CHIP 47 5% 1/8WR92 1-216-845-11 METAL CHIP 100K 5% 1/10WR93 1-216-821-11 METAL CHIP 1K 5% 1/10WR94 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R98 1-216-821-11 METAL CHIP 1K 5% 1/10WR101 1-216-835-11 METAL CHIP 15K 5% 1/10WR102 1-216-841-11 METAL CHIP 47K 5% 1/10WR103 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR104 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R105 1-216-833-11 METAL CHIP 10K 5% 1/10WR106 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR107 1-216-817-11 METAL CHIP 470 5% 1/10WR108 1-216-841-11 METAL CHIP 47K 5% 1/10WR109 1-216-841-11 METAL CHIP 47K 5% 1/10W

R110 1-216-821-11 METAL CHIP 1K 5% 1/10WR111 1-216-821-11 METAL CHIP 1K 5% 1/10WR112 1-216-835-11 METAL CHIP 15K 5% 1/10WR113 1-216-851-11 METAL CHIP 330K 5% 1/10WR114 1-216-812-11 METAL CHIP 180 5% 1/10W


(AZ2D)R121 1-216-861-11 METAL CHIP 2.2M 5% 1/10WR122 1-216-835-11 METAL CHIP 15K 5% 1/10W

R123 1-216-857-11 METAL CHIP 1M 5% 1/10WR126 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR127 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR128 1-216-857-11 METAL CHIP 1M 5% 1/10WR129 1-216-835-11 METAL CHIP 15K 5% 1/10W

R130 1-216-809-11 METAL CHIP 100 5% 1/10WR131 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR132 1-216-838-11 METAL CHIP 27K 5% 1/10WR133 1-216-833-11 METAL CHIP 10K 5% 1/10WR141 1-216-821-11 METAL CHIP 1K 5% 1/10W

R142 1-216-845-11 METAL CHIP 100K 5% 1/10WR143 1-216-864-11 SHORT CHIP 0R144 1-216-845-11 METAL CHIP 100K 5% 1/10WR145 1-216-821-11 METAL CHIP 1K 5% 1/10WR146 1-216-821-11 METAL CHIP 1K 5% 1/10W


R154 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR155 1-216-833-11 METAL CHIP 10K 5% 1/10WR156 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR157 1-216-817-11 METAL CHIP 470 5% 1/10WR158 1-216-841-11 METAL CHIP 47K 5% 1/10W

R159 1-216-841-11 METAL CHIP 47K 5% 1/10WR160 1-216-821-11 METAL CHIP 1K 5% 1/10WR161 1-216-821-11 METAL CHIP 1K 5% 1/10WR162 1-216-835-11 METAL CHIP 15K 5% 1/10W

R163 1-216-851-11 METAL CHIP 330K 5% 1/10W

R164 1-216-812-11 METAL CHIP 180 5% 1/10WR168 1-216-821-11 METAL CHIP 1K 5% 1/10WR169 1-216-821-11 METAL CHIP 1K 5% 1/10WR171 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR172 1-216-845-11 METAL CHIP 100K 5% 1/10W



(AZ5D)R180 1-216-809-11 METAL CHIP 100 5% 1/10WR186 1-216-864-11 SHORT CHIP 0

R187 1-216-853-11 METAL CHIP 470K 5% 1/10WR188 1-218-484-11 METAL CHIP 750 5% 1/10WR189 1-216-841-11 METAL CHIP 47K 5% 1/10WR191 1-216-821-11 METAL CHIP 1K 5% 1/10WR192 1-216-845-11 METAL CHIP 100K 5% 1/10W

R193 1-216-864-11 SHORT CHIP 0R194 1-216-845-11 METAL CHIP 100K 5% 1/10WR195 1-216-821-11 METAL CHIP 1K 5% 1/10WR196 1-216-821-11 METAL CHIP 1K 5% 1/10WR197 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R198 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR201 1-216-825-11 METAL CHIP 2.2K 5% 1/10W




(AZ5D)




R245 1-216-833-11 METAL CHIP 10K 5% 1/10W(AZ2D: E2/AZ5D: E2)

R245 1-216-864-11 SHORT CHIP 0(EXCEPT AZ2D: E2/AZ5D: E2)










MAIN


97

HCD-AZ2D/AZ5D



R265 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR266 1-216-845-11 METAL CHIP 100K 5% 1/10WR267 1-216-837-11 METAL CHIP 22K 5% 1/10WR270 1-216-825-11 METAL CHIP 2.2K 5% 1/10W







(AZ5D)










R295 1-216-864-11 SHORT CHIP 0(EXCEPT AZ2D: E2/AZ5D: E2)


R301 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR302 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR303 1-216-821-11 METAL CHIP 1K 5% 1/10WR304 1-216-839-11 METAL CHIP 33K 5% 1/10W


R311 1-216-833-11 METAL CHIP 10K 5% 1/10WR312 1-216-833-11 METAL CHIP 10K 5% 1/10W

R313 1-216-833-11 METAL CHIP 10K 5% 1/10WR314 1-216-841-11 METAL CHIP 47K 5% 1/10WR315 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R316 1-216-797-11 METAL CHIP 10 5% 1/10WR317 1-216-833-11 METAL CHIP 10K 5% 1/10WR318 1-216-805-11 METAL CHIP 47 5% 1/10WR319 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR320 1-216-803-11 METAL CHIP 33 5% 1/10W

R321 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR322 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR323 1-216-821-11 METAL CHIP 1K 5% 1/10WR324 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR325 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R326 1-216-821-11 METAL CHIP 1K 5% 1/10WR327 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR328 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR329 1-216-841-11 METAL CHIP 47K 5% 1/10WR330 1-216-825-11 METAL CHIP 2.2K 5% 1/10W



R353 1-216-821-11 METAL CHIP 1K 5% 1/10WR354 1-216-839-11 METAL CHIP 33K 5% 1/10WR355 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR356 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR357 1-216-833-11 METAL CHIP 10K 5% 1/10W

R359 1-216-834-11 METAL CHIP 12K 5% 1/10WR361 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR362 1-216-845-11 METAL CHIP 100K 5% 1/10WR363 1-216-837-11 METAL CHIP 22K 5% 1/10WR364 1-216-829-11 METAL CHIP 4.7K 5% 1/10W




R381 1-216-833-11 METAL CHIP 10K 5% 1/10WR391 1-216-833-11 METAL CHIP 10K 5% 1/10WR392 1-216-837-11 METAL CHIP 22K 5% 1/10WR393 1-216-837-11 METAL CHIP 22K 5% 1/10WR394 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

MAIN


98

HCD-AZ2D/AZ5D

R395 1-216-813-11 METAL CHIP 220 5% 1/10WR396 1-216-833-11 METAL CHIP 10K 5% 1/10WR400 1-216-809-11 METAL CHIP 100 5% 1/10WR401 1-216-809-11 METAL CHIP 100 5% 1/10WR402 1-216-809-11 METAL CHIP 100 5% 1/10W

R403 1-216-857-11 METAL CHIP 1M 5% 1/10WR404 1-216-809-11 METAL CHIP 100 5% 1/10WR405 1-216-809-11 METAL CHIP 100 5% 1/10WR406 1-216-809-11 METAL CHIP 100 5% 1/10WR407 1-216-809-11 METAL CHIP 100 5% 1/10W

R408 1-216-833-11 METAL CHIP 10K 5% 1/10WR409 1-216-833-11 METAL CHIP 10K 5% 1/10WR411 1-216-851-11 METAL CHIP 330K 5% 1/10WR413 1-216-864-11 SHORT CHIP 0R415 1-216-833-11 METAL CHIP 10K 5% 1/10W

R416 1-216-833-11 METAL CHIP 10K 5% 1/10WR417 1-216-833-11 METAL CHIP 10K 5% 1/10WR419 1-216-809-11 METAL CHIP 100 5% 1/10WR420 1-216-841-11 METAL CHIP 47K 5% 1/10WR421 1-216-809-11 METAL CHIP 100 5% 1/10W





R444 1-216-809-11 METAL CHIP 100 5% 1/10WR445 1-216-841-11 METAL CHIP 47K 5% 1/10WR446 1-216-809-11 METAL CHIP 100 5% 1/10WR447 1-216-857-11 METAL CHIP 1M 5% 1/10WR451 1-216-857-11 METAL CHIP 1M 5% 1/10W

R452 1-216-857-11 METAL CHIP 1M 5% 1/10WR454 1-216-809-11 METAL CHIP 100 5% 1/10WR455 1-216-809-11 METAL CHIP 100 5% 1/10WR457 1-216-809-11 METAL CHIP 100 5% 1/10WR458 1-216-809-11 METAL CHIP 100 5% 1/10W

R459 1-216-809-11 METAL CHIP 100 5% 1/10W(AZ5D)

R460 1-216-809-11 METAL CHIP 100 5% 1/10W(AZ5D)

R462 1-216-833-11 METAL CHIP 10K 5% 1/10WR463 1-216-809-11 METAL CHIP 100 5% 1/10WR464 1-216-809-11 METAL CHIP 100 5% 1/10W

R465 1-216-821-11 METAL CHIP 1K 5% 1/10WR469 1-216-833-11 METAL CHIP 10K 5% 1/10WR471 1-216-833-11 METAL CHIP 10K 5% 1/10WR472 1-216-815-11 METAL CHIP 330 5% 1/10W

(AZ2D: E3, E15/AZ5D: E3, E15)R472 1-216-819-11 METAL CHIP 680 5% 1/10W

(AZ2D: E12/AZ5D: E12)

R472 1-216-821-11 METAL CHIP 1K 5% 1/10W(AZ2D: EA/AZ5D: EA)

R472 1-216-823-11 METAL CHIP 1.5K 5% 1/10W(AZ2D: AUS/AZ5D: AUS)

R472 1-216-829-11 METAL CHIP 4.7K 5% 1/10W(AZ2D: E2, E13, KR/AZ5D: E2)

R472 1-216-864-11 SHORT CHIP 0(AZ2D: SP, MY, PH/AZ5D: SP, MY, TH)

R473 1-216-811-11 METAL CHIP 150 5% 1/10W(AZ5D)

R473 1-216-864-11 SHORT CHIP 0 (AZ2D)R475 1-216-833-11 METAL CHIP 10K 5% 1/10WR480 1-216-809-11 METAL CHIP 100 5% 1/10WR481 1-216-809-11 METAL CHIP 100 5% 1/10WR482 1-216-809-11 METAL CHIP 100 5% 1/10W


R490 1-216-809-11 METAL CHIP 100 5% 1/10WR491 1-216-809-11 METAL CHIP 100 5% 1/10WR492 1-216-811-11 METAL CHIP 150 5% 1/10W

(AZ2D: E13)R492 1-216-821-11 METAL CHIP 1K 5% 1/10W

(AZ2D: E2/AZ5D: E2)R492 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

(AZ2D: KR)

R492 1-216-829-11 METAL CHIP 4.7K 5% 1/10W(EXCEPT AZ2D: E2, E13, KR/AZ5D: E2)

R493 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR494 1-216-833-11 METAL CHIP 10K 5% 1/10WR495 1-216-833-11 METAL CHIP 10K 5% 1/10WR496 1-216-797-11 METAL CHIP 10 5% 1/10W

R497 1-216-809-11 METAL CHIP 100 5% 1/10WR498 1-216-797-11 METAL CHIP 10 5% 1/10WR951 1-216-833-11 METAL CHIP 10K 5% 1/10WR981 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR982 1-216-841-11 METAL CHIP 47K 5% 1/10W


< TRANSFORMER >

T301 1-433-372-11 TRANSFORMER, BIAS OSCILLATION

< VIBRATOR >

X11 1-767-925-11 VIBRATOR, CRYSTAL (12MHz)X401 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)X402 1-760-489-11 VIBRATOR, CERAMIC (5MHz)

*************************************************************

MAIN


99

HCD-AZ2D/AZ5D

A-1091-273-A MIC BOARD, COMPLETE (EXCEPT AZ5D: TH)A-1114-870-A MIC BOARD, COMPLETE (AZ5D: TH)

*********

< CAPACITOR >

C1053 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC1060 1-115-868-11 ELECT 0.22uF 20% 50VC1061 1-162-974-11 CERAMIC CHIP 0.01uF 50VC1062 1-115-868-11 ELECT 0.22uF 20% 50VC1063 1-162-974-11 CERAMIC CHIP 0.01uF 50V

C1064 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC1066 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1067 1-164-816-11 CERAMIC CHIP 220PF 2% 50VC1068 1-115-868-11 ELECT 0.22uF 20% 50VC1069 1-115-872-11 ELECT 2.2uF 20% 50V

C1070 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC1071 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC1072 1-126-791-11 ELECT 10uF 20% 35VC1073 1-115-872-11 ELECT 2.2uF 20% 50VC1074 1-126-176-11 ELECT 220uF 20% 10V

C1077 1-115-871-11 ELECT 1uF 20% 50VC1078 1-115-872-11 ELECT 2.2uF 20% 50VC1079 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC1080 1-115-871-11 ELECT 1uF 20% 50VC1082 1-126-786-11 ELECT 47uF 20% 16V

C1083 1-126-786-11 ELECT 47uF 20% 16VC1084 1-110-563-11 CERAMIC CHIP 0.068uF 10% 16VC1085 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25VC1086 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC1087 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V


C1095 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC1097 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1098 1-164-156-11 CERAMIC CHIP 0.1uF 25V

< CONNECTOR >

CN1050 1-785-334-11 PIN, CONNECTOR (LIGHT ANGLE) 8P

< DIODE >

D1061 8-719-069-54 DIODE UDZSTE-175.1B

< EARTH TERMINAL >

EP1050 1-537-738-21 TERMINAL, GROUNDEP1060 1-537-738-21 TERMINAL, GROUND

< IC >

IC1060 8-759-710-97 IC NJM4565M-DIC1061 8-759-496-41 IC M65850FP-E1

< JACK >

J1050 1-750-032-11 JACK (DIA. 3.5) (PHONES)J1060 1-770-226-11 JACK (LARGE TYPE) (MIC 1)J1061 1-770-226-11 JACK (LARGE TYPE) (MIC 2)

< JUMPER RESISTOR/CAPACITOR >

JR1051 1-216-296-11 SHORT CHIP 0JR1053 1-164-156-11 CERAMIC CHIP 0.1uF 25V

< RESISTOR >

R1050 1-500-329-21 INDUCTOR, FERRITE BEADR1051 1-500-329-21 INDUCTOR, FERRITE BEADR1052 1-216-864-11 SHORT CHIP 0R1060 1-216-821-11 METAL CHIP 1K 5% 1/10WR1061 1-216-833-11 METAL CHIP 10K 5% 1/10W


R1067 1-216-809-11 METAL CHIP 100 5% 1/10WR1068 1-216-833-11 METAL CHIP 10K 5% 1/10WR1069 1-216-847-11 METAL CHIP 150K 5% 1/10WR1070 1-216-809-11 METAL CHIP 100 5% 1/10WR1071 1-216-833-11 METAL CHIP 10K 5% 1/10W

R1072 1-216-833-11 METAL CHIP 10K 5% 1/10WR1073 1-216-845-11 METAL CHIP 100K 5% 1/10WR1074 1-216-864-11 SHORT CHIP 0R1075 1-216-833-11 METAL CHIP 10K 5% 1/10WR1076 1-216-835-11 METAL CHIP 15K 5% 1/10W

R1077 1-216-835-11 METAL CHIP 15K 5% 1/10WR1078 1-216-837-11 METAL CHIP 22K 5% 1/10WR1079 1-216-813-11 METAL CHIP 220 5% 1/10WR1080 1-216-846-11 METAL CHIP 120K 5% 1/10WR1081 1-216-837-11 METAL CHIP 22K 5% 1/10W


< VARIABLE RESISTOR >

RV1060 1-223-983-11 RES, VAR, CARBON 50K (MIC LEVEL)RV1061 1-223-983-11 RES, VAR, CARBON 50K (ECHO LEVEL)

*************************************************************

MS-214 BOARD*************

< CONNECTOR >

CN001 1-815-569-11 CONNECTOR, FFC/FPC 7P

< SWITCH >

S001 1-762-951-13 SWITCH, PUSH (DISC IN/OUT)S002 1-762-951-13 SWITCH, PUSH (CHUCKING)S003 1-762-951-13 SWITCH, PUSH (TRIGGER)

************************************************************

MIC MS-214


100

HCD-AZ2D/AZ5D

SIRCS BOARD***********

< CAPACITOR >

C1040 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V

< IC >

IC1040 6-600-349-11 IC NJL22H400A

< RESISTOR >

R1040 1-216-805-11 METAL CHIP 47 5% 1/10WR1041 1-216-805-11 METAL CHIP 47 5% 1/10W

*************************************************************

A-1091-194-A S-MASTER BOARD, COMPLETE (AZ2D)A-1091-195-A S-MASTER BOARD, COMPLETE

(AZ5D: E2, E3, E12, E15, EA, SP, MY, AUS)A-1114-873-A S-MASTER BOARD, COMPLETE (AZ5D: TH)

***************

< CAPACITOR >

C501 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C502 1-126-960-11 ELECT 1uF 20% 50V(AZ5D)

C503 1-164-156-11 CERAMIC CHIP 0.1uF 25VC504 1-126-964-11 ELECT 10uF 20% 50V

(AZ5D)C505 1-164-156-11 CERAMIC CHIP 0.1uF 25V

(AZ5D)



C509 1-104-665-11 ELECT 100uF 20% 25V(AZ5D)


C511 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C512 1-126-960-11 ELECT 1uF 20% 50V(AZ5D)

C513 1-126-960-11 ELECT 1uF 20% 50V(AZ5D)

C514 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)




C519 1-104-665-11 ELECT 100uF 20% 25V(AZ5D)


C521 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C522 1-126-960-11 ELECT 1uF 20% 50V

C523 1-126-960-11 ELECT 1uF 20% 50VC524 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C525 1-124-247-11 ELECT 10uF 20% 35VC526 1-164-156-11 CERAMIC CHIP 0.1uF 25VC527 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C528 1-104-665-11 ELECT 100uF 20% 25VC529 1-164-156-11 CERAMIC CHIP 0.1uF 25VC530 1-164-156-11 CERAMIC CHIP 0.1uF 25VC531 1-126-964-11 ELECT 10uF 20% 50VC532 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V

C533 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC534 1-126-163-11 ELECT 4.7uF 20% 50VC535 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC536 1-164-156-11 CERAMIC CHIP 0.1uF 25V


(AZ5D)















C562 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C563 1-164-156-11 CERAMIC CHIP 0.1uF 25VC569 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC570 1-164-156-11 CERAMIC CHIP 0.1uF 25VC572 1-164-156-11 CERAMIC CHIP 0.1uF 25V


(AZ5D)



C576 1-164-346-11 CERAMIC CHIP 1uF 16V(AZ5D)



SIRCS S-MASTER


101

HCD-AZ2D/AZ5D






C584 1-100-924-21 ELECT 2200uF 20% 35V(AZ5D)


C586 1-136-177-00 FILM 1uF 5% 50V(AZ5D)

C587 1-136-177-00 FILM 1uF 5% 50V(AZ5D)








C595 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)

C596 1-126-964-11 ELECT 10uF 20% 50V(AZ5D)



C599 1-104-665-11 ELECT 100uF 20% 25V(AZ5D)




(AZ5D)










C614 1-100-924-21 ELECT 2200uF 20% 35V(AZ5D)


C616 1-136-177-00 FILM 1uF 5% 50V(AZ5D)

C617 1-136-177-00 FILM 1uF 5% 50V(AZ5D)


C620 1-126-935-11 ELECT 470uF 20% 16VC621 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V




(AZ5D)



C627 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC628 1-164-156-11 CERAMIC CHIP 0.1uF 25VC629 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50V

C630 1-164-156-11 CERAMIC CHIP 0.1uF 25VC631 1-162-923-11 CERAMIC CHIP 47PF 5% 50V




(AZ5D)









C644 1-100-924-21 ELECT 2200uF 20% 35V(AZ5D)


C646 1-136-177-00 FILM 1uF 5% 50V(AZ5D)

S-MASTER


102

HCD-AZ2D/AZ5D

C647 1-136-177-00 FILM 1uF 5% 50V(AZ5D)









C656 1-164-156-11 CERAMIC CHIP 0.1uF 25VC657 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC658 1-164-337-11 CERAMIC CHIP 2.2uF 16VC659 1-164-156-11 CERAMIC CHIP 0.1uF 25VC660 1-164-156-11 CERAMIC CHIP 0.1uF 25V

(AZ5D)






C666 1-126-947-11 ELECT 47uF 20% 35V(AZ5D)

C667 1-126-947-11 ELECT 47uF 20% 35V(AZ5D)




C671 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC672 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC673 1-164-156-11 CERAMIC CHIP 0.1uF 25V

(AZ5D)C674 1-100-924-21 ELECT 2200uF 20% 35V

(AZ5D)C676 1-136-177-00 FILM 1uF 5% 50V

(AZ5D)

C677 1-136-177-00 FILM 1uF 5% 50V(AZ5D)










C689 1-104-665-11 ELECT 100uF 20% 25V(AZ5D)






C696 1-126-947-11 ELECT 47uF 20% 35V(AZ5D)

C697 1-126-947-11 ELECT 47uF 20% 35V(AZ5D)





C702 1-126-933-11 ELECT 100uF 20% 16V(AZ5D)

C704 1-100-924-21 ELECT 2200uF 20% 35V(AZ5D)

C706 1-136-177-00 FILM 1uF 5% 50V(AZ5D)

C707 1-136-177-00 FILM 1uF 5% 50V(AZ5D)








C722 1-164-156-11 CERAMIC CHIP 0.1uF 25VC723 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C724 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC725 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC726 1-164-346-11 CERAMIC CHIP 1uF 16VC727 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50VC728 1-125-898-11 CERAMIC CHIP 0.22uF 10% 50V

S-MASTER


103

HCD-AZ2D/AZ5D

C729 1-125-898-11 CERAMIC CHIP 0.22uF 10% 50VC730 1-125-898-11 CERAMIC CHIP 0.22uF 10% 50VC731 1-125-898-11 CERAMIC CHIP 0.22uF 10% 50VC732 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50VC733 1-164-346-11 CERAMIC CHIP 1uF 16V

C734 1-100-924-21 ELECT 2200uF 20% 35VC735 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC736 1-136-177-00 FILM 1uF 5% 50VC737 1-136-177-00 FILM 1uF 5% 50VC738 1-125-898-11 CERAMIC CHIP 0.22uF 10% 50V


C744 1-117-370-11 CERAMIC CHIP 10uF 10VC747 1-164-156-11 CERAMIC CHIP 0.1uF 25VC748 1-164-156-11 CERAMIC CHIP 0.1uF 25VC749 1-104-665-11 ELECT 100uF 20% 25VC751 1-162-923-11 CERAMIC CHIP 47PF 5% 50V

C752 1-164-156-11 CERAMIC CHIP 0.1uF 25VC753 1-164-156-11 CERAMIC CHIP 0.1uF 25VC754 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC756 1-164-346-11 CERAMIC CHIP 1uF 16VC757 1-115-185-11 CERAMIC CHIP 0.033uF 10% 50V


C763 1-164-346-11 CERAMIC CHIP 1uF 16VC764 1-100-924-21 ELECT 2200uF 20% 35VC765 1-115-339-11 CERAMIC CHIP 0.1uF 10% 50VC766 1-136-177-00 FILM 1uF 5% 50VC767 1-136-177-00 FILM 1uF 5% 50V


C773 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC774 1-117-370-11 CERAMIC CHIP 10uF 10VC780 1-164-156-11 CERAMIC CHIP 0.1uF 25VC781 1-164-156-11 CERAMIC CHIP 0.1uF 25VC782 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C783 1-104-662-11 ELECT 22uF 20% 25VC784 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC785 1-162-910-11 CERAMIC CHIP 5PF 0.25PF 50VC786 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC787 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V

C790 1-126-956-11 ELECT 0.1uF 20% 50VC791 1-104-665-11 ELECT 100uF 20% 25VC792 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC793 1-104-665-11 ELECT 100uF 20% 25VC794 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C795 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC796 1-104-665-11 ELECT 100uF 20% 25V

< CONNECTOR >

CN501 1-784-780-11 CONNECTOR, FFC 19P (AZ2D)CN501 1-568-838-11 CONNECTOR FFC 21P (AZ5D)CN502 1-568-826-11 CONNECTOR FFC 7P (AZ5D)

* CN503 1-564-512-11 PLUG, CONNECTOR 9P (AZ2D)* CN503 1-764-333-11 PLUG, CONNECTOR 10P (AZ5D)

< DIODE >

D501 8-719-988-61 DIODE 1SS355TE-17D502 8-719-988-61 DIODE 1SS355TE-17D503 8-719-988-61 DIODE 1SS355TE-17D504 8-719-988-61 DIODE 1SS355TE-17D505 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)

D506 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)D507 8-719-988-61 DIODE 1SS355TE-17D508 8-719-988-61 DIODE 1SS355TE-17D509 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)D510 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)

D511 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)D512 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)D513 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)D514 8-719-988-61 DIODE 1SS355TE-17 (AZ5D)D515 8-719-988-61 DIODE 1SS355TE-17

D516 8-719-988-61 DIODE 1SS355TE-17D517 6-500-695-01 DIODE UDZSTE-172.7BD518 8-719-988-61 DIODE 1SS355TE-17D519 8-719-988-61 DIODE 1SS355TE-17D571 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)

D572 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D601 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D602 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D631 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D632 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)

D661 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D662 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D691 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D692 6-500-260-01 DIODE P6SMB39AT3 (AZ5D)D721 6-500-260-01 DIODE P6SMB39AT3

D722 6-500-260-01 DIODE P6SMB39AT3D751 6-500-260-01 DIODE P6SMB39AT3D752 6-500-260-01 DIODE P6SMB39AT3D753 8-719-988-61 DIODE 1SS355TE-17D754 8-719-988-61 DIODE 1SS355TE-17

D771 8-719-988-61 DIODE 1SS355TE-17

< EARTH TERMINAL >

EP501 1-537-738-21 GROUND, TERMINALEP503 1-537-738-21 GROUND, TERMINALEP504 1-537-738-21 GROUND, TERMINALEP505 1-537-738-21 GROUND, TERMINALEP506 1-537-738-21 GROUND, TERMINAL

EP507 1-537-738-21 GROUND, TERMINAL

< JUMPER RESISTOR >

FB702 1-216-864-11 SHORT CHIP 0

S-MASTER


104

HCD-AZ2D/AZ5D

< FILTER >

FL503 1-234-177-21 FILTER, CHIP EMIFL504 1-234-177-21 FILTER, CHIP EMIFL505 1-234-177-21 FILTER, CHIP EMIFL506 1-234-177-21 FILTER, CHIP EMI

< IC >

IC501 6-701-834-01 IC PCM1802DBR (AZ5D)IC502 6-701-834-01 IC PCM1802DBR (AZ5D)IC503 6-701-834-01 IC PCM1802DBRIC504 6-705-979-01 IC CXD9788AR (AZ5D)IC505 6-705-979-01 IC CXD9788AR (AZ5D)

IC506 6-705-979-01 IC CXD9788ARIC507 6-705-695-01 IC CXD9775M (AZ5D)IC508 6-705-695-01 IC CXD9775M (AZ5D)IC509 6-705-695-01 IC CXD9775M (AZ5D)IC512 6-705-695-01 IC CXD9775M

IC513 6-705-695-01 IC CXD9775MIC514 8-759-387-77 IC TC7WU04F (TE12R)IC515 6-701-189-01 IC MC74VHC1GU04DFT1IC516 8-759-473-95 IC uPC2905T-E1IC517 8-759-583-47 IC uPC2933T-E2

IC518 6-700-263-01 IC NJM2870F18 (TE2)IC519 6-707-629-01 IC CXD9845M (AZ5D)

< COIL/JUMPER RESISTOR >

L505 1-412-951-11 INDUCTOR 10uHL506 1-412-951-11 INDUCTOR 10uHL516 1-216-295-00 SHORT CHIP 0L517 1-216-295-00 SHORT CHIP 0L518 1-216-295-00 SHORT CHIP 0

L519 1-412-939-11 INDUCTOR 1uHL520 1-412-939-11 INDUCTOR 1uHL571 1-456-813-11 COIL, AIR-CORE (AZ5D)L572 1-456-813-11 COIL, AIR-CORE (AZ5D)L573 1-456-680-11 INDUCTOR 10uH (AZ5D)

L574 1-456-680-11 INDUCTOR 10uH (AZ5D)L601 1-456-813-11 COIL, AIR-CORE (AZ5D)L602 1-456-813-11 COIL, AIR-CORE (AZ5D)L603 1-456-680-11 INDUCTOR 10uH (AZ5D)L604 1-456-680-11 INDUCTOR 10uH (AZ5D)

L631 1-456-813-11 COIL, AIR-CORE (AZ5D)L632 1-456-813-11 COIL, AIR-CORE (AZ5D)L633 1-456-680-11 INDUCTOR 10uH (AZ5D)L634 1-456-680-11 INDUCTOR 10uH (AZ5D)L663 1-456-680-11 INDUCTOR 10uH (AZ5D)

L664 1-456-680-11 INDUCTOR 10uH (AZ5D)L693 1-456-680-11 INDUCTOR 10uH (AZ5D)L694 1-456-680-11 INDUCTOR 10uH (AZ5D)L721 1-456-813-11 COIL, AIR-COREL722 1-456-813-11 COIL, AIR-CORE

L723 1-456-680-11 INDUCTOR 10uHL724 1-456-680-11 INDUCTOR 10uHL751 1-456-813-11 COIL, AIR-COREL752 1-456-813-11 COIL, AIR-COREL753 1-456-680-11 INDUCTOR 10uH

L754 1-456-680-11 INDUCTOR 10uH

< TRANSISTOR >

Q571 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q572 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q631 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q632 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q657 8-729-120-28 TRANSISTOR 2SC1623-L5L6

Q661 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q662 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q691 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q692 8-729-602-36 TRANSISTOR 2SA1602-F (AZ5D)Q721 8-729-602-36 TRANSISTOR 2SA1602-F

Q722 8-729-602-36 TRANSISTOR 2SA1602-FQ751 8-729-602-36 TRANSISTOR 2SA1602-FQ752 8-729-602-36 TRANSISTOR 2SA1602-F

< RESISTOR >

R501 1-216-864-11 SHORT CHIP 0 (AZ5D)R502 1-216-864-11 SHORT CHIP 0 (AZ5D)R504 1-216-864-11 SHORT CHIP 0 (AZ5D)R505 1-216-821-11 METAL CHIP 1K 5% 1/10W


R508 1-216-864-11 SHORT CHIP 0R509 1-216-864-11 SHORT CHIP 0R510 1-219-365-11 SHORT CHIP 0R511 1-216-809-11 METAL CHIP 100 5% 1/10WR512 1-216-864-11 SHORT CHIP 0

R514 1-216-857-11 METAL CHIP 1M 5% 1/10WR515 1-216-821-11 METAL CHIP 1K 5% 1/10WR516 1-216-864-11 SHORT CHIP 0R517 1-216-809-11 METAL CHIP 100 5% 1/10W


(AZ5D)





R524 1-216-864-11 SHORT CHIP 0 (AZ5D)





R532 1-216-864-11 SHORT CHIP 0 (AZ5D)R533 1-216-821-11 METAL CHIP 1K 5% 1/10W



(AZ5D)

S-MASTER


105

HCD-AZ2D/AZ5D



R539 1-216-864-11 SHORT CHIP 0 (AZ5D)R540 1-216-864-11 SHORT CHIP 0 (AZ5D)R541 1-216-821-11 METAL CHIP 1K 5% 1/10W


(AZ5D)


R545 1-216-864-11 SHORT CHIP 0 (AZ5D)R546 1-216-864-11 SHORT CHIP 0 (AZ5D)R547 1-216-821-11 METAL CHIP 1K 5% 1/10WR550 1-216-821-11 METAL CHIP 1K 5% 1/10W

R551 1-216-821-11 METAL CHIP 1K 5% 1/10WR552 1-216-821-11 METAL CHIP 1K 5% 1/10WR553 1-216-864-11 SHORT CHIP 0R554 1-216-864-11 SHORT CHIP 0R555 1-216-833-11 METAL CHIP 10K 5% 1/10W

R556 1-216-821-11 METAL CHIP 1K 5% 1/10WR557 1-216-821-11 METAL CHIP 1K 5% 1/10WR558 1-216-821-11 METAL CHIP 1K 5% 1/10WR560 1-216-864-11 SHORT CHIP 0R561 1-216-864-11 SHORT CHIP 0

R562 1-216-864-11 SHORT CHIP 0R563 1-216-864-11 SHORT CHIP 0 (AZ5D)R564 1-216-864-11 SHORT CHIP 0 (AZ5D)R569 1-216-864-11 SHORT CHIP 0R570 1-216-821-11 METAL CHIP 1K 5% 1/10W


(AZ5D)R574 1-216-864-11 SHORT CHIP 0 (AZ5D)R577 1-216-864-11 SHORT CHIP 0 (AZ5D)R578 1-216-864-11 SHORT CHIP 0 (AZ5D)

R579 1-216-809-11 METAL CHIP 100 5% 1/10W(AZ5D)

R580 1-216-818-11 METAL CHIP 560 5% 1/10W(AZ5D)


R582 1-216-864-11 SHORT CHIP 0 (AZ5D)R583 1-220-942-11 METAL CHIP 3.3 1% 1/4W

(AZ5D)

R584 1-220-942-11 METAL CHIP 3.3 1% 1/4W(AZ5D)

R585 1-216-864-11 SHORT CHIP 0 (AZ5D)R586 1-216-065-00 RES-CHIP 4.7K 5% 1/10W

(AZ5D)R587 1-216-065-00 RES-CHIP 4.7K 5% 1/10W


(AZ5D)

R589 1-216-809-11 METAL CHIP 100 5% 1/10W(AZ5D)

R590 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)

R591 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)







R599 1-216-809-11 METAL CHIP 100 5% 1/10W(AZ5D)

R600 1-216-809-11 METAL CHIP 100 5% 1/10WR602 1-216-864-11 SHORT CHIP 0 (AZ5D)R603 1-216-809-11 METAL CHIP 100 5% 1/10W

(AZ5D)R604 1-216-864-11 SHORT CHIP 0 (AZ5D)R607 1-216-864-11 SHORT CHIP 0 (AZ5D)


(AZ5D)R610 1-216-818-11 METAL CHIP 560 5% 1/10W



R613 1-220-942-11 METAL CHIP 3.3 1% 1/4W(AZ5D)

R614 1-220-942-11 METAL CHIP 3.3 1% 1/4W(AZ5D)

R615 1-216-864-11 SHORT CHIP 0 (AZ5D)R616 1-216-864-11 SHORT CHIP 0R617 1-216-833-11 METAL CHIP 10K 5% 1/10W

(AZ5D)

R618 1-216-065-00 RES-CHIP 4.7K 5% 1/10W(AZ5D)

R619 1-216-065-00 RES-CHIP 4.7K 5% 1/10W(AZ5D)





R632 1-216-818-11 METAL CHIP 560 5% 1/10W(AZ5D)

R633 1-216-809-11 METAL CHIP 100 5% 1/10W(AZ5D)

R634 1-216-864-11 SHORT CHIP 0 (AZ5D)R637 1-216-864-11 SHORT CHIP 0 (AZ5D)


(AZ5D)R640 1-216-864-11 SHORT CHIP 0 (AZ5D)R642 1-216-864-11 SHORT CHIP 0 (AZ5D)

S-MASTER


106

HCD-AZ2D/AZ5D

R643 1-220-942-11 METAL CHIP 3.3 1% 1/4W(AZ5D)

R644 1-220-942-11 METAL CHIP 3.3 1% 1/4W(AZ5D)


(AZ5D)R647 1-216-809-11 METAL CHIP 100 5% 1/10W

(AZ5D)R648 1-216-065-00 RES-CHIP 4.7K 5% 1/10W

(AZ5D)

R649 1-216-065-00 RES-CHIP 4.7K 5% 1/10W(AZ5D)

R650 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)

R651 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)





R657 1-216-845-11 METAL CHIP 100K 5% 1/10WR658 1-216-864-11 SHORT CHIP 0R661 1-216-791-11 METAL CHIP 3.3 5% 1/10W

(AZ5D)


(AZ5D)R664 1-216-864-11 SHORT CHIP 0 (AZ5D)R665 1-216-835-11 METAL CHIP 15K 5% 1/10W

(AZ5D)R666 1-216-791-11 METAL CHIP 3.3 5% 1/10W

(AZ5D)

R667 1-216-800-11 METAL CHIP 18 5% 1/10W(AZ5D)

R668 1-216-800-11 METAL CHIP 18 5% 1/10W(AZ5D)

R671 1-216-864-11 SHORT CHIP 0 (AZ5D)R672 1-216-864-11 SHORT CHIP 0 (AZ5D)R677 1-216-833-11 METAL CHIP 10K 5% 1/10W

R678 1-216-065-00 RES-CHIP 4.7K 5% 1/10W(AZ5D)

R679 1-216-065-00 RES-CHIP 4.7K 5% 1/10W(AZ5D)

R680 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)

R681 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)




R685 1-216-833-11 METAL CHIP 10K 5% 1/10WR686 1-216-864-11 SHORT CHIP 0R691 1-216-791-11 METAL CHIP 3.3 5% 1/10W

(AZ5D)


(AZ5D)R694 1-216-864-11 SHORT CHIP 0 (AZ5D)R695 1-216-791-11 METAL CHIP 3.3 5% 1/10W

(AZ5D)R696 1-216-791-11 METAL CHIP 3.3 5% 1/10W

(AZ5D)

R697 1-216-800-11 METAL CHIP 18 5% 1/10W(AZ5D)

R698 1-216-800-11 METAL CHIP 18 5% 1/10W(AZ5D)

R706 1-216-065-00 RES-CHIP 4.7K 5% 1/10W(AZ5D)

R707 1-216-065-00 RES-CHIP 4.7K 5% 1/10W(AZ5D)

R710 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)

R711 1-216-790-11 METAL CHIP 2.7 5% 1/10W(AZ5D)






R722 1-216-864-11 SHORT CHIP 0R723 1-216-809-11 METAL CHIP 100 5% 1/10WR724 1-216-864-11 SHORT CHIP 0R727 1-216-864-11 SHORT CHIP 0

R728 1-216-864-11 SHORT CHIP 0R729 1-216-809-11 METAL CHIP 100 5% 1/10WR730 1-216-818-11 METAL CHIP 560 5% 1/10WR731 1-216-837-11 METAL CHIP 22K 5% 1/10WR732 1-216-864-11 SHORT CHIP 0

R733 1-220-942-11 METAL CHIP 3.3 1% 1/4WR734 1-220-942-11 METAL CHIP 3.3 1% 1/4WR735 1-216-864-11 SHORT CHIP 0R738 1-216-065-00 RES-CHIP 4.7K 5% 1/10WR739 1-216-065-00 RES-CHIP 4.7K 5% 1/10W

R740 1-216-790-11 METAL CHIP 2.7 5% 1/10WR741 1-216-790-11 METAL CHIP 2.7 5% 1/10WR742 1-216-845-11 METAL CHIP 100K 5% 1/10WR743 1-216-845-11 METAL CHIP 100K 5% 1/10WR744 1-216-845-11 METAL CHIP 100K 5% 1/10W

R746 1-216-821-11 METAL CHIP 1K 5% 1/10WR747 1-219-365-11 SHORT CHIP 0R748 1-219-365-11 SHORT CHIP 0R749 1-219-365-11 SHORT CHIP 0R750 1-219-365-11 SHORT CHIP 0

R751 1-216-837-11 METAL CHIP 22K 5% 1/10WR752 1-216-818-11 METAL CHIP 560 5% 1/10WR753 1-216-809-11 METAL CHIP 100 5% 1/10WR754 1-216-864-11 SHORT CHIP 0R757 1-216-864-11 SHORT CHIP 0

S-MASTER


107

HCD-AZ2D/AZ5D

R758 1-216-864-11 SHORT CHIP 0R759 1-216-809-11 METAL CHIP 100 5% 1/10WR760 1-216-864-11 SHORT CHIP 0R762 1-216-864-11 SHORT CHIP 0R763 1-220-942-11 METAL CHIP 3.3 1% 1/4W

R764 1-220-942-11 METAL CHIP 3.3 1% 1/4WR765 1-216-864-11 SHORT CHIP 0R768 1-216-065-00 RES-CHIP 4.7K 5% 1/10WR769 1-216-065-00 RES-CHIP 4.7K 5% 1/10WR770 1-216-790-11 METAL CHIP 2.7 5% 1/10W

R771 1-216-790-11 METAL CHIP 2.7 5% 1/10WR772 1-216-845-11 METAL CHIP 100K 5% 1/10WR773 1-216-845-11 METAL CHIP 100K 5% 1/10WR774 1-216-845-11 METAL CHIP 100K 5% 1/10WR775 1-216-222-00 RES-CHIP 10K 5% 1/8W

R783 1-216-821-11 METAL CHIP 1K 5% 1/10WR785 1-216-222-00 RES-CHIP 10K 5% 1/8WR786 1-216-857-11 METAL CHIP 1M 5% 1/10WR787 1-216-809-11 METAL CHIP 100 5% 1/10WR788 1-216-841-11 METAL CHIP 47K 5% 1/10W

R789 1-216-841-11 METAL CHIP 47K 5% 1/10WR790 1-216-222-00 RES-CHIP 10K 5% 1/8WR791 1-216-809-11 METAL CHIP 100 5% 1/10WR792 1-216-837-11 METAL CHIP 22K 5% 1/10WR793 1-216-837-11 METAL CHIP 22K 5% 1/10W

R794 1-216-828-11 METAL CHIP 3.9K 5% 1/10WR795 1-216-837-11 METAL CHIP 22K 5% 1/10WR796 1-216-222-00 RES-CHIP 10K 5% 1/8W

< VIBRATOR >

X501 1-795-843-11 VIBRATOR, CRYSTA (12.288MHz)X502 1-795-660-21 QUARTZ CRYSTAL UNIT (49.152MHz)

*************************************************************

SP OUT BOARD*************

< CAPACITOR >

C1113 1-131-992-11 CERAMIC CHIP 100000PF 35V(AZ2D: KR)









C1139 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC1140 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC1141 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

(AZ5D)








< CONNECTOR >

CN1100 1-691-767-11 PLUG (MICRO CONNECTOR) 5PCN1101 1-691-766-11 PLUG (MICRO CONNECTOR) 4P (AZ5D)CN1102 1-691-768-11 PLUG (MICRO CONNECTOR) 6P (AZ5D)

< COIL >

L1101 1-420-872-52 COIL, AIR-CORE (AZ2D: KR)L1102 1-420-872-52 COIL, AIR-CORE (AZ2D: KR)L1103 1-420-872-52 COIL, AIR-CORE (AZ2D: KR)L1104 1-420-872-52 COIL, AIR-CORE (AZ2D: KR)

< RESISTOR >

R1101 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

R1102 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

R1103 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

R1104 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

R1113 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

R1114 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

R1115 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

R1116 1-245-711-31 CARBON 10 5% 1/2W(AZ2D: KR)

< TERMINAL >

TM1100 1-780-224-11 TERMINAL BOARD (SP) (2P) (AZ5D)(SPEAKER FRONT L/R)

TM1100 1-780-226-11 TERMINAL BOARD (SP) (2P) (AZ2D)(SPEAKER FRONT L/R)

TM1101 1-780-225-11 TERMINAL BOARD (SP) (4P) (AZ5D)(SPEAKER SURR L/R, S.WOOFER, CENTER)

*************************************************************

VIDEO BOARD************

< CAPACITOR/JUMPER RESISTOR >

C1201 1-126-960-11 ELECT 1uF 20% 50VC1202 1-126-960-11 ELECT 1uF 20% 50VC1203 1-126-960-11 ELECT 1uF 20% 50VC1204 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1205 1-126-965-11 ELECT 22uF 20% 50V

S-MASTER SP OUT VIDEO


108

HCD-AZ2D/AZ5D

C1206 1-126-960-11 ELECT 1uF 20% 50VC1207 1-126-960-11 ELECT 1uF 20% 50VC1208 1-126-960-11 ELECT 1uF 20% 50VC1209 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1210 1-104-665-11 ELECT 100uF 20% 25V

C1211 1-126-916-11 ELECT 1000uF 20% 6.3VC1212 1-126-916-11 ELECT 1000uF 20% 6.3VC1213 1-126-916-11 ELECT 1000uF 20% 6.3VC1214 1-126-916-11 ELECT 1000uF 20% 6.3VC1215 1-126-916-11 ELECT 1000uF 20% 6.3V

C1216 1-164-156-11 CERAMIC CHIP 0.1uF 25VC1217 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1218 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1219 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1220 1-216-864-11 SHORT CHIP 0

C1221 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1222 1-216-864-11 SHORT CHIP 0C1223 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1224 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC1225 1-216-864-11 SHORT CHIP 0

< CONNECTOR >

CN1201 1-793-565-11 CONNECTOR, FFC (LIF (NON-ZIF)) 13PCN1202 1-785-315-11 PIN, CONNECTOR (STRAIGHT) 3P

< EARTH TERMINAL >

EP1201 1-537-738-21 GROUND, TERMINALEP1202 1-537-738-21 GROUND, TERMINAL

< JUMPER RESISTOR >

FB1201 1-216-864-11 SHORT CHIP 0FB1202 1-216-864-11 SHORT CHIP 0FB1203 1-216-864-11 SHORT CHIP 0FB1204 1-216-864-11 SHORT CHIP 0FB1205 1-216-864-11 SHORT CHIP 0

FB1206 1-216-864-11 SHORT CHIP 0

< IC >

IC1201 6-705-602-01 IC MM1623BFBE

< TERMINAL/JACK >

J1201 1-537-943-11 TERMINAL, S (S VIDEO OUT)J1202 1-785-867-11 JACK, PIN 1P (VIDEO OUT)J1203 1-793-445-11 JACK, PIN 3P (COMPONENT VIDEO OUT)

< COIL >

L1201 1-412-058-11 INDUCTOR 10uH

< RESISTOR >

R1202 1-216-809-11 METAL CHIP 100 5% 1/10WR1203 1-216-833-11 METAL CHIP 10K 5% 1/10WR1204 1-218-285-11 METAL CHIP 75 5% 1/10WR1205 1-218-285-11 METAL CHIP 75 5% 1/10WR1206 1-218-285-11 METAL CHIP 75 5% 1/10W

R1207 1-218-285-11 METAL CHIP 75 5% 1/10WR1208 1-218-285-11 METAL CHIP 75 5% 1/10W

R1209 1-216-809-11 METAL CHIP 100 5% 1/10WR1210 1-216-833-11 METAL CHIP 10K 5% 1/10WR1211 1-218-285-11 METAL CHIP 75 5% 1/10W

*************************************************************

MISCELLANEOUS**************

61 1-828-329-11 WIRE (FLAT TYPE) (13 CORE)62 1-828-320-11 WIRE (FLAT TYPE) (11 CORE)63 1-469-829-11 CORE, FERRITE65 1-828-936-11 WIRE (FLAT TYPE) (5 CORE)66 1-790-378-11 WIRE (FLAT TYPE) (8 CORE)

67 1-797-175-11 DECK, MECH (CMAL1Z254A) (DECK-B)101 1-828-304-11 WIRE (FLAT TYPE) (7 CORE)106 1-797-174-11 DECK, MECH (CMAL5Z230) (DECK-A)151 1-773-125-11 WIRE (FLAT TYPE) (19 CORE) (AZ2D)151 1-773-160-11 WIRE (FLAT TYPE) (21 CORE) (AZ5D)

152 1-828-002-11 WIRE (FLAT TYPE) (17 CORE) (AZ2D)152 1-828-361-11 WIRE (FLAT TYPE) (19 CORE) (AZ5D)153 1-400-640-11 CORE, FERRITE154 1-828-333-11 WIRE (FLAT TYPE) (13 CORE)155 1-828-953-11 WIRE (FLAT TYPE) (9 CORE)

157 1-693-670-11 TUNER (TM-10KR) (AZ2D: KR)157 1-693-671-11 TUNER (TM-10E) (EXCEPT AZ2D: KR)203 1-828-947-11 WIRE (FLAT TYPE) (7 CORE)204 1-400-640-11 CORE, FERRITE205 1-769-977-11 WIRE (FLAT TYPE) (13 CORE)

253 1-828-947-11 WIRE (FLAT TYPE) (7 CORE) (AZ5D)0254 1-769-079-23 CORD, POWER (AZ2D: KR)0254 1-777-071-53 CORD, POWER (AZ2D: E12, E13, EA, SP, MY,

PH/AZ5D: E12, EA, SP, MY)0254 1-783-203-13 CORD, POWER (AZ2D: AUS/AZ5D: AUS)0254 1-824-642-11 CORD, POWER (WITH CONNECTOR)

(AZ5D: TH)

0254 1-827-226-11 CORD, POWER(AZ2D: E2, E3, E15/AZ5D: E2, E3, E15)

256 1-500-386-11 FILTER, CLAMP (FERRITE CORE)256 1-500-497-11 FILTER, CLAMP (FERRITE CORE)

0257 1-468-896-11 REGULATOR, SWITCHING(AZ2D: E12, KR, AUS)0257 1-468-897-11 REGULATOR, SWITCHING

(AZ2D: E2, E3, E13, E15, EA, SP, MY, PH)

0257 1-468-898-11 REGULATOR, SWITCHING(AZ5D: E12, TH, AUS)0257 1-468-899-11 REGULATOR, SWITCHING

(AZ5D: E2, E3, E15, EA, SP, MY)356 A-1114-646-A MD (AU) ASSY

0357 8-820-291-02 OPTICAL PICK-UP BLOCK KHM-310CAB/C2RP(Including sled motor, spindle motor)

358 1-828-771-11 WIRE (FLAT TYPE) (24 CORE)

M001 X-4955-496-1 MOTOR (PULLEY) ASSY (LOADING)M901 1-787-099-11 FAN, DCM902 1-787-331-21 FAN, D.C. (AZ5D)

*************************************************************

VIDEO


109

HCD-AZ2D/AZ5D

ACCESSORIES************

0 1-569-007-11 ADAPTOR, CONVERSION 2P(AZ2D: E3, E15/AZ5D: E3, E15)

0 1-569-008-21 ADAPTOR, CONVERSION 2P(AZ2D: SP, MY, PH/AZ5D: SP, MY)

0 1-770-019-51 ADAPTOR, CONVERSION PLUG(AZ2D: EA/AZ5D: EA)

2

HCD-AZ2D/AZ5D

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.

Ver. Date Description of Revision

1.0 2005.06 New

HCD-AZ2D/AZ5D - SERVICE MANUAL

Documents

Transcript of HCD-AZ2D/AZ5D - SERVICE MANUAL